Green Car Congress

JUNE 29, 2016

In addition, the integration of hybrid and emissions control systems has the potential to deliver up to a 10-12% reduction in fuel consumption, equivalent to sub-80g/km of CO 2 emissions (NEDC). Ricardo believes the above package is very competitive with other fuel economy solutions such as full hybridization.

Emissions 150

Emissions Hybrid Affordable Future 150

Green Car Congress

SEPTEMBER 13, 2010

Reductions in fuel consumption and CO 2 from base 2.0-liter liter ELC-Hybrid to downsized 1.4L VTES + SpeedStart. CPT and AVL have been working for the past 18 months to develop a value-driven micro/mild HEV solution, utilizing CPT’s production-ready VTES electric supercharger ( earlier post ).

VRLA 210

VRLA Hybrid Downsizing Fuel 210

Green Car Congress

JUNE 11, 2019

In the latter, CARB staff signaled a plan to align the regulatory provisions for the first phase of NO x tightening with the second implementation stage of the Greenhouse Gas Emissions and Fuel Efficiency Standards for Medium- and Heavy-Duty Engines and Vehicles - Phase 2 in 2024. g/bhp-hr and a low-load cycle limit below 0.2

Standards 191

Standards Diesel 2019 Emissions 191

Green Car Congress

SEPTEMBER 12, 2012

Cobra electric supercharger. At the 17 th Supercharging conference this week in Dresden, Controlled Power Technologies (CPT) will launch what it says is the first water-cooled electric supercharger developed for “quasi-continuous” boosting of commercial diesel engines, including those developed for off highway applications.

Water 370

Water Engine Commercial Diesel 370

Green Car Congress

APRIL 24, 2010

Since the end of 2006, Opel, Robert Bosch, IVK and FKFS have been working on a natural gas hybrid vehicle in a project supported by the German Federal Ministry of Economics and technology. The primary goal is developing a prototype of a CNG-fueled parallel hybrid based on an Opel Astra Caravan with less than 90 g CO 2 /km emissions.

Engine 170

Engine Hybrid Fuel Exhaust 170

Green Car Congress

AUGUST 4, 2011

This corresponds to a 23% reduction in fuel consumption and, therefore, CO 2 output.). the step-by-step introduction of electrification to SKYACTIV internal combustion engines: stop-start, followed by regenerative braking, followed by electric motor drive technologies. SKYACTIV at Powertrains, Fuels & Lubes. pumping loss.

Mazda 322

Mazda Engine Gasoline Diesel 322

Green Car Congress

JUNE 14, 2015

The amount of liquid fuel that may be used in a lap decreases in proportion to the amount of electrical energy a driver is able to employ.). The previously used centralized exhaust tract was replaced by a twin exhaust-pipe system in order to improve output and optimize the vehicle’s aerodynamics. Click to enlarge.

Porsche 150

Porsche Audi Exhaust Li-ion 150

Green Car Congress

FEBRUARY 18, 2014

Controlled Power Technologies (CPT) will deliver two technical papers at SAE World Congress in April on its SpeedStart torque assist and kinetic energy recovery system ( earlier post ) and TIGERS turbine integrated gas energy recovery system ( earlier post ) for 48V mild hybrid vehicles. Earlier post.)

Congress 236

Congress Hybrid Exhaust Gas-Electric 236

Green Car Congress

NOVEMBER 30, 2011

outlined its plans for next-generation automotive technology&madsh;which it is labeling “Earth Dreams Technology”—comprising a series of measures to improve the efficiency of gasoline and diesel engines, transmissions, hybrid and plug-in hybrid systems and electric powertrains. A compact, high efficiency electric powertrain for EVs.

Honda 246

Honda Plug-in Hybrid Engine 246

Green Car Congress

JUNE 18, 2013

At the company’s 61 st Automotive Press Briefing in Boxberg, Germany, Bosch senior executives outlined the company’s view on the general future of automotive technology—“ efficient and increasingly electrical ”, and provided a thumbnail of the way they see—and thus are developing products for—sector-specific technology trends.

Future 291

Future Gasoline-Electric Vehicles Gasoline 291

Green Car Congress

MARCH 31, 2017

The transmission on the front and rear axle, the combustion engine, the electric motor and the energy recovery systems have all been optimized, but the basic principle behind the drive system is unchanged: the rear axle of the 919 is driven by an extremely compact two-liter V4 combustion engine. liters of fuel to do so. Aerodynamics.

Porsche 150

Porsche 2017 Hybrid Exhaust 150

Green Car Congress

FEBRUARY 5, 2020

It is important to state that there are several technology paths to achieve these levels of emissions, and some of them can simultaneously lower greenhouse gas emissions, such that the NO x reductions do not compete with the CO 2 reductions.

Emissions 291

Emissions Diesel Engine 2010 291

Green Car Congress

MARCH 8, 2012

The new Yaris Hybrid, which is equipped with a version of the downsized hybrid powertrain featured in the Prius c/Aqua ( earlier post ), is a major step in the company’s full hybrid European roll-out strategy. Every key HSD component has been reduced in size, and both the fuel tank and battery are installed under the rear seat.

Hybrid 240

Hybrid Toyota Downsizing Sale 240

Green Car Congress

MAY 17, 2013

In a policy analysis in the ACS journal Environmental Science & Technology , researchers from the Universities of Cambridge, Exeter and Oxford argue that, due to the increased emphasis on alternative fuels with drastically differing energy densities, vehicle efficiency should be evaluated based on energy rather than volume. respectively.

Fuel 210

Fuel Energy Gasoline-Electric Gasoline 210

Green Car Congress

JANUARY 17, 2017

Rheinmetall Automotive sees its content per car rising under an e-mobility scenario, with battery-electric vehicles offering the greatest opportunity. The new battery-electric London cabs manufactured by Geely, for example, will have four Rheinmetall pumps incorporated, representing about €200 in sales for the company for each car.

Parts 150

Parts 2020 Sale Gasoline-Electric 150

Green Car Congress

JULY 4, 2010

to eliminate turbo lag—in support of aggressive engine downsizing. The separate components are connected electrically. The system can operate without a wastegate, using electrical energy storage to prepare for the next acceleration event. CPT Electric Supercharger.

Exhaust 218

Exhaust Energy Storage Gas-Electric Downsizing 218

Green Car Congress

JANUARY 11, 2012

Automotive supplier KSPG Automotive (formerly Kolbenschmidt Pierburg), a subsidiary of Rheinmetall AG, and FEV have jointly developed a concept for a compact, 30 kW range extender for battery-electric vehicles. The engine, with a 90° V, is port fuel injected, with two valves per cylinder, and meets Euro 6 emission requirements.

Range 252

Range Gasoline-Electric Exhaust Engine 252

Green Car Congress

SEPTEMBER 29, 2011

Controlled Power Technologies (CPT) is developing a 48-volt version of its 12 volt electric supercharger based on its variable torque enhancement system known as VTES. At 48 volts, a VTES electric supercharger will transform 7kW of battery power into a highly boosted charge of air for downsized gasoline and diesel engines.

Volt 207

Volt Hybrid Downsizing Lead Acid 207

Green Car Congress

SEPTEMBER 24, 2010

The diversified manufacturer also said that in addition to boosting engine performance, its superchargers can provide up to a 5% fuel savings and reduce emissions compared to competing technologies. 136 kg], which translates into improved fuel economy and enhanced performance and safety for the end consumer.

Eaton 218

Eaton Emissions Fuel Range 218

Green Car Congress

NOVEMBER 30, 2009

This is to be achieved through the synergistic application of an extremely downsized gasoline engine coupled with electrified boosting and exhaust gas energy recovery; micro-hybrid functionality with stop/start, torque assist and regenerative braking; and a novel energy storage technology. Earlier post.) Earlier post.).

Lead Acid 225

Lead Acid CO2 Exhaust Gasoline-Electric 225

Green Car Congress

JUNE 7, 2010

In terms of powertrain technologies, Renault focused on the introduction of new technologies for internal combustion engines and conventional transmissions, as well as outlining its commitment to electric powertrains. Specific engine-mapping aimed at reducing fuel consumption and CO 2 emissions. Select Engines. New-generation 1.5

Environment 230

Environment Engine 2010 Parts 230

Green Car Congress

OCTOBER 8, 2015

Having better control over the combustion process reduces the emission load on the exhaust aftertreatment systems. Eminox SCRT technology can significantly reduce harmful diesel exhaust gases, particularly in urban operating conditions. Phil Bush, technology manager at Eminox. —Jog Lall, sales and marketing director Eminox.

Vehicles 150

Vehicles Exhaust Emissions Diesel 150

Green Car Congress

MAY 6, 2013

Since 2010, all Sprinters in the US have been powered by BlueTEC diesel engines, marking the first use of BlueTEC technology, with its selective catalytic reduction (SCR) exhaust aftertreatment system, in the commercial van market here. The two overhead camshafts actuate 16 intake and exhaust valves. with a variable delivery rate.

2014 306

2014 Diesel Standards Exhaust 306

Green Car Congress

DECEMBER 9, 2016

By rightsizing engines with available technologies, automakers are able to continue applying the benefits of smaller turbocharged engines while fine-tuning powertrain systems to further optimize fuel economy, emissions and performance. E-boosting products can significantly improve engine responsiveness and also provide better fuel economy.

Global 150

Global Sale Transportation Vehicles 150

Green Car Congress

FEBRUARY 1, 2009

The pneumatic hybrid engine, which follows the downsizing and supercharging paradigm, offers a fuel-saving potential that is almost equal to that of hybrid electric powertrains while inducing much lower additional mass and cost penalties, according to the ETH Zürich researchers. This corresponds to a fuel saving of one-third.

Hybrid 199

Hybrid Engine Downsizing 2009 199

Green Car Congress

JULY 13, 2011

MHI) has completed development of a new-generation liquefied natural gas (LNG) carrier marking an evolutionary advance from Moss-type LNG carriers which use independent spherical storage tanks to transport NG. Improved aerodynamics contributes to reduced fuel consumption during navigation. Bottom : Conventional Moss-tank carrier.

Mitsubishi 199

Mitsubishi Fuel Mariner Panama 199

Green Car Congress

MARCH 27, 2015

Daimler Trucks North America’s (DTNA) SuperTruck program has achieved 115% freight efficiency improvement (gallons of fuel consumed per ton of goods moved per mile traveled)—surpassing the Department of Energy (DOE) program’s goal of 50% improvement and exhibiting the best results of all reporting OEMs. Click to enlarge. Powertrain.

2009 150

2009 Engine Detroit Oregon 150

Green Car Congress

AUGUST 16, 2016

SuperTruck II builds on the successful SuperTruck I program, which has already led to more than twenty fuel saving technologies that have reached the commercial market, said Acting Assistant Secretary David Friedman. By area of interest, the awards are: EV Everywhere Plug‐In Electric Vehicle Local Showcases (Area of Interest 1).

Vehicles 150

Vehicles Plug-in Lithium Ion Universal 150

Green Car Congress

JULY 7, 2014

liter turbocharged gasoline engine has a combination water-cooled cylinder head, integrated exhaust manifold and twin-scroll turbocharger. liter turbocharged port and direct-injection engine uses an advanced valve control system to switch between Atkinson cycle and Otto cycle operation to optimize performance and fuel efficiency.

North America 210

North America Lexus America Fuel Economy 210

Green Car Congress

SEPTEMBER 30, 2009

The new Astra has grown slightly to provide a roomier interior and, at the same time, it has benefited from engineering enhancements that allow it to improve fuel efficiency and performance. liter units, each featuring common-rail with multiple fuel injection equipped with particulate filters. L/100 km (51 mpg US). A new diesel 1.3

Exhaust 199

Exhaust MPG Gasoline-Electric Engine 199

Green Car Congress

DECEMBER 1, 2014

At the 2 nd International Conference Automotive 48 V Power Supply Systems , held last week in Düsseldorf, Germany, Controlled Power Technologies (CPT), a major sponsor of the event, together with leading car makers and Tier 1 suppliers, argued the need for an internationally agreed 48V electrical standard.

Standards 257

Standards International Vehicles Hybrid 257

Green Car Congress

MAY 8, 2013

Especially with increased production volume of renewable fuels and optimized powertrain solutions for flexible fuel vehicles, there is a chance for combustion engines to not only remain in the market but also be sustainable for future vehicle. The intake manifold was modified for high pressure EGR feed and port fuel injection (PFI).

Fuel Economy 278

Fuel Economy Economy Fuel Engine 278

Green Car Congress

OCTOBER 2, 2014

liter units which are part of a new generation of engines from the Kappa family—meet growing demand for small capacity, turbocharged engines to reduce fuel consumption and CO 2 emission without compromising performance. Both engines—1.0-liter liter and 1.4-liter liter T-GDI engine. 48-volt hybrid version of the i40.

Hyundai 239

Hyundai Downsizing Engine Hybrid 239

Green Car Congress

DECEMBER 11, 2009

RegEnBoost integrates the three devices into a powertrain electrical power network (PEPN), which also incorporates a DC to DC converter and an enhanced lead acid battery, optimized for fast energy storage and release.

Downsizing 191

Downsizing Power Powered Exhaust 191

Green Car Congress

JUNE 16, 2011

According to its estimates, adopting the full combination of improved technologies in medium and large cars and pickup trucks with spark-ignition engines could reduce fuel consumption by 29% at an additional cost of $2,200 to the consumer. Source: NRC. Click to enlarge.

Fuel 210

Fuel Downsizing Fuel Economy Diesel 210

Green Car Congress

JUNE 23, 2014

Ford’s approach to the project was to engineer a comprehensive suite of gasoline engine systems technologies, including: Aggressive engine downsizing in a mid-sized sedan from a large V-6 to a small I-4. Split, parallel, cross-flow cooling with integrated exhaust manifold. Electric TiVCT system. Earlier post.). dissertation.

Fuel Economy 247

Fuel Economy Economy Ford Engine 247

Green Car Congress

FEBRUARY 20, 2015

In addition to a range of visual upgrades, the new cee’d GT Line features the debut of Kia’s all-new downsized 1.0-liter liter T-GDi is a downsized, three-cylinder power unit engineered to improve fuel consumption and emissions while offering strong performance and immediate response. Kia cee’d GT Line. Click to enlarge.

Kia 150

Kia Downsizing Fuel Economy Cleaner Emissions 150