Green Car Congress

APRIL 26, 2023

This applies to all standard biofuels such as HVO (Hydrotreated Vegetable Oil) and FAME (Fatty Acid Methyl Ester) fuels up to a content of 100%. Due to its state-of-the-art design, just a few engine components are subject to slightly higher wear, depending on the amount of biofuel and the duration of operation.

Engine 284

Engine Mariner Fuel Exhaust 284

Green Car Congress

JANUARY 28, 2021

Achates Power will begin the study and design of the initial tactical vehicle concept engine and has selected Southwest Research Institute (SwRI) to contribute its expertise in advanced materials to reduce heat rejection and improve power density and efficiency. The variable flow lube pump helps maintain engine efficiency.

Power 418

Power Powered Vehicles Exhaust 418

Green Car Congress

NOVEMBER 25, 2015

Federal-Mogul Powertrain, a division of Federal-Mogul Holdings Corporation, has developed a new piston ring for two-stroke diesel engines that reduces oil consumption and marine pollution by allowing the quantity of lubricant used to be greatly reduced. This feed oil is not uniformly distributed on the cylinder wall. Click to enlarge.

Mariner 150

Mariner Oil Pollution Diesel 150

Green Car Congress

NOVEMBER 10, 2019

Combustion exhaust is directed to the fuel cell, which produces power while capturing and concentrating carbon dioxide for permanent storage. The modular design enables the technology to be deployed at a wide range of locations, which could lead to a more cost-efficient path for large-scale deployment of carbon capture and sequestration.

Carbon 360

Carbon Fuel Exhaust Energy 360

Green Car Congress

JULY 17, 2023

To utilize its dual-fuel potential in Tier III areas fully, the engine is being offered with Exhaust Gas Recirculation (EGR) that reduces methane-slip emissions compared to first-generation, Otto-cycle engines without EGR. This successful gas trial is a very important milestone in the development of the ME-GA engine. —Thomas S.

Gas 195

Gas Engine Concept Exhaust 195

Green Car Congress

SEPTEMBER 16, 2014

division, maker of the Delo brand of heavy duty engine oils, lubricants and coolants, unveiled a new category of heavy duty motor oil designed to address the growth of severe duty applications in on- and off-highway markets. A critical part of this process is to find an engine oil which is not just heavy duty, but severe duty.

Chevron 210

Chevron Fuel Economy Oil Economy 210

Green Car Congress

SEPTEMBER 20, 2021

Exhaust cooling starts with the computer-optimized exhaust valve shape and is further enhanced by the integrated exhaust manifold and cylinder head design that uses the same water jacket to lower exhaust gas temperature entering the turbochargers to further improve reliability and performance.

Tundra 418

Tundra Toyota Hybrid Nickel Metal Hydride 418

Green Car Congress

MARCH 22, 2014

liter diesel, prominently showing the closely attached exhaust aftertreatment system. The EA288 is designed to meet the requirements of different markets. extension of the oil return and blow-by channels to the parting plane of the oil pan. The dual oil and vacuum pump unit. Oil and vacuum pump. The EA288 2.0-liter

Diesel 384

Diesel Engine Exhaust Water 384

Green Car Congress

JULY 18, 2023

Originally ordered in Q2 2021 and scheduled for delivery in July 2023, the ship is powered by MAN B&W ME-GA dual-fuel engines capable of running on fuel oil and LNG, and comes with Exhaust Gas Recirculation (EGR) for emission reduction. Earlier post.) ME-GA-opti continues this trend and will further boost the ME-GA’s reputation.

Gas 150

Gas Engine Oil Fuel 150

Green Car Congress

MARCH 30, 2023

The engine also retains well-proven MAN technolgies such as the gas-injection system, pilot-fuel-oil system and MAN SCR (Selective Catalytic Reduction) system. The MAN 49/60DF can operate and even start in gas mode where it complies with IMO Tier III without exhaust gas after-treatment.

Diesel 259

Diesel Gas Mariner Engine 259

Green Car Congress

APRIL 18, 2016

The new engine is fitted with an exhaust gas heat recovery (EGHR) system. The engine—dedicated to the hybrid system—features cooled Exhaust Gas Recirculation (EGR)to reduce pumping losses, and incorporates a hybrid dedicated combustion system with relatively high compression ratio of 11.5:1. Features of the new 1.8-liter

Malibu Hybrid 150

Malibu Hybrid 2016 Chevrolet Design 150

Green Car Congress

OCTOBER 29, 2016

The International Maritime Organization (IMO), the regulatory authority for international shipping, decided to implement a global sulfur cap of 0.50% m/m (mass/mass) (5,000 ppm) on fuel oil starting 1 January 2020 during its Marine Environment Protection Committee (MEPC), meeting for its 70 th session in London.

Oil 150

Oil 2020 Puerto Rico Virgin Islands 150

Green Car Congress

FEBRUARY 6, 2013

developer of the all-fuel, external combustion Cyclone Engine, signed an agreement with The Ohio State University’s Center for Automotive Research (OSU CAR) to perform design analysis and testing services for the company. Cyclone Power Technologies Inc.,

Engine 218

Engine Columbus Design Ohio 218

Green Car Congress

JULY 11, 2020

The exhaust gas recirculation (EGR) system design has been updated to a dual loop (low and high pressure) system. High-pressure (29,000 psi/2,000 bar) direct-injection fuel injector nozzles were redesigned to match the newly designed and optimized combustion chamber, reducing fuel consumption. 1 from 16.5:1

Jeep 269

Jeep Available Fuel Economy Economy 269

Green Car Congress

APRIL 26, 2022

Odor causing VOCs such as jet fuel smell and odorous organic acids can enter the cabin from exhaust fumes, engine oil and hydraulic leaks, as well as de-icing fluid ingestion. The air at high altitude contains significant levels of ozone.

Ozone 195

Ozone Convert Cleaner Exhaust 195

Green Car Congress

JULY 15, 2022

Time constraints and the need to consider sustainability aspects that are playing an ever more critical role in motor racing, as well as the automobile industry in general, meant that returning to the drawing board to design a completely new engine and building it at great cost was not an option. Oil system. BMW M Hybrid V8 engine.

BMW 293

BMW Engine Hybrid Oil 293

Green Car Congress

DECEMBER 20, 2018

Certification in accordance with the Euro 6d standard (RDE stage 2) not prescribed for new models until 1 January 2020 is possible due to measures including extended exhaust gas aftertreatment with an additional underbody SCR catalytic converter including ammonia slip catalyst (ASC) in the underbody.

Diesel 326

Diesel Mercedes SUV Exhaust 326

Green Car Congress

APRIL 30, 2018

This next-generation concept truck features a custom, aerodynamic design and aims to demonstrate improvements in fuel economy for Class 8 trucks. Bespoke design, elongated flaps fit. Starship uses full synthetic Shell Heavy Duty Engine Oil; Shell Rotella DEF Diesel Exhaust Fluid and Shell ROTELLA Extended Life Coolant; and.

San Diego 281

San Diego Fuel Jacksonville Fuel Economy 281

Green Car Congress

JUNE 5, 2012

The Shanghai Merchant Ship Design & Research Institute (SDARI) and development partners DNV and Wärtsilä have unveiled a new Handysize—i.e., ships with a cargo-carrying capability of less than 60,000 metric tonnes—bulk carrier concept design: the Green Dolphin. Draught, design. Speed at design draught.

2020 294

2020 Design Concept Fuel 294

Green Car Congress

JULY 2, 2022

As a result, shipbuilders and operators around the world are seeking environmentally friendly alternatives to conventional ship engines powered by fuel oil or diesel. It is then fed into the engine, which it drives by burning in a conventional combustion engine and generates absolutely no exhaust gases that are harmful to the climate.

Hydrogen 480

Hydrogen Engine Fuel Carbon 480

Green Car Congress

JUNE 8, 2019

This means that the turbocharger and the exhaust manifold are now positioned at the rear, on the side of the firewall when viewed from behind. This configuration allows the flattest possible and aerodynamically advantageous front section design. Fresh air is used in addition to oil and water to cool the turbocharger.

Mercedes 277

Mercedes Exhaust Oil-Sands Engine 277

Green Car Congress

APRIL 23, 2015

With automotive design trending toward smaller engine compartments, increased exhaust gas recirculation and decreased air flow, the high-end temperatures in underhood environments are climbing and, more importantly, driving the performance requirements for FSRs to extremes not previously required.

Design 150

Design Polymer Congress Exhaust 150

Green Car Congress

OCTOBER 12, 2017

Air Products and Chemicals designed, built, and is operating the state-of-the-art CO 2 -capture and storage system at their hydrogen-production facility located at the Valero Port Arthur Refinery in Port Arthur, Texas. The CO 2 captured from the Port Arthur facility is being used for EOR at the West Hastings Unit oil field in southeast Texas.

CO2 186

CO2 Texas Oil Store 186

Green Car Congress

DECEMBER 13, 2017

Southwest Research Institute recently opened a new fully automated, multi-fuel burner facility designed to rapidly and cost-effectively age and evaluate exhaust catalyst equipment for a wide range of engines. SwRI has also improved system controls, allowing precise control of low exhaust flow rates. .

Emissions 150

Emissions Exhaust Production Gasoline 150

Green Car Congress

MARCH 15, 2011

MAN Diesel & Turbo has designed an LNG-fueled two-stroke ME-GI engine for DNV’s mew concept Quantum 9000 container ship. The gas supply line is designed with ventilated double-wall piping and HC sensors for safety shutdown. The control and safety system is designed to “fail to safe conditions”.

Design 199

Design Engine Diesel Fuel 199

Green Car Congress

OCTOBER 9, 2019

In the editorial, the researchers note that internal combustion engines operating on fossil fuel oil provide about 25% of the world’s power (about 3,000 out of 13,000 million tons oil equivalent per year), and in doing so, they produce about 10% of the world’s greenhouse gas (GHG) emissions. road dust) are accounted for. Gas exchange.

International 312

International Engine Exhaust Emissions 312

Green Car Congress

OCTOBER 24, 2012

The LT1 camshaft design is based on the LS3’s cam tuning (14mm gross intake lift) and offers 62 crank degrees of cam phasing authority. The LT1 head features smaller combustion chambers designed to complement the volume of the unique topography of the pistons’ heads. All-aluminum block and oil pan.

2014 362

2014 Oil Exhaust Engine 362

Green Car Congress

MAY 21, 2015

The new Veradel grade is a tough, high-performance resin designed to meet growing global demand for advanced polymers that can improve automotive powertrain efficiency and reduce carbon emissions. This high-performing polymer also delivers good dimensional stability and strong resistance to oil and exhaust gases.

Polymer 150

Polymer F-150 Carbon Fiber Exhaust 150

Green Car Congress

SEPTEMBER 24, 2016

CDTi Whisper Diesel ( earlier post ) in Europe, and is derived from a common Italian-German-American medium diesel engine design, according to GM. A variable-vane turbocharger enables the engine to deliver more power with lower exhaust emissions and no decrease in overall fuel efficiency. The first application of the 1.6L

Diesel 150

Diesel 2018 Exhaust Chevrolet 150

Green Car Congress

MARCH 31, 2021

Extensive modifications to the drive, chassis, design and equipment will provide the hallmark AMG driving experience with all-electric drive. The power of the electric motor is applied immediately with full torque, a characteristic of the design. The system is designed to ensure even heat distribution in the battery.

Mercedes 448

Mercedes Hybrid Batteries Battery 448

Green Car Congress

JULY 16, 2020

for XSE grade, which uses a dual-outlet exhaust). Most AWD grades have 202 hp, while the Camry XSE AWD grade has 205 hp with dual exhaust. A variable cooling system, variable oil pump and a cooled exhaust gas recirculation (EGR) system all contribute to the engine’s high thermal efficiency and outstanding fuel economy.

Toyota 400

Toyota Hybrid Camry Hybrid Exhaust 400

Green Car Congress

SEPTEMBER 14, 2018

When designing commercial vehicles with a fuel cell drive, the high hydrogen storage pressures of around 700 bar are not the only challenge. Fuel cells are also sensitive to oil admixtures. The electric compressor used to compress the supply air flow must therefore be oil-free. Exhaust pathway. Compressor.

Commercial 223

Commercial Fuel Vehicles Water 223

Green Car Congress

SEPTEMBER 9, 2013

Designed by Fiat, which employs the engine in numerous applications including Class 2, 3 and 4 commercial vehicles, the 16-valve, dual-overhead cam I-4 has been adapted for the North American market with a wide range of modifications that enable regulatory compliance, while also enhancing performance. Further refinement in the 3.0L

2014 291

2014 Chrysler Diesel Oil 291

Green Car Congress

SEPTEMBER 20, 2012

Increased efficiency in all of the new Ecotec engines is achieved in part through lower engine friction, which was reduced by up to 16% using new technologies such as a variable-displacement oil pump. Modular balance shaft system in the oil pan. Rotocast aluminum cylinder head with sodium-filled exhaust valves.

2013 236

2013 Oil-Sands Chevrolet Sodium 236

Green Car Congress

AUGUST 20, 2019

The valve train is the “respiratory organ” of combustion engines: it manages the aspiration of fresh air and the discharge of exhaust gases (gas exchange). The basic principle of the valve train—for both intake and exhaust side—is an asymmetric hydraulic pendulum, which can be described as a mass-spring-system. Image: Empa.

Fuel 220

Fuel Gas-Electric Exhaust Gas 220

Green Car Congress

DECEMBER 13, 2012

The newly unveiled 2014 Chevrolet Silverado 1500 and GMC Sierra 1500 pickup trucks will deliver more power, more torque and improved fuel efficiency, partly due to a trio of all-new EcoTec3 engines designed specifically for the needs of full-size truck customers. The deep-skirt block design helps maximize strength and minimize vibration.

Sierra 218

Sierra Silverado 2014 Engine 218

Green Car Congress

JUNE 17, 2016

All the heavy-duty engines benefit from new low-friction engine oils. In contrast to the OM 471, the principle of the seven-hole injection nozzle has been retained, on account of the compact design. With its optimized injection and combustion, the engine is systematically designed for low fuel consumption.

Mercedes 150

Mercedes Engine Fuel Emissions 150