Green Car Congress

OCTOBER 11, 2013

The Automobile Division of the Institution of Mechanical Engineers has awarded its Prize for the Environment to Ricardo, Ford Motor Company, Controlled Power Technologies and Valeo engineers for their paper HyBoost—An Intelligently Electrified Optimized Downsized Gasoline Engine Concept. Earlier post.).

Engine 210

Engine Downsizing Lead Acid Automobile 210

Green Car Congress

SEPTEMBER 9, 2014

Ricardo will display the first functional integration prototype of the Advanced Diesel Electric Powertrain (ADEPT) collaborative research project ( earlier post ) in public for the first time this week at the Low Carbon Vehicle Event (LCV 2014) in the UK. ADEPT schematic. Click to enlarge.

Diesel 231

Diesel Downsizing Lead Acid Gasoline-Electric 231

Green Car Congress

JANUARY 9, 2010

To achieve its goals, Peugeot is relying on a new products strategy that includes electric propulsion (the i0n i-MiEV-derived electric car) and E-Vivacity scooter from 2010; diesel hybrid in the 3008 from 2011 ( earlier post) ; e-HDi (microhybrid) from 2011 on the entire diesel range; and a plug-in diesel hybrid in 2012. Full Hybrid.

Downsizing 218

Downsizing Plug-in Hybrid Concept 218

Green Car Congress

MARCH 8, 2012

The new Yaris Hybrid, which is equipped with a version of the downsized hybrid powertrain featured in the Prius c/Aqua ( earlier post ), is a major step in the company’s full hybrid European roll-out strategy. Every key HSD component has been reduced in size, and both the fuel tank and battery are installed under the rear seat.

Hybrid 240

Hybrid Toyota Downsizing Sale 240

Green Car Congress

SEPTEMBER 30, 2015

The Ricardo HyBoost concept is based on a downsized, highly boosted turbocharged direct injection gasoline (TDGI) engine giving improved fuel economy at low cost, linked to a 48V electrical architecture including a belt starter generator (BSG), DC-DC converter and a lithium-ion battery for energy storage.

Fuel Economy 150

Fuel Economy Economy Concept Fuel 150

Green Car Congress

MAY 15, 2018

The new “EcoDynamics+” powertrain supplements acceleration with electric power from an additional 48-volt battery and extends combustion engine ‘off time’ using a new Mild-Hybrid Starter-Generator unit. kWh 48-volt lithium-ion battery and a new Mild-Hybrid Starter-Generator (MHSG).

Kia 150

Kia 2018 Diesel Hybrid 150

Green Car Congress

SEPTEMBER 29, 2011

Controlled Power Technologies (CPT) is developing a 48-volt version of its 12 volt electric supercharger based on its variable torque enhancement system known as VTES. At 48 volts, a VTES electric supercharger will transform 7kW of battery power into a highly boosted charge of air for downsized gasoline and diesel engines.

Volt 207

Volt Hybrid Downsizing Lead Acid 207

Green Car Congress

OCTOBER 2, 2014

The four-door fastback is powered by a hybrid electric powertrain that is expected to deliver 550 hp (410 kW) with fuel consumption of 5.5 The powertrain incorporates a new aluminum-based downsized twin-turbocharged 3.0-liter The powertrain incorporates a new aluminum-based downsized twin-turbocharged 3.0-liter

Infinity 281

Infinity Fuel Economy MPG Concept 281

Green Car Congress

FEBRUARY 26, 2018

liter hybrid system; and new 4WD systems—one for gasoline-engined cars, one for hybrids—based on the Toyota New Global Architecture (TNGA). Both powerful and rhythmic acceleration are realized. Shift responsiveness has improved through downsizing of the pulley and reduction of inertia by 40%.

Toyota 264

Toyota Engine Hybrid Gasoline-Electric 264

Green Car Congress

JANUARY 13, 2015

The 2016 Sonata Hybrid features a downsized 2.0-liter liter Nu GDI four-cylinder engine paired with a six-speed automatic transmission that houses a more powerful 38 kW electric motor and clutch where the torque converter would normally be found. Hybrid system net power is 193 horsepower (144 kW) at 6,000 rpm.

Fuel Economy 150

Fuel Economy Economy Hyundai Hybrid 150

Green Car Congress

SEPTEMBER 13, 2010

liter ELC-Hybrid to downsized 1.4L VTES + SpeedStart. CPT and AVL have been working for the past 18 months to develop a value-driven micro/mild HEV solution, utilizing CPT’s production-ready VTES electric supercharger ( earlier post ). Reductions in fuel consumption and CO 2 from base 2.0-liter Click to enlarge.

VRLA 210

VRLA Hybrid Downsizing Fuel 210

Green Car Congress

JULY 28, 2014

gasoline and diesel) represent the bulk of energy consumption throughout the forecast period. However, Navigant foresees that the consumption of gasoline will slowly decrease as alternatives and diesel become more popular in light-duty vehicle (LDV) segments. Electricity and hydrogen will together account for less than 0.5%

Transportation 255

Transportation Global Fuel Alternative Fuels 255

Green Car Congress

JANUARY 17, 2017

Rheinmetall Automotive sees its content per car rising under an e-mobility scenario, with battery-electric vehicles offering the greatest opportunity. The new battery-electric London cabs manufactured by Geely, for example, will have four Rheinmetall pumps incorporated, representing about €200 in sales for the company for each car.

Parts 150

Parts 2020 Sale Gasoline-Electric 150

Green Car Congress

JANUARY 22, 2010

Projects to be funded include: Ultra Lightweight Gas Turbine Range Extender for Electric Vehicles. The aim of this project is to develop an ultra-lightweight, gas turbine powered, electric vehicle range extender that will enable vehicle weight savings of 100 kg or more and a modest reduction in CO 2 emissions on the UNECE101 drive cycle.

Carbon 225

Carbon Li-ion Downsizing Gas 225

Green Car Congress

MARCH 7, 2012

The hybrid drivetrain couples an electric motor powered by a Nissan-developed compact lithium-ion battery with a 2.0-liter liter gasoline direct injection engine to provide the performance potential of a 2.5-liter liter V6 and the electric motor. This earlier rendering of the system uses a 2.5-liter Earlier post.).

Nissan 186

Nissan Concept Lithium Ion Motor 186

Green Car Congress

JUNE 14, 2015

(The amount of liquid fuel that may be used in a lap decreases in proportion to the amount of electrical energy a driver is able to employ.). Porsche retained the basic concept of its Class 1 Le Mans Prototype (LMP1) for the second generation: a downsized turbocharged direct injection gasoline engine and two different energy recovery systems.

Porsche 150

Porsche Audi Exhaust Li-ion 150

Green Car Congress

FEBRUARY 20, 2013

At the SAE 2013 Hybrid and Electric Vehicle Technology Symposium in Anaheim this week, Owen Thunes, Senior Project Engineer, Zero Emissions Research Group at Nissan, provided an updated overview of the company’s development efforts on the upcoming FF (Front-engine, Front-wheel drive) hybrid system. Earlier post.) Torque exceeds the 3.5L

Engine 220

Engine Hybrid Fuel Economy Li-ion 220

Green Car Congress

MARCH 14, 2010

In addition to its twin turbos, the new eight-cylinder unit—known internally as the M 157—features gasoline direct injection with spray-guided combustion and twin turbochargers. liters more economical than the preceding model powered by the naturally aspirated AMG 6.3-litre V8 has a weight/power ratio of 0.41

Downsizing 186

Downsizing Standards Fuel Mercedes 186

Green Car Congress

JANUARY 11, 2012

Automotive supplier KSPG Automotive (formerly Kolbenschmidt Pierburg), a subsidiary of Rheinmetall AG, and FEV have jointly developed a concept for a compact, 30 kW range extender for battery-electric vehicles. Except for the fuel tank and the radiator, all components, including the power electronics, are mounted on a support frame.

Range 252

Range Gasoline-Electric Exhaust Engine 252

Green Car Congress

DECEMBER 22, 2010

Tucson ix Fuel Cell Electric Vehicle. Hyundai Motor Company has completed development of its next-generation hydrogen fuel cell vehicle—the Tucson ix Fuel Cell Electric Vehicle (FCEV)—and will begin testing next year with an eye toward 2015 mass production. Gasoline equivalent fuel efficiency. Click to enlarge.

Tucson 231

Tucson Hyundai 2015 Fuel 231

Green Car Congress

SEPTEMBER 4, 2013

The Ricardo-led Advanced Diesel Electric Powertrain (ADEPT) project will apply 48V “intelligent electrification” concepts, mild hybridization and waste heat recovery in a Ford Focus diesel demonstrator. ADEPT will use CPT’s SpeedStart micro-mild hybrid (BSG and stop-start) and TIGERS energy recovery systems.

Fuel Economy 239

Fuel Economy Diesel Economy Gasoline 239

Green Car Congress

MARCH 31, 2014

Over the entire lifecycle of the C 180, the lifecycle analysis yields a primary energy consumption of 521 gigajoules (corresponding to the energy content of around 16,000 liters of gasoline); an environmental input of approx. Electric water pump, which makes on-demand operation possible (C 180 and C 200). The new C-Class.

Mercedes 252

Mercedes CO2 2007 MPG 252

Green Car Congress

NOVEMBER 30, 2009

The HyBoost project ( earlier post ), a two-year collaborative research program led by Ricardo in partnership with Controlled Power Technologies, the European Advanced Lead Acid Battery Consortium, Ford, Imperial College London, and Valeo, aims to demonstrate a very cost-effective, ultra-efficient gasoline engine in a C-segment passenger car.

Lead Acid 225

Lead Acid CO2 Exhaust Gasoline-Electric 225

Green Car Congress

NOVEMBER 6, 2017

Especially in regard to battery technology, downsizing, efficiency improvements with the turbocharged petrol engine and, in particular, for energy recovery systems. For the 2017 WEC season, the Porsche 919 Hybrid acquired modifications to its aerodynamics and suspension as well as other efficiency improvements for the power train.

Porsche 150

Porsche Manufacturer Hybrid Downsizing 150

Green Car Congress

SEPTEMBER 22, 2009

Controlled Power Technologies’ VTES (Variable Torque Enhancement System) electric supercharger ( earlier post ) is being incorporated in a project by engine developer AVL ( earlier post ) and will also feature in the Ricardo-led £3 million (US$5-million) HyBoost program announced by the Technology Strategy Board on 9 September ( earlier post ).

Downsizing 231

Downsizing Electric Electrical Exhaust 231

Green Car Congress

FEBRUARY 4, 2009

full hybrid (power-split) system delivered a 36% compared to the baseline. The clutch module contains a second clutch, currently not activated, which can disconnect the combustion engine from the drive train to enable electric-only driving in a future phase. Downsizing a gasoline engine (e.g., Click to enlarge.

Hybrid 150

Hybrid Concept Downsizing Fuel 150

Green Car Congress

OCTOBER 10, 2012

Internal combustion engines have been significantly improving in the past decade, after the adoption of technologies such as Gasoline Direct Injection, mild electrification, downsizing and turbocharging. The OSU EcoCAR prototype vehicle features an extended-range electric architecture with a downsized 1.8L Power from ORC.

Waste 312

Waste PHEV Fuel Exhaust 312

Green Car Congress

DECEMBER 1, 2014

At the 2 nd International Conference Automotive 48 V Power Supply Systems , held last week in Düsseldorf, Germany, Controlled Power Technologies (CPT), a major sponsor of the event, together with leading car makers and Tier 1 suppliers, argued the need for an internationally agreed 48V electrical standard.

Standards 257

Standards International Vehicles Hybrid 257

Green Car Congress

AUGUST 4, 2011

the step-by-step introduction of electrification to SKYACTIV internal combustion engines: stop-start, followed by regenerative braking, followed by electric motor drive technologies. Ultimately, the compression ratio ended up playing a central role among these factors in both gasoline and diesel engines, although in different directions.

Mazda 322

Mazda Engine Gasoline Diesel 322

Green Car Congress

FEBRUARY 1, 2009

Researchers at ETH Zürich are developing a pneumatic hybrid engine—an internal combustion engine connected to a compressed air tank instead of a battery system. The compressed air supply also allows extreme downsizing. Downsizing the engine in this instance halves the number of cylinders from four to two. Dönitz et al.

Hybrid 199

Hybrid Engine Downsizing 2009 199

Green Car Congress

JUNE 15, 2011

Conventional automotive technologies have significant emission-reduction potential, according to a draft of the Boston Consulting Group’s (BCG) latest report on automotive propulsion, Powering Autos to 2020. —“Powering Autos to 2020” (draft). Source: BCG. However, China is a major wildcard.

CO2 246

CO2 Electric Cars 2020 United States 246

Green Car Congress

FEBRUARY 5, 2014

The KWID CONCEPT is powered by the latest-generation downsized 1.2-liter liter gasoline turbocharged engine mated to dual-clutch transmission EDC. ready—being pre-disposed to receive batteries for electric use—and comes with a charging plug behind the Renault logo. The KWID CONCEPT is also Z.E

Concept 223

Concept Market India Connect 223

Green Car Congress

SEPTEMBER 6, 2012

To support the rollout, Ford will rapidly expand the availability of EcoBoost gasoline engine technology, low CO 2 ECOnetic Technologies, vehicle electrification and driver assistance features. liter EcoBoost is the most power-dense production engine the company has ever produced. The Focus Electric will go on sale early next year.

Fuel Economy 261

Fuel Economy Europe Ford Economy 261

Green Car Congress

AUGUST 16, 2016

The Vehicle Technologies Office Program Wide Selections will aim to reduce the cost and improve the efficiency of plug-in electric, alternative fuel, and conventional vehicles through thirty-five projects addressing 11 areas of interest. Grid Modernization for Electric Vehicles (Area of Interest 2). Description. Federal funding.

Vehicles 150

Vehicles Plug-in Lithium Ion Universal 150

Green Car Congress

MARCH 11, 2014

Re-emphasizing the general technology points that have emerged over the past few months at different events while adding a bit more detail, Yoshikazu Tanaka, Product General Manager of the Product Planning Group, said at the Geneva show that Toyota’s current fuel cell (FC) system features an output power density of 3.0

2015 274

2015 Toyota Fuel Market 274

Green Car Congress

FEBRUARY 11, 2010

The new Touareg will offer a range of conventional gasoline and diesel engine options, an eight-speed transmission and, on the majority of models, Stop-Start technology. Compared to a conventional SUV of the same size and power, the hybrid delivers more than 25% fuel savings in city driving. The new Touareg Hybrid combines a 3.3-liter

Hybrid 218

Hybrid MPH Gasoline-Electric MPG 218

Green Car Congress

JULY 7, 2014

liter Atkinson-cycle gasoline engine, which brings the brand’s number of hybrid offerings to six—the most among luxury brands. Further, the hybrid battery pack is split into two separate pods for better weight distribution, with the additional benefit of more efficient use of cabin space. A balance shaft enhances smoothness.

North America 210

North America Lexus America Fuel Economy 210