Green Car Congress

SEPTEMBER 5, 2011

The Volvo Car Corporation is introducing a new, downsized engine range consisting solely of four-cylinder gasoline and diesel engines. The upcoming four-cylinder VEA (Volvo Environmental Architecture) engine range includes common rail diesels and direct injected gasoline engines. Earlier post.).

Downsizing 268

Downsizing Fuel Economy Volvo Economy 268

Green Car Congress

FEBRUARY 24, 2023

Supported by a grant from the Niche Vehicle Network, supported by the Department for Transport and Innovate UK, the project will adapt the design of the Yamaha Tricity 300 to replace its combustion engine with a fully electric powertrain with fast-charging capability and a targeted 100 mile operating range.

Motorcycles 397

Motorcycles Fully Electric Concept Electric Motorcycles 397

Green Car Congress

JUNE 23, 2014

Cost of the new engine relative to gasoline baseline. The technical focus over the last year has been on new engine installation and performance assessments. In 2013, the Cummins-led team demonstrated a Tier 2 Bin 5 version of the engine on the dyno, and then on a vehicle, while development of the Tier 2 Bin 2 engine started.

Fuel Economy 357

Fuel Economy Economy Gasoline Downsizing 357

Green Car Congress

MARCH 19, 2018

Other technologies—such as efficiency improvements in gasoline engines as well as the rollout of hybrid electric power trains—offer more compelling and cost-effective pathways to reducing CO 2 emissions from European passenger cars, the ICCT says. —The ICCT. Renault Clio) and lower medium (e.g.,

Diesel 186

Diesel CO2 Standards Emissions 186

Green Car Congress

AUGUST 14, 2017

Suitable for series production, the new High Thermal Conductivity (HTC) materials and Thermal Interface Material (TIM) coating can reduce valve head temperatures by up to 70°C, allowing improved combustion and lower emissions. The materials also enable CO 2 emissions reduction by eliminating the need for fuel enrichment as a means of cooling.

Engine 150

Engine Emissions Exhaust Sodium 150

Green Car Congress

MAY 23, 2009

Schematic of downsized and supercharged four-stroke hybrid pneumatic spark injection engine. The reduction in fuel consumption is obtained mainly through enabling the effective use of a heavily downsized engine, rather than from regenerative efficiency. Source: ETH Zürich. Click to enlarge. Earlier post.). Earlier post.).

Downsizing 170

Downsizing Concept Engine Hybrid 170

Green Car Congress

OCTOBER 16, 2013

PM mass emissions rates for the FTP and US06 drive cycles as function of vehicle mileage. GDI is a strategy to improve fuel efficiency that is rapidly gaining market acceptance, as illustrated by the popularity of Ford’s GDI EcoBoost engines. These efforts are yielding reductions in PM emissions, but this is still a work in progress.

Standards 246

Standards Emissions Miles Engine 246

Green Car Congress

MARCH 5, 2014

Among the changes in the new Juke are a new design at the front and rear with greater emphasis on both premium refinement and sporty design cues; a new downsized 1.2-liter liter turbocharged engine offering greater performance, economy and lower emissions; a revised 1.6-liter Engines and drivetrains.

Nissan 255

Nissan Engine Downsizing Europe 255

Green Car Congress

JULY 25, 2013

New generation XL3 injector for GDI engines goes into production. liter GDI engine. of 8 holes) enables optimal adaptation to all engine-specific requirements. of 8 holes) enables optimal adaptation to all engine-specific requirements. Click to enlarge.

Engine 294

Engine Production Downsizing Emissions 294

Green Car Congress

OCTOBER 25, 2012

Fuel mass flow comparison shows Pinnacle engine ahead at just about all points in the map. FEV performed engine mappings in a dynamometer test cell to evaluate the fuel economy of Pinnacle’s TP90 scooter engine compared to a benchmark engine (N15) from Pinnacle’s Asian OEM partner. Test engine specs. Stroke [mm].

Engine 262

Engine Fuel Fuel Economy Production 262

Green Car Congress

NOVEMBER 19, 2013

L 3-cylinder direct injection gasoline turbo engine. announced that it has newly developed the VTEC Turbo, a direct injection gasoline turbo engine family most suitable for small-to-medium-sized vehicles. engines: 2.0L 4-cylinder direct injection gasoline turbo engine. L 3-cylinder direct injection gasoline turbo engine.

Gasoline 259

Gasoline Honda Engine Downsizing 259

Green Car Congress

JANUARY 27, 2016

Current mild-hybrid vehicle projects, in partnership with Ford and Hyundai/Kia, that utilize advanced 48V lead-carbon batteries, can reduce CO 2 emissions by 15-20%, according to the latest data from the Advanced Lead Acid Battery Consortium (ALABC), presented at the Advanced Automotive Battery Conference (25-28 January, Mainz).

Emissions 150

Emissions Hybrid CO2 Downsizing 150

Green Car Congress

SEPTEMBER 12, 2012

At the 17 th Supercharging conference this week in Dresden, Controlled Power Technologies (CPT) will launch what it says is the first water-cooled electric supercharger developed for “quasi-continuous” boosting of commercial diesel engines, including those developed for off highway applications. tonnes gross vehicle weight.

Water 370

Water Commercial Engine Diesel 370

Green Car Congress

OCTOBER 15, 2011

Developed for the latest 1-liter downsized gasoline engines. Continental will be supplying Ford with turbochargers for the carmaker’s new three-cylinder direct injection gasoline engine platform. The first two engines will generate 74 and 88 kW from a displacement of just one liter. Click to enlarge. Earlier post.)

Engine 225

Engine Ford Supplies Downsizing 225

Green Car Congress

DECEMBER 11, 2014

Volvo Car’s 3-cylinder gasoline engine. Volvo Cars confirmed its production program to develop a lightweight 3-cylinder Drive-E gasoline engine. The engine, wholly developed in Sweden, will join the company’s 4-cylinder Drive-E engines ( earlier post ). Volvo Cars’ new three-cylinder engine. Click to enlarge.

Volvo 230

Volvo Gasoline Engine Cars 230

Green Car Congress

JUNE 19, 2012

demands of very high-power diesel engines. liter diesel (N57D30S1) engine applied in the M550d xDrive, with a specific power output of 93 kW/liter (124 bhp/liter). downsized diesel engines with improved fuel economy and CO 2 emissions. —Arnd Baberg, Chief Engineer Piston Product Engineering, Federal-Mogul.

Diesel 271

Diesel Light Engine Downsizing 271

Green Car Congress

SEPTEMBER 11, 2015

Bosch is leading a consortium in a German government-funded project to develop a direct injection system for monovalent natural gas engines—i.e., engines that run exclusively on CNG. Today’s CNG vehicles are generally bivalent, running on gasoline and CNG with engines designed for gasoline direct injection.

Gas 150

Gas Engine Gasoline Downsizing 150

Green Car Congress

FEBRUARY 4, 2013

During its recent Innovation Day presentations ( earlier post ), PSA Peugeot Citroën announced that it will commercialize high-efficiency gasoline engines featuring dedicated exhaust gas recirculation (D-EGR), derived from a collaborative program with SwRI in the US. PSA concept D-EGR engine. PSA has filed for two patents on its work.

Gasoline 268

Gasoline 2018 Engine Commercial 268

Green Car Congress

AUGUST 25, 2015

A team of engineers from GM Powertrain, Ford and FCA have published a detailed review of how to estimate the engine efficiency benefits of higher octane fuel—e.g., fuel with higher ethanol content—for part- and full-load operation for different engine types and fuel assumptions. —Leone et al.

Engine 150

Engine Fuel GM Ford 150

Green Car Congress

APRIL 25, 2012

FEV provided early development stage support for the engine in the area of design and CAE, combustion development, and engine build for 36 engines. And these engines are capable of doing that with very low exhaust emissions levels. The engine will initially be offered with power ratings of 73.5

Congress 210

Congress Ford Engine Downsizing 210

Green Car Congress

OCTOBER 16, 2012

SIDI engine. Opel revealed more details about its new mid-size gasoline engine family at the Aachen Colloquium in Germany. liter, four-cylinder, SIDI (spark ignition direct injection) ECOTEC Turbo engines, which begin Opel’s renewal of its powertrain portfolio, deliver improved fuel consumption, performance and refinement.

Gasoline 350

Gasoline Engine Fuel Power 350

Green Car Congress

JULY 14, 2016

The upside of gasoline direct injection (GDI) engines is widely seen as being improved fuel economy coupled with an increase in specific power (especially with turbocharging), enabling significant downsizing. In other words, while the use of GDI engines can reduce CO 2 , it also can increase BC—contributing to further warming.

Climate 150

Climate Engine Carbon Fuel Economy 150

Green Car Congress

FEBRUARY 8, 2013

Built to replace the previous facility in Faridabad, the wholly-owned operation will expand manufacturing capacity and provide sales, design, test and validation capabilities for a wide range of domestic and international automakers, including Maruti Suzuki, Mahindra & Mahindra, Renault, GM, Tata Motors, Fiat, Ashok Leyland, Volvo Eicher and others.

India 186

India Emissions Exhaust Suzuki 186

Green Car Congress

APRIL 19, 2013

A study by a team from Ford Motor Company and AVL has concluded that a mid-level ethanol blend—greater than E20 but less than E40—appears to be attractive as a long-term future fuel for the US for use in engines optimized for the higher octane blend. In the face of increased regulatory stringency (e.g., Earlier post.)

Engine 253

Engine Fuel Ford Future 253

Green Car Congress

MARCH 2, 2011

This marks Toyota’s first downsizing of its HSD technology. This engineering solution targets the independent powering of the air-conditioning unit for improved full hybrid powertrain fuel economy. Introducing full hybrid technology into the B-segment presented Toyota with several unique engineering challenges.

Prius 231

Prius Downsizing Hybrid Toyota 231

Green Car Congress

JANUARY 16, 2013

liter engines and certain lower powered versions of the 2.0-liter liter turbo-diesel engine as part of the fundamental renewal of its powertrain portfolio. The second family of new downsized power units to be introduced after the gasoline 1.6-liter liter engines and certain lower powered versions of the 2.0-liter

Diesel 230

Diesel Engine Fuel Hungary 230

Green Car Congress

JULY 26, 2010

BorgWarner will produce engine timing systems for Fiat Powertrain Technologies’ (FPT) new two-cylinder TwinAir engine, including the 65 hp naturally aspirated, and the 85 hp and 105 hp turbocharged variants. To achieve its goals of lower emissions and better fuel economy, FPT significantly downsized the 0.9-liter

Engine 170

Engine Fuel Economy Downsizing Economy 170

Green Car Congress

MARCH 27, 2020

For the past four years, the Co-Optimization of Fuels & Engines (Co-Optima) National Laboratory consortium has focused research efforts primarily on turbocharged (boosted) spark-ignition (SI) engines for light-duty vehicles. The report highlights researchers’ answers to three vital questions: What fuels do engines want?

Alcohol Blend 243

Alcohol Blend Fuel Engine Fuel Economy 243

Green Car Congress

DECEMBER 11, 2012

PureTech 3-cylinder engine. Citroën is introducing the first members of its new PureTech family of three-cylinder gasoline engines on the C3, DS3 and C-Elysée (for international markets) ranges. mpg US) and CO 2 emissions range from 99 to 107 g/km. mpg US) and CO 2 emissions range from 99 to 107 g/km. Click to enlarge.

Engine 281

Engine Gasoline Fuel MPG 281

Green Car Congress

NOVEMBER 28, 2015

Dearman has begun on-vehicle testing of the Generation 2 zero-emission transport refrigeration system. The system is powered by an innovative, liquid nitrogen Dearman engine, which replaces the standard diesel engine. Dearman liquid air engine, Gen 2 design. Earlier post.) Earlier post.) Click to enlarge.

Transportation 150

Transportation Engine Power Powered 150

Green Car Congress

FEBRUARY 20, 2013

At the SAE 2013 Hybrid and Electric Vehicle Technology Symposium in Anaheim this week, Owen Thunes, Senior Project Engineer, Zero Emissions Research Group at Nissan, provided an updated overview of the company’s development efforts on the upcoming FF (Front-engine, Front-wheel drive) hybrid system. Earlier post.)

Engine 220

Engine Hybrid Fuel Economy Li-ion 220

Green Car Congress

OCTOBER 5, 2011

Even while projecting to the future and talking about batteries and electric vehicles, he said, “ when you look at our actual analysis and you look to our projections for the future, 95% or more of the vehicles, all of the heavy-duty vehicles in our analysis are relying on IC engines. should not discount novel engine designs.

International 265

International Future Engine EPA 265

Green Car Congress

SEPTEMBER 7, 2009

liter, 3-cylinder Range Extender engine with integrated electrical generator. Lotus Engineering will unveil its Range Extender engine at the 63 rd Frankfurt International Motor Show next week. This results in reduced engine mass (56 kg/123 lbs), assembly costs, package size and improved emissions and engine durability.

Engine 240

Engine Range Exhaust Downsizing 240

Green Car Congress

MARCH 7, 2019

The selected projects will focus on reducing the total cost of ownership of NGVs, increasing vehicle efficiency, decreasing local air pollution, and advancing technology development to increase the use of more affordable medium- and heavy-duty natural gas engines and vehicles. Cummins Inc.

Gas 191

Gas Vehicles Exhaust Engine 191

Green Car Congress

JUNE 11, 2019

The Manufacturers of Emission Controls Association (MECA) released a report assessing market-ready technologies being commercialized by suppliers of emission control and efficiency components for heavy-duty diesel vehicles to meet lower intermediate standards for oxides of nitrogen (NO x ) by 2024 as a transition to final standards in 2027.

Standards 191

Standards Diesel 2019 Emissions 191

Green Car Congress

SEPTEMBER 30, 2014

The continued growth of turbocharging technologies will be driven by requirements for manufacturers to meet global environmental emissions regulations and bolstered by strong demand in emerging markets. In addition to improving fuel efficiency, downsized turbocharged engines also reduce harmful exhaust emissions.

2019 261

2019 Global Sale Downsizing 261

Green Car Congress

NOVEMBER 28, 2016

In October 2015, the US Department of Energy’s (DOE) launched a broad, joint effort to co-optimize the development of efficient engines and low greenhouse-gas fuels for on-road vehicles with the goal of reducing petroleum consumption by 30% by 2030 beyond what is already targeted. How do engine parameters affect efficiency?

Engine 150

Engine Fuel Vehicles Emissions 150