Green Car Congress

JUNE 23, 2014

Resources (DOE will publish Merit Review presentations on its website.). Purdue University will work with the team on variable valve train options for warm up and HC control, all leading to the final T2B2 demonstration on a complete, street worthy, driveable vehicle.

Fuel Economy 357

Fuel Economy Economy Gasoline Downsizing 357

Green Car Congress

NOVEMBER 1, 2016

In its new report on downsized and boosted gasoline engine technologies ( earlier post ) the ICCT highlighted Ricardo’s work on an “extreme” Miller cycle concept with high (13:1) compression ratio (CR) and central direct injection in a downsized boosted engine. Resources. Ricardo continues to develop the concept.

Concept 150

Concept Downsizing 2016 Congress 150

Green Car Congress

JUNE 7, 2021

Notably, we highlight the importance of fast charging, which is essential for downsizing aircraft and batteries to reduce cost while achieving high vehicle use rates to maximize revenues. Further, eVTOL batteries should continue functioning even after a safety incident occurs until a safe landing. —Yang et al. Yang et al. Yang et al.

Batteries 243

Batteries Battery Li-ion Downsizing 243

Green Car Congress

NOVEMBER 15, 2009

Federal-Mogul Corporation has developed an innovative aluminum piston design that can reliably withstand the mechanical and thermal loads produced by heavily boosted engines, thereby enhancing diesel engine performance and supporting diesel downsizing. The grain size of the re-melted part is approximately one tenth of the as-cast size.

Downsizing 210

Downsizing Diesel Engine Design 210

Green Car Congress

NOVEMBER 3, 2022

Our fast-charging technology works for most energy-dense batteries and will open a new possibility to downsize electric vehicle batteries from 150 to 50 kWh without causing drivers to feel range anxiety. Credit: EC Power. The work was supported by the US Department of Energy, the US Department of Defense, the US Air Force and the William E.

International 273

International Charging Power Powered 273

Green Car Congress

AUGUST 2, 2009

In contrast, the standards recently announced by the Obama Administration, while attainable, require downsizing and a shift in the fleet mix away from SUVs. More rapid technological progress makes the standards easier to achieve, but still requires changes in fleet characteristics, either through the car/truck mix or weight and engine size.

Fuel Economy 210

Fuel Economy Downsizing Obama Economy 210

Green Car Congress

APRIL 20, 2010

compacts under 1,400 kg in weight—a stoichiometric 3-cylinder turbocharged gasoline direct injection (GDI) engine offers an optimal combination of cost, lower emissions and reductions in fuel consumption, according to an analysis by Delphi Powertrain presented at the recent SAE 2010 World Congress. Earlier post.). Kirwan et al.

Gasoline 231

Gasoline Downsizing Engine CO2 231

Green Car Congress

JANUARY 19, 2021

The very fast charge allows us to downsize the battery without incurring range anxiety. The researchers said that the key to long-life and rapid recharging is the battery’s ability to heat up quickly to 60 ?C C for charge and discharge, and then cool down when the battery is not working. —Professor Wang.

Market 305

Market Batteries Battery Charging 305

Green Car Congress

JULY 24, 2009

The California Air Resources Board adopted amendments to help business owners comply with its 2007 regulation aimed at reducing toxic diesel emissions from the state’s estimated 180,000 off-road vehicles such as tractors and bulldozers used in construction, mining and other industries. Earlier post.).

Diesel 150

Diesel Emissions 2007 Fleet 150

Green Car Congress

FEBRUARY 1, 2009

A member of the ETH research team, which is led by Lino Guzzella, Professor of Thermotronics, will present a paper on their work at the upcoming SAE World Congress 2009 in Detroit in April—one of a number to be presented on the topic there. The compressed air supply also allows extreme downsizing. Dönitz et al.

Hybrid 199

Hybrid Engine Downsizing 2009 199

Green Car Congress

APRIL 19, 2013

The team presented a paper on their work at the 2013 SAE World Congress in Detroit. Given the properties of the fuel blend, improved fuel efficiencies can be generated by several approaches, including downsizing/downspeeding; increased compression ratio; reduced enrichment; and the leveraging of improved efficiency at part load.

Engine 253

Engine Fuel Ford Future 253

Green Car Congress

APRIL 22, 2013

downsized, turbocharged) gasoline engine, as operating an engine with higher compression ratios at low load can increase fuel economy compared to operating an engine with fixed compression ratio. Use of a variable compression ratio (VCR) could be one technology approach to reducing fuel consumption in highly boosted (e.g., Kleeberg, H.,

Fuel Economy 218

Fuel Economy Economy Fuel Downsizing 218

Green Car Congress

MARCH 27, 2020

compression ratio, extent of downsizing, etc.). The first-of-its-kind Co-Optima effort is designed to provide American industry with the scientific underpinnings needed to maximize vehicle performance and efficiency, leverage domestic fuel resources, and reduce lifecycle emissions. What Will Work in the Real World?

Alcohol Blend 243

Alcohol Blend Fuel Engine Fuel Economy 243

Green Car Congress

NOVEMBER 1, 2010

These extreme downsizing indicates the potential of a SI, knock-free engine, operating at the same peak pressure as the diesel engine and higher engine speeds. However this aggressive downsizing may not be practical because other constraints (durability, exhaust temperatures). In this manner a 3.6 —Bromberg and Cohn.

Diesel 218

Diesel Engine Downsizing Fuel 218

Green Car Congress

FEBRUARY 4, 2013

to decrease the propensity of gasoline to auto-ignite under high pressure and temperature—will lead to technologies that can increase compression ratio, and support high-efficiency downsizing and downspeeding. Presented at the Society of Automotive Engineers Congress, SAE Paper 2009-01-0694. Alger, T.F.

Gasoline 268

Gasoline 2018 Engine Commercial 268

Green Car Congress

MAY 29, 2020

Advanced low-temperature-combustion (LTC) strategies of downsized and boosted engines are capable of offering ultra-low emissions and higher efficiencies. In a recent study, published in the journal Combustion and Flame , they report that their predictions implicate the composition and temperature of the initial mix of fuel and air.

Downsizing 186

Downsizing Engine Fuel 2020 186

Green Car Congress

MARCH 8, 2012

The company plans to commercialize the motor system after finalizing other technologies for motor/inverter cooling, downsizing and efficiency. The newly developed cylinder-shaped inverter matches the diameter of the motor, enabling them to be connected coaxially within a chassis, resulting in a substantial downsizing of the motor system.

Mitsubishi 252

Mitsubishi Motor Motors Motoring 252

Green Car Congress

SEPTEMBER 13, 2010

liter ELC-Hybrid to downsized 1.4L VTES + SpeedStart. CPT and AVL’s most recent work assesses the potential of a VTES equipped downsized ELC-Hybrid vehicle in combination with the CPT SpeedStart Integrated Starter Generator ( earlier post ) and the UltraBattery. Click to enlarge. —Guy Morris.

VRLA 210

VRLA Hybrid Downsizing Fuel 210

Green Car Congress

JANUARY 20, 2019

HyMag could especially benefit a weight-sensitive application, such as wind turbines, because the technology’s higher efficiency could lead to downsized structures. But the motors in electric and hybrid cars contain approximately a tenth of a kilogram of dysprosium per motor.

Wind 294

Wind Downsizing Motor Motors 294

Green Car Congress

JUNE 23, 2016

Although gasoline direct injection (GDI) enables downsizing with its increased power and lower fuel consumption, it also results in higher particulate emissions. This will reduce particulate emissions from the direct injection gasoline engines by up to 90%. Johnson, T., 2016) “Vehicular Emissions in Review,” SAE Int.

Gasoline 150

Gasoline 2017 Engine Mercedes 150

Green Car Congress

MAY 14, 2012

Carmakers are developing a wide variety of new powertrain systems, from downsized thermal engine, to hybrid systems to full electric motorization. AMEC—a flexible microcontroller interface for engine control—will be first available in OLEA, Scaleo chip’s new family of microcontrollers optimized for powertrain systems.

Motor 218

Motor Motors Motoring International 218

Green Car Congress

AUGUST 14, 2011

Downsizing the Si particles, alloying Si with metals, and making Si/C composites are some methods proposed to relieve the volume expansion effect. Pure Si loses most of its capacity after a few cycles because the significant volume change during lithium insertion/extraction causes breakdown of the electrode structure.

Li-ion 325

Li-ion Lithium Ion Downsizing New York 325

Green Car Congress

APRIL 23, 2017

Downsizing silicon to the nanoscale has been shown to reduce this problem, and by combining an abundant and relatively pure form of silicon dioxide and a low-cost chemical reaction, the researchers created lithium-ion half-cell batteries that store almost four times more energy than conventional graphite anodes.

Li-ion 150

Li-ion Waste Lithium Ion Batteries 150

Green Car Congress

APRIL 22, 2009

presented a pair of papers at the SAE 2009 World Congress describing the development of a variable compression ratio (VCR) engine enabled by a dual piston mechanism. Resources. Engineers from Honda R&D Co., Kadota et al. Ishikawa, M. Yoshida, K. Takahashi and S.

Honda 150

Honda Concept Engine Downsizing 150

Green Car Congress

MAY 9, 2012

The team presented its work at the SAE 2012 World Congress. Engine downsizing and downspeeding are two strategies that can be applied to gasoline and diesel engines to improve vehicle fuel economy. Forced induction is a necessary aspect of these strategies in order to maintain vehicle performance for customer acceptance.

Fuel Economy 199

Fuel Economy Economy Fuel Eaton 199

Green Car Congress

OCTOBER 29, 2019

ECONAMIQ provides greater savings potential than the popular downsizing of internal combustion engines, while the benefits of a larger displacement is preserved. The internal exchange of flue gasses according to the ECONAMIQ principle ensures that the engine reaches operating temperature faster. US20190153912A1 : Combustion engine.

Fuel 186

Fuel San Jose 2019 Engine 186

Green Car Congress

DECEMBER 9, 2015

The technology enables a “downsized” natural gas solution that is cost-competitive while providing similar levels of power, torque, and fuel economy to a larger diesel engine. Westport will contribute approximately $250,000 in additional funds for a total of $1.15

Gas 150

Gas Downsizing Fuel Economy Engine 150

Green Car Congress

OCTOBER 14, 2015

Addressing key global environmental issues such as climate change, water shortages, resource depletion, and degradation of biodiversity, the Toyota Environmental Challenge 2050 aims to reduce the negative impact of manufacturing and driving vehicles as much as possible. that can improve the fuel efficiency of hybrids by 10 percent.

2010 150

2010 Toyota CO2 Vehicles 150

Green Car Congress

JANUARY 31, 2017

Torotrak has been in commercial discussions with passenger car Tier 1s and OEMs as they seek to understand the full capability of V-Charge—Torotrak’s variable-drive mechanical supercharger that can enable ambitious engine downsizing ( earlier post ). We will take the appropriate actions to prudently manage our resources.

Charging 150

Charging Engine Commercial Diesel 150

Green Car Congress

MAY 8, 2015

Thanks to this rightsizing approach, the new engine enjoys the consumption benefits of a downsizing engine in partial load operation, while at higher loads it has the advantages of a large-displacement engine. The result is optimal efficiency and performance characteristics across the entire engine speed range. Stansfield, P., Stroppiana, A.,

Audi 150

Audi MPG Downsizing 2015 150

Green Car Congress

AUGUST 25, 2015

Knock and fuel octane rating are becoming increasingly important due to many powertrain design trends including downsizing, downspeeding, cylinder deactivation, and hybridization. … To achieve continued improvement in engine efficiency and CO 2 emissions, it is critical to quantify the roles of fuel octane rating and alcohol content.

Engine 150

Engine Fuel GM Ford 150

Green Car Congress

FEBRUARY 5, 2018

This is also an advantage because cooling systems can be downsized or removed altogether. This factor is crucial as it greatly increases the efficiency of the cells by reducing the amount of energy that is lost as heat. Chenguang Liu, Zhenning Yu, David Neff, Aruna Zhamu, and Bor Z.

General Motors 150

General Motors GM Downsizing 2010 150

Green Car Congress

APRIL 6, 2017

Improving battery power to such as level would further enable hybridization to near-HEV levels as well as engine downsizing, thereby enabling fuel economy improvements beyond the current 10-15% MHEV limit. a larger motor generator). —Abdellahi et al. Abdellahi, A., Khaleghi Rahimian, S., Blizanac, B., and Sisk, B.

Battery Powered 284

Battery Powered Fuel Economy Power Powered 284

Green Car Congress

APRIL 26, 2009

The resulting higher BMEP levels allow downsizing of the engine at equivalent vehicle performance. EBS has a collaborative R&D agreement with Ford, and participated in the study reported at the World Congress. The MIT team spun off a startup— Ethanol Boosting Systems , LLC (EBS)—in 2006 to commercialize the concept. Earlier post.)

Diesel 170

Diesel Ford F-150 Gasoline 170

Green Car Congress

JANUARY 2, 2018

Researchers at Tianjin University in China report that combing split injection to the Miller cycle with boost pressure can effectively decrease the knock tendency and increase the engine torque in a downsized spark-ignition engine. Their paper is published in the journal Fuel. 2017.11.006.

Downsizing 186

Downsizing Engine Fuel Economy E6 186

Green Car Congress

JULY 28, 2014

The shape and form of road transportation alternative fuels markets vary greatly by region, largely influenced by government regulations, local resources, infrastructure, and fuel prices. For instance, markets for liquefied petroleum gas (LPG) are particularly strong in Eastern Europe, Turkey, and South Korea, but relatively small elsewhere.

Transportation 255

Transportation Global Fuel Alternative Fuels 255

Green Car Congress

MARCH 19, 2013

This first report (Phase I) examines only the impact of improving the efficiency of fossil-fueled vehicles, in which efficiency gains are delivered by the improvement of the internal combustion engine vehicle, including lightweighting, engine downsizing and hybridization. —“An Economic Assessment of Low Carbon Vehicles”.

Cost Of 261

Cost Of 2020 Fuel CO2 261