Green Car Congress

SEPTEMBER 30, 2015

Anhui Jianghuai Automobile Group Co Ltd (JAC) and Ricardo are collaborating on a project to develop the Ricardo HyBoost concept ( earlier post )—a combination of low-cost technologies to deliver improved performance and fuel economy which featured recently in the Ricardo Centenary celebrations —into volume production on a JAC vehicle.

Fuel Economy 150

Fuel Economy Economy Concept Fuel 150

Green Car Congress

MAY 17, 2013

Relative changes in vehicle energy efficiency (VEE) (km/MJ) on ethanol/gasoline blends over those on gasoline for different blending levels. Several recent highly cited LCAs that have incorporated vehicle efficiency differences between gasoline and ethanol/gasoline blends could potentially be misleading.

Fuel 210

Fuel Energy Gasoline-Electric Gasoline 210

Green Car Congress

FEBRUARY 1, 2009

The pneumatic hybrid engine, which follows the downsizing and supercharging paradigm, offers a fuel-saving potential that is almost equal to that of hybrid electric powertrains while inducing much lower additional mass and cost penalties, according to the ETH Zürich researchers. This corresponds to a fuel saving of one-third.

Hybrid 199

Hybrid Engine Downsizing 2009 199

Green Car Congress

APRIL 18, 2013

In a fairly bleak assessment of global progress towards low-carbon energy, the International Energy Agency (IEA) concluded that, despite a few bright spots such as the rapid expansion of renewable technologies and the growth of hybrid and EV sales, the progress is far below that required to achieve a 2 °C pathway—i.e.,

Carbon 265

Carbon Supplies Global Transportation 265

Green Car Congress

FEBRUARY 4, 2009

Comparison of Fuel Consumption, Fun to Drive and System Cost of the different powertrain concepts. However, the system cost of the Turbohybrid was 150% that of the baseline, while the system cost of the full hybrid was more than 300% that of the baseline. Downsizing a gasoline engine (e.g., Click to enlarge.

Hybrid 150

Hybrid Concept Downsizing Fuel 150

Green Car Congress

SEPTEMBER 29, 2011

Controlled Power Technologies (CPT) is developing a 48-volt version of its 12 volt electric supercharger based on its variable torque enhancement system known as VTES. At 48 volts, a VTES electric supercharger will transform 7kW of battery power into a highly boosted charge of air for downsized gasoline and diesel engines.

Volt 207

Volt Hybrid Downsizing Lead Acid 207

Green Car Congress

FEBRUARY 24, 2016

Pierburg GmbH, part of the KSPG Group, has developed an electric compressor for spontaneously boosting the charge pressure of engines fitted with an exhaust-gas turbocharger. This component allows pressure to be increased regardless of the exhaust-gas energy availability. Initial prototypes are now being tested by various customers.

Exhaust 150

Exhaust Gas-Electric Electric Electrical 150

Green Car Congress

MARCH 8, 2012

The new Yaris Hybrid, which is equipped with a version of the downsized hybrid powertrain featured in the Prius c/Aqua ( earlier post ), is a major step in the company’s full hybrid European roll-out strategy. The downsized full hybrid system combines the new 1NZ-FXE 1.5-liter liter Atkinson Cycle gasoline engine is 16.5

Hybrid 240

Hybrid Toyota Downsizing Sale 240

Green Car Congress

OCTOBER 4, 2009

Toyota’s targeted cost reductions in fuel cell vehicles. In a news conference at the Japan National Press Club on Friday, Toyota Motor President Akio Toyoda said that the company plans to begin mass production of electric vehicles in the US in 2012, followed by US production of fuel cell vehicles in 2015. Source: Toyota.

2015 315

2015 Toyota Commercial Fuel 315

Green Car Congress

JUNE 18, 2013

At the company’s 61 st Automotive Press Briefing in Boxberg, Germany, Bosch senior executives outlined the company’s view on the general future of automotive technology—“ efficient and increasingly electrical ”, and provided a thumbnail of the way they see—and thus are developing products for—sector-specific technology trends.

Future 291

Future Gasoline-Electric Vehicles Gasoline 291

Green Car Congress

OCTOBER 10, 2012

Starting from a energy-based powertrain simulation model validated on experimental data from the PHEV, the researchers conducted a first- and second-law analysis to identify the potential for engine waste heat recovery, considering a variety of driving cycles and assuming the vehicle operating in charge-sustaining (HEV) mode. Skarke et al.

Waste 312

Waste PHEV Fuel Exhaust 312

Green Car Congress

NOVEMBER 8, 2011

The White Paper was published by the US Coalition for Advanced Diesel Cars, a national organization focused on promoting technology neutral policies and the energy efficiency and environmental benefits of advanced clean diesel technology. Washington, DC’s current focus is electric vehicles (EVs) and electric technology.

Standards 247

Standards Transportation Fuel Economy MPG 247

Green Car Congress

JANUARY 22, 2010

We are funding innovative projects in a number of key areas which include internal combustion engine technologies, energy storage and management, lightweight structures and new propulsion technologies. Projects to be funded include: Ultra Lightweight Gas Turbine Range Extender for Electric Vehicles. Title Partners.

Carbon 225

Carbon Li-ion Downsizing Gas 225

Green Car Congress

MARCH 11, 2014

The output power is more than 100kW, despite significant unit downsizing. From the perspective of mobility zones based on travel distance, hybrid and plug-in hybrid vehicles can match the everyday usability of a current gasoline car, and become mainstream environmentally friendly vehicles. Toyota’s view of hydrogen. Click to enlarge.

2015 274

2015 Toyota Fuel Market 274

Green Car Congress

JULY 12, 2013

Describing its product goals and tracking progress toward its 2020 manufacturing priorities in its 2012 Sustainability Report , General Motors reaffirmed its commitment to further reduce the energy used and the environmental impacts of building and operating an automobile. Manufacturing energy use and emissions. Earlier post.).

GM 275

GM MPG Manufacturer 2017 275

Green Car Congress

NOVEMBER 30, 2009

The HyBoost project ( earlier post ), a two-year collaborative research program led by Ricardo in partnership with Controlled Power Technologies, the European Advanced Lead Acid Battery Consortium, Ford, Imperial College London, and Valeo, aims to demonstrate a very cost-effective, ultra-efficient gasoline engine in a C-segment passenger car.

Lead Acid 225

Lead Acid CO2 Exhaust Gasoline-Electric 225

Green Car Congress

DECEMBER 1, 2014

At the 2 nd International Conference Automotive 48 V Power Supply Systems , held last week in Düsseldorf, Germany, Controlled Power Technologies (CPT), a major sponsor of the event, together with leading car makers and Tier 1 suppliers, argued the need for an internationally agreed 48V electrical standard.

Standards 257

Standards International Vehicles Hybrid 257

Green Car Congress

JUNE 22, 2013

The National Energy Technology Laboratory (NETL) of the US Department of Energy (DOE) has awarded Envera LLC a $2.8-million The new engine will achieve high efficiency using the Atkinson Cycle with an 18:1 compression ratio, combined with aggressive engine downsizing. Engine downsizing is a key tool in improving fuel economy.

Engine 207

Engine Eaton Fuel Economy Downsizing 207

Green Car Congress

SEPTEMBER 16, 2015

Mahle has developed a new thermal spray coating for modern high-output direct-injection turbocharged gasoline engines (GTDI). The thermal and kinetic energy of the flame can be produced either with burning mixtures of fuel gas and oxygen, or by using an electrical power source. Typically high-output engines under 3.5

Engine 150

Engine Fuel Michigan South America 150

Green Car Congress

AUGUST 16, 2016

One initiative, SuperTruck II ( earlier post ), will award $80 million to four projects to develop and to demonstrate cost-effective technologies that more than double the freight efficiency of Class 8 trucks. In 2010, the Energy Department launched the SuperTruck initiative to improve heavy-duty truck freight efficiency by 50%.

Vehicles 150

Vehicles Plug-in Lithium Ion Universal 150

Green Car Congress

JULY 12, 2013

The report looks at four key themes: Innovation and technology: By 2040 almost none of Europe’s new cars will be powered solely by a traditional gasoline or diesel engine. Key focus areas are: Integration of combustion engines and electric machines to reduce cost and increase utility. Power electronics & electric machines.

Industrial 210

Industrial Industry Carbon Vehicles 210

Green Car Congress

AUGUST 4, 2011

the step-by-step introduction of electrification to SKYACTIV internal combustion engines: stop-start, followed by regenerative braking, followed by electric motor drive technologies. Energy balance in an internal combustion engine. Extreme compression ratio rather than downsizing. Although downsizing—i.e.,

Mazda 322

Mazda Engine Gasoline Diesel 322

Green Car Congress

DECEMBER 9, 2016

In addition, Honeywell’s forecast calls for electric boosting products to help support compliance with more stringent national environmental standards. Electrics and hybrids are expected to grow from a total of 3 million vehicles in 2016 to a total of 16 million by 2021. for its hydrogen-powered Clarity Fuel Cell vehicle.

Global 150

Global Sale Transportation Vehicles 150

Green Car Congress

SEPTEMBER 7, 2009

liter, 3-cylinder Range Extender engine with integrated electrical generator. In a series hybrid vehicle, the Range Extender engine is attached to an electricity generator and provides an efficient source of energy to power the electric motor directly or charge the vehicles battery. The Lotus 1.2-liter, Click to enlarge.

Engine 240

Engine Range Exhaust Downsizing 240

Green Car Congress

JUNE 4, 2010

However, the technologies would also increase vehicle purchase costs for consumers, sometimes by as much as several thousand dollars. Replacing spark-ignition engines with diesel engines and components would yield fuel savings of about 37% at an added cost of approximately $5,900 per vehicle. Assessment of Technologies”.

Purchase 210

Purchase Lithium Ion Fuel Available 210

Green Car Congress

JUNE 14, 2011

Based on the results of the study, CAR believes the economic risk to the auto industry connected to mandating permanent fuel economy standards in the long run is “ very serious ” The group recommends periodic review to assess the rate of technology development and cost reduction of advanced technologies leading up to 2025.

Fuel Economy 199

Fuel Economy Economy Auto Industry Standards 199

Green Car Congress

JULY 17, 2015

The PHEV (Plug-in Hybrid Electric Vehicle), a subset of the electric car, combines a primary electric motor with a much smaller back-up engine fueled with a hydrocarbon/biofuel mix. (In In this paper PHEV refers solely to the long-range PHEV of 60 miles (100 km) electric-only range.) It is much more than that.

PHEV 150

PHEV Plug-in Renewable Energy 150

Green Car Congress

FEBRUARY 14, 2009

not enthusiast or pioneer—adoption of coming plug-in hybrid electric vehicles (PHEVs), given current market conditions and consumer awareness and attitudes. The most frequent designs resulting from the game include higher charge-sustaining (CS) and charge-depleting (CD) blended operation—few valued all-electric range. Ken Kurani.

PHEV 150

PHEV Fuel Economy San Diego Climate Change 150

Green Car Congress

SEPTEMBER 28, 2009

The new system, where we have adopted a pretty radical change in the architecture itself, downsizes dramatically, takes 100 kg of the mass out, and takes the size down to half of that of the Equinox. The system looks about like a small inline gasoline engine, you could even put it into a sedan. Click to enlarge. Charles Freese.

GM 262

GM 2015 Engine Fuel 262

Green Car Congress

DECEMBER 11, 2009

CPT says that the RegEnBoost system enables a typical family-sized car to achieve less than 100 g/km CO 2 with a 1-liter gasoline engine, but when required can offer the same lively performance and in-gear acceleration of a 2-liter naturally aspirated powertrain.

Downsizing 191

Downsizing Power Powered Exhaust 191

Green Car Congress

FEBRUARY 14, 2010

Cost-effectiveness of vehicle electrification using today’s assumptions. The study by Aaron Brooker, Matthew Thorton and John Rugh aimed to identify possible pathways to cost-effective vehicle electrification by evaluating a variety of scenarios and technology improvements. The EHEV pathway is the dynamic, road-charged hybrid.

Plug-in 231

Plug-in Plug Vehicles PHEV 231

Green Car Congress

NOVEMBER 8, 2016

The US Department of Energy (DOE) has announced the 2017 Small Business Innovation Research and Small Business Technology Transfer (SBIR/STTR) Phase I Release 2 topics , including three subtopics focused on hydrogen and fuel cell technologies. The vehicle topics: Electric Drive Vehicle Batteries. The second is a.

Engine 253

Engine Fuel Hydrogen Batteries 253

Green Car Congress

JUNE 16, 2011

According to its estimates, adopting the full combination of improved technologies in medium and large cars and pickup trucks with spark-ignition engines could reduce fuel consumption by 29% at an additional cost of $2,200 to the consumer.

Fuel 210

Fuel Downsizing Fuel Economy Diesel 210

Green Car Congress

DECEMBER 11, 2011

Exxon Mobil Corporation’s new The Outlook for Energy: A View to 2040 , released last week, projects that global energy demand in 2040 will be about 30% higher than it was in 2010 as population grows to 9 billion and global GDP doubles. Light duty vehicle fleet by type and average fuel efficiency. Source: ExxonMobil Outlook.

Personal 408

Personal Global Transportation Fuel 408

Green Car Congress

JUNE 23, 2014

At the US Department of Energy (DOE) Annual Merit Review in Washington, DC last week, Cory Weaver from Ford Research and Advanced Engineering reported that Ford has completed the planned build of 12 units of the new engine, and is working on vehicle integration for further testing per the project timeline. Electric TiVCT system.

Fuel Economy 247

Fuel Economy Economy Ford Engine 247

Green Car Congress

NOVEMBER 19, 2014

The EALABC focus is on the environmental and cost benefits of current and future advanced lead-carbon batteries for 48V hybrid vehicles. This electrochemical breakthrough provides the most cost effective solution for 48V hybrids, which have a unique requirement for a battery demanding a high rate partial state-of-charge (HRPSoC) capability.

Carbon 240

Carbon Hybrid Batteries Battery 240

Green Car Congress

JUNE 19, 2015

Under the Energy Independence and Security Act of 2007, NHTSA does not have the statutory authority for setting CAFE standards for more than five years at a time—i.e., The U-M survey also asked vehicle owners which advanced technology they would prefer at two different gasoline price points: $2.50/gallon mpg by 2025.

Standards 150

Standards Fuel Economy Economy EPA 150