Green Car Congress

MAY 8, 2013

Future advanced engine and powertrain configurations must address emission and fuel economy requirements for worldwide applications, transition to bio-fuels, and synergies with future powertrain trends. improvement in fuel economy over the baseline engine for the Metro-Highway (M-H) cycle. improvement in fuel economy over the baseline.

Fuel Economy 278

Fuel Economy Economy Fuel Engine 278

Green Car Congress

NOVEMBER 16, 2011

The US Environmental Protection Agency (EPA) and the US Department of Transportation (DOT) formally unveiled their joint proposal to set stronger fuel economy and greenhouse gas pollution standards for Model Year 2017-2025 passenger cars and light trucks. L/100km), if the vehicles were to meet this CO 2 level all through fuel economy.

Fuel Economy 338

Fuel Economy EPA Economy MPG 338

Green Car Congress

JULY 26, 2012

The 2012 APEAL Study finds that 27% of new-vehicle buyers who replaced a vehicle downsized—i.e., The downsizing trend also has an impact on owner satisfaction with the fuel economy of their new vehicle. purchased a new vehicle in a smaller segment than the vehicle they replaced. Power and Associates.

Downsizing 210

Downsizing 2012 Vehicles Power 210

Green Car Congress

DECEMBER 10, 2009

In addition to demonstrating better fuel consumption results than current advanced gasoline engines, the Omnivore engine has successfully demonstrated homogeneous charge compression ignition (HCCI) down to extremely light loads. Jamie Turner, Chief Engineer of Powertrain Research at Lotus Engineering.

Fuel Economy 218

Fuel Economy Engine Light Fuel 218

Green Car Congress

APRIL 14, 2011

Results of this study showed that the pre-chamber jet ignition combustion system roughly matches HCCI fuel economy across both NEDC and FTP drive cycles, with a 13% improvement in fuel economy recorded over the baseline stoichiometric (λ=1) spark ignition combustion system. Click to enlarge. liter) GM engine.

Fuel Economy 210

Fuel Economy Economy Engine Fuel 210

Green Car Congress

APRIL 2, 2010

Yesterday, the US Environmental Protection Agency (EPA) and the National High Traffic Safety Administration (NHTSA) jointly established increasingly stringent greenhouse gas emission standards under the Clean Air Act for 2012 through 2016 model-year vehicles and fuel economy standards under the Corporate Average Fuel Economy program, respectively.

EPA 236

EPA Standards Light PHEV 236

Green Car Congress

DECEMBER 11, 2011

Light duty vehicle fleet by type and average fuel efficiency. Growth is led by developing regions such as China, India, Africa and other emerging economies. Growth is led by developing regions such as China, India, Africa and other emerging economies. Source: ExxonMobil Outlook. Click to enlarge. L/100 km) by 2040.

Personal 408

Personal Global Transportation Fuel 408

Green Car Congress

APRIL 6, 2016

This trend of increasing demand for higher octane gasoline is likely driven by changes in fuel requirements for light-duty vehicles (LDV) in response to increasing fuel economy standards, which will have widespread implications for future gasoline markets, according to EIA analysts. of the LDV market by 2025.

Downsizing 150

Downsizing Gasoline Engine Design 150

Green Car Congress

DECEMBER 20, 2009

Ford views EcoBoost as a strategy as well as a product—one that will serve as a key element of Ford’s CO 2 and fuel economy product strategy—said Dan Kapp, Director, Ford Powertrain Research and Advanced Engineering, during a briefing on the company’s fuel economy strategies in Dearborn. Planning background.

Fuel Economy 186

Fuel Economy Economy Ford Downsizing 186

Green Car Congress

JANUARY 26, 2012

The company’s engineers have a prototype system running in a B-segment donor vehicle on a dynamometer and are calibrating the control strategy to prove its driveability, performance, CO 2 and fuel economy benefits. Both solutions involve part load losses which compromise some of the fuel consumption savings made by downsizing.

Downsizing 270

Downsizing Vehicles Fuel Economy 2010 270

Green Car Congress

JULY 11, 2017

The ICCT team—John German and Aaron Isenstadt—concluded that diesels have and will retain two significant advantages over gasoline engines: significantly better fuel economy and cargo hauling and towing ability. Meeting the 2025 standard will require an average improvement in fuel economy of about 4.1% Background.

Diesel 186

Diesel Light Fuel Economy 2017 186

Green Car Congress

JUNE 14, 2011

Based on the results of the study, CAR believes the economic risk to the auto industry connected to mandating permanent fuel economy standards in the long run is “ very serious ” The group recommends periodic review to assess the rate of technology development and cost reduction of advanced technologies leading up to 2025.

Fuel Economy 199

Fuel Economy Economy Auto Industry Standards 199

Green Car Congress

JANUARY 11, 2010

The remaining six projects totaling more than $71 million will support efforts to increase the fuel economy for passenger vehicle engines and powertrain systems. The goal is to develop engine technologies that will improve the fuel economy of passenger vehicles by 25-40% by 2015 using an engine-only approach. 38,831,115. 39,559,868.

Fuel Economy 199

Fuel Economy Downsizing Vehicles Waste 199

Green Car Congress

JANUARY 10, 2013

Even in the BRICs, ICE downsizing has become a big deal. The survey found that most companies are hedging their bets and spreading funding across a wide range of areas, with ICE downsizing and plug-in hybrids expected to receive the greatest investment over the next 5 years. —“14 th Annual Global Automotive Executive Survey”.

Downsizing 231

Downsizing Global Auto Brazil 231

Green Car Congress

DECEMBER 19, 2013

Annual stop-start light duty vehicle sales by region, world markets: 2013-2022. By 2022, total global annual sales for light duty stop-start vehicles (SSVs) will exceed 55 million, accounting for 54.3% Source: Navigant. Click to enlarge. of total vehicle sales, according to a new report by Navigant Research. By then, 82.8%

North America 273

North America Vehicles Global Sale 273

Green Car Congress

SEPTEMBER 30, 2014

Automakers are turning to downsized turbocharged engines to satisfy more stringent global fuel economy and emission regulations and customer demand for better-performing vehicles. In addition to improving fuel efficiency, downsized turbocharged engines also reduce harmful exhaust emissions.

2019 261

2019 Global Sale Downsizing 261

Green Car Congress

OCTOBER 23, 2014

of total worldwide light-duty vehicle sales by 2023, or about 2.5 Of note are fuel efficiency advances made to conventional internal combustion engines (ICEs) through stop-start technologies, the use of lightweight materials for body panels and chassis, engine downsizing, and growing interest in diesel. million units. Source: Navigant.

Plug-in 276

Plug-in Plug Global Li-ion 276

Green Car Congress

JUNE 16, 2011

To address this request, the NRC formed the Committee on the Assessment of Technologies for Improving Light-Duty Vehicle Fuel Economy. Further, the benefits of some technologies are not completely represented in the tests used to estimate corporate average fuel economy (CAFE).

Fuel 210

Fuel Downsizing Fuel Economy Diesel 210

Green Car Congress

JUNE 25, 2012

reduction in fuel consumption achieved with XL Hybrids’ aftermarket hybrid electric powertrain ( earlier post ) on a light-duty cargo van on the UDDS cycle (urban conditions). The tests were conducted on ESWA’s light-duty chassis dynamometer test cell featuring a twin-roll Clayton dynamometer. kWh, Ashton said. Both the 2.0

Hybrid 330

Hybrid Fuel Lithium Ion Downsizing 330

Green Car Congress

MARCH 5, 2013

Vehicle size, a key determinant of fuel economy, has shown a reduction in OECD countries, while the non-OECD trend is toward bigger vehicles. The analysis, an update of an earlier work using data from 2010 and 2011, found that the global average for light-duty vehicle fuel economy was 7.2 Source: GFEI. Click to enlarge.

Fuel Economy 170

Fuel Economy Economy Fuel 2005 170

Green Car Congress

OCTOBER 10, 2012

The analysis used the Ohio State University EcoCAR, a student prototype PHEV, as the basis for the preliminary fuel economy evaluation. Internal combustion engines have been significantly improving in the past decade, after the adoption of technologies such as Gasoline Direct Injection, mild electrification, downsizing and turbocharging.

Waste 312

Waste PHEV Fuel Exhaust 312

Green Car Congress

DECEMBER 17, 2015

The engine should yield fuel efficiency gains of more than 50% compared to a downsized, turbo-charged gasoline direct injection engine, while reducing the overall cost of the powertrain system, said Fabien Redon, Vice President, Technology Development at Achates Power. Earlier post.) Earlier post.). Earlier post.). Fabien Redon.

Downsizing 150

Downsizing Engine Fuel Gasoline 150

Green Car Congress

APRIL 8, 2015

In a new report, Navigant Research forecasts that total annual global light-duty start-stop vehicle (SSVs) sales will reach 59 million, accounting for 55% of all light duty vehicle sales. This also offers opportunities for other engine efficiencies such as electric boost. —“ Start-Stop Vehicles ”.

Light 150

Light North America Global 2015 150

Green Car Congress

SEPTEMBER 9, 2014

Engine downsizing through charge boosting is a well-recognized means of improving internal combustion engine fuel efficiency, by increasing the proportion of the drive cycle at which the powertrain operates within or close to the region of peak fuel efficiency of its operating map. 48V Diesel Fuel Efficiency'

Diesel 231

Diesel Downsizing Lead Acid Gasoline-Electric 231

Green Car Congress

APRIL 18, 2013

Emerging economies are stepping up their efforts to promote and develop clean energy. Many countries, including emerging economies, introduced or strengthened energy efficiency regulations. Fuel economy improvements accelerate where implementation of fuel economy standards and other policy measures has been scaled up, the report notes.

Carbon 265

Carbon Supplies Global Transportation 265

Green Car Congress

MAY 1, 2012

This concept system is expected to be ideal for heavily downsized applications and developing markets. Delphi also showcased its light-weight new Unit Pump Common Rail (UPCR) system, a cost-effective concept specifically designed for diesel engines with one to four cylinders. New high pressure heavy duty common rail systems.

Engine 199

Engine Light Diesel 2000 199

Green Car Congress

JUNE 4, 2010

Various combinations of commercially available technologies could greatly reduce fuel consumption in passenger cars, sport-utility vehicles, minivans, and other light-duty vehicles over the next 15 years without compromising vehicle performance or safety, according to a new report by the National Research Council. Engines and Technologies.

Purchase 210

Purchase Lithium Ion Fuel Fuel Economy 210

Green Car Congress

OCTOBER 25, 2012

FEV performed engine mappings in a dynamometer test cell to evaluate the fuel economy of Pinnacle’s TP90 scooter engine compared to a benchmark engine (N15) from Pinnacle’s Asian OEM partner. This combination of variable compression ratio and our operating mode gets us huge fuel economy wins.

Engine 262

Engine Fuel Fuel Economy Production 262

Green Car Congress

JULY 28, 2014

However, Navigant foresees that the consumption of gasoline will slowly decrease as alternatives and diesel become more popular in light-duty vehicle (LDV) segments. Relatively modest incremental fuel economy improvements of 2 mpg to 3 mpg per vehicle can have significant impacts on global oil demand. Conventional fuels (e.g.,

Transportation 255

Transportation Global Fuel Alternative Fuels 255

Green Car Congress

MAY 16, 2019

Reducing engine-out emissions cuts tailpipe emissions in the crucial period before catalyst light-off and reduces the need for costly aftertreatment systems. The industry has long recognized that increasing injection pressure to 500+ bar could substantially cut engine-out particulates while improving CO2 emissions and fuel economy.

Emissions 257

Emissions Gasoline Fuel Exhaust 257

Green Car Congress

MAY 27, 2014

To develop the ranking, UCS averaged the per-mile emissions for each light-duty vehicle sold by each automaker. To determine GHG emissions, UCS considered the fuel economy, fuel type, and sales volume of each type of vehicle sold by each automaker in the 2013 model year (MY2013). Source: UCS. Click to enlarge. Methodology.

2013 299

2013 Kia Hyundai Sale 299

Green Car Congress

OCTOBER 5, 2011

” Bunker spent the bulk of his presentation describing the new medium- and heavy-duty fuel economy and greenhouse gas regulations from EPA and the Department of Transportation. The future that we point to [is] very conventional-looking engines.” Earlier post.) non-petroleum-based—for transportation.

International 265

International Engine Future EPA 265

Green Car Congress

SEPTEMBER 12, 2011

The report expects aluminum to double its share of the light vehicle material mix by 2025 vs. the 2008 EPA baseline vehicle. Using aluminum will extend the efficiencies of other technologies, while enabling secondary cost-savings from downsized powertrains without sacrificing performance. kg) per year per light vehicle.

2012 186

2012 Downsizing Auto Industry 186

Green Car Congress

AUGUST 11, 2014

GMZ Energy and its partners are on track to deliver a 1 kW thermoelectric generator (TEG) for the Bradley Fighting Vehicle as well as to design and to integrate a light-duty vehicle TEG into a Honda Accord as part of a DOE-funded project. GMZ is targeting a fuel economy improvement of 5%. down-speeding, downsized engine, etc.),

Honda 231

Honda Houston North America Vehicles 231

Green Car Congress

SEPTEMBER 12, 2012

Below this GVW the technology has already been acquired by Valeo as a supercharger for cars and light commercial vehicle applications. Earlier post.) Cobra is particularly relevant to Tier 4 Interim legislation that comes into effect this year for off-road vehicles, according to the company. —CPT program manager Andy Dickinson.

Water 370

Water Engine Commercial Diesel 370

Green Car Congress

OCTOBER 25, 2012

In keeping with the trend to downsizing, Hyundai has been expanding the application of Turbo Gasoline Direct Injection (T-GDI) engines. Hyundai will continue its efforts to develop light-weight and fuel-efficient transmissions. A variety of technologies were adopted to maximize fuel economy and performance of the Kappa 1.0

Hyundai 218

Hyundai Future Gasoline Exhaust 218

Green Car Congress

MAY 12, 2017

Gasoline direct-injection (GDI) engines have higher fuel economy compared to the more widely used port fuel injection (PFI) engines. In this study, we present a comprehensive database of emissions from a fleet of GDI- and PFI-equipped light-duty gasoline vehicles tested on a chassis dynamometer over the cold-start unified cycle (UC).

Fleet 207

Fleet Engine Fuel Economy Global 207