Green Car Congress

JULY 23, 2015

Nanoporous silicon is considered an attractive next-generation anode material in lithium-ion batteries due to its much higher theoretical capacity and lower operating voltage than the commonly used graphitic carbon materials. mVs -1 in the voltage range of 0.01–1.0 the overall process does not use expensive Si precursors or reagents.

Li-ion 150

Li-ion Batteries Battery Lithium Ion 150

Green Car Congress

APRIL 30, 2022

The selected projects are: Advanced Manufacturing Process Innovations – Flex-Ion Battery Innovation Center. The Flex-Ion Battery Innovation Center, a division of Ventra Group Co., will establish a center of excellence for advanced Li-Ion battery manufacturing, in collaboration with partner eCAMION. Lead: Ventra Group Co.;

Canada 304

Canada Li-ion Emissions Vehicles 304

Green Car Congress

SEPTEMBER 5, 2019

This expanded portfolio has the dual aims of improving current generation lithium ion batteries as well as longer horizon materials discovery and optimisation projects to support the commercialisation of next-generation batteries. Next generation lithium ion cathode materials. Next generation sodium ion batteries–NEXGENNA.

Energy Storage 223

Energy Storage Li-ion Lithium Ion Energy 223

Green Car Congress

SEPTEMBER 16, 2013

F 0.7 , for sodium-ion (Na-ion) batteries (NIBs). This new material provides an energy density of 600 Wh kg –1 , the highest value among Na-ion cathodes. Recently, attention has been refocused on room-temperature Na-ion batteries (NIBs) as a low-cost alternative technology as compared to LIBs.

Sodium 292

Sodium Li-ion Energy Batteries 292

Green Car Congress

OCTOBER 10, 2011

Conventional Li-ion cell (left) compared to Seeo cell (right). The California Energy Commission has awarded $1,585,490 to spur research on projects including a solid-state Li-ion battery system for grid-scale energy storage. The Commission’s funding is the cost-share for the company’s $6.2

Li-ion 186

Li-ion Grid Energy California 186

Green Car Congress

MARCH 31, 2014

Vehicle technologies span a range from new Si/graphene Li-ion anode materials and composites for motor windings to diesel aftertreatment and advanced lubricants. The reduced fuel consumption will extend the effective range of the turbo vehicle. Low-Cost, High-Energy Si/Graphene Anodes for Li-Ion Batteries.

Exhaust 261

Exhaust Wind 2014 Motor 261

Green Car Congress

FEBRUARY 12, 2014

Haldor Topsøe A/S, a global market leader in catalysis and related process technologies, recently acquired 18% of the shares in sodium-ion battery technology company Faradion Ltd, based in Sheffield, UK. Other partners in the investment included Finance Yorkshire’s Seedcorn Fund and Rising Stars Growth Fund II LP.

Sodium 199

Sodium Li-ion Companies Batteries 199

Green Car Congress

FEBRUARY 17, 2009

The manganese spinel system, Amine said, has excellent power capability—much better than any other existing lithium-ion system—allowing the possibility of designing small batteries, which could lead to significant cost reduction. XRD of new Argonne nano-Li 4 Ti 5 O 12 spinel. New titanate system for HEVs. Click to enlarge.

Li-ion 150

Li-ion PHEV Ni-Li Lithium Titanate 150

Green Car Congress

MARCH 22, 2012

This partnership brings together 17 scientists and engineers from nine universities across Canada, who will work on reducing the cost of PEMFCs through the exploration of alternative non-platinum metals and the fabrication of advanced layer structures. APC Investment: $4,176,005 (through NSERC and CFI).

Canada 262

Canada Li-ion Fuel Batteries 262

Green Car Congress

FEBRUARY 19, 2009

CPI) shortly after GM selected CPI and its parent LG Chem as the provider for the Li-ion batteries for the Extended Range Electric Vehicle (E-REV) Chevy Volt. (GM billion, and spends $60 million annually on Li-ion battery research and development. Generic Li-ion cell and various component technologies.

Li-ion 170

Li-ion Power Powered Market 170

Green Car Congress

MAY 28, 2015

This quality control device will help to drive down the costs of fuel cells by reducing waste and improving the process efficiency of roll-to-roll manufacturing of polymer electrolyte membranes. High Loading Lithium-Ion Electrode Architecture for Low Cost Electric Vehicle Batteries Ballast Energy, Inc. 149,871.44.

Li-ion 150

Li-ion Battery Powered Engine Lithium Ion 150

Green Car Congress

MAY 26, 2011

Scheme of the semi-solid flow cell (SSFC) system using flowing lithium-ion cathode and anode suspensions. The SSFC could enable new models such as transportation ‘fuels’ tuned for power versus range, or cold versus warm climates, with flexible refueling and recycling options. Source: Duduta et al. Click to enlarge. –2.9

Li-ion 345

Li-ion Recharge Grid Lithium Ion 345

Green Car Congress

SEPTEMBER 28, 2020

Stanford University scientists have identified a new solid-state Li-ion electrolyte predicted to exhibit simultaneously fast ionic conductivity, wide electrochemical stability, low cost, and low mass density. sulfur (Li?B?S) 1 in Li 5 B 7 S 13 and 80 (?56, 1 in Li 9 B 19 S 33. 41) mS cm ?1

Li-ion 397

Li-ion Lithium Ion Batteries Battery 397

Baua Electric

MARCH 25, 2024

Despite kicking off a new era with the launch of its LEAF in 2010, Nissan has quickly fallen behind with longer-range, more advanced EVs rolling out. “We The 90-year-old automaker announced its new “The Arc” business plan Monday as it looks to compete with Tesla and low-cost automakers from China.

Nissan 52

Nissan Affordable Price Li-ion 52

Green Car Congress

AUGUST 10, 2011

The US Department of Energy will award more than $175 million over the next three to five years to accelerate the development and deployment of a range of advanced vehicle technologies. This project will develop a new process that enables low-cost, domestic manufacturing of magnesium. Metal Oxygen Separation Technologies Inc.

Carbon Fiber 268

Carbon Fiber Lithium Ion Li-ion Vehicles 268

Green Car Congress

MAY 29, 2010

EnerFuel is developing a HT PEM cell/on-board reformer system that enables the use of conventional fuels in the fuel cell range extender. In 2008, EnerFuel developed a prototype to demonstrate the advantages of a fuel cell EV range extender. Balance of plant elimination is critical to the cost and reliability of the fuel cell.

Fuel 218

Fuel Range Electric Vehicles Lithium Ion 218

Green Car Congress

JANUARY 22, 2010

Projects to be funded include: Ultra Lightweight Gas Turbine Range Extender for Electric Vehicles. Total project cost is £2,206,784, with the TSB providing £1,103,392. The small size, multi-fuel capability and potential low cost of the ULRE could also help speed adoption of electric vehicles.

Carbon 225

Carbon Li-ion Downsizing Gas 225

Green Car Congress

OCTOBER 30, 2022

Indeed, fuel cell projects are gathering momentum, with system deliveries ranging up to 3.2 The greatest challenge is the same as that which is plaguing the adoption of fuel cells in the automotive market—the buildout of low-cost green hydrogen infrastructure.

Market 150

Market Electric Vehicles Vehicles Cars 150

Green Car Congress

FEBRUARY 1, 2013

Reducing the cost of electric drive systems from $30/kW to $8/kW. When these goals are met, the levelized cost of an all-electric vehicle with a 280-mile range will be comparable to that of an ICE vehicle of similar size. Cost and performance targets in this technology area include: Electric motors. Traction drive system.

Plug-in 247

Plug-in Zinc Air Li-ion 2012 247

Green Car Congress

JULY 15, 2010

Projected incremental mass due to the energy storage and electricity generation system for (a) a 100- and (b) 300-mile range for a battery electric vehicle and a fuel cell electric vehicle. This allows batteries for small low-range pure electric vehicles but excludes them for larger-vehicle long-range applications.

Li-ion 210

Li-ion Connect Connected GM 210

Green Car Congress

OCTOBER 4, 2009

Toyoda positioned EVs for short-distance travel and fuel cell cars for longer ranges. Toyota is also seeking to reduce the cost of fuel-cell system specific materials, through cooperation with materials manufacturers. The company is working to develop a low-cost CFRP for a high-pressure hydrogen tank. Earlier post.).

2015 315

2015 Toyota Commercial Fuel 315

Green Car Congress

JANUARY 18, 2014

Specifically: the current cost of high?energy ion batteries is approximately four times too high on a kWh basis; current batteries are two to three times too heavy and large, and high? ion batteries are not intrinsically tolerant to abusive conditions. displayed in longer EV range, higher MPG and/or MPGe ratings).

Carbon Fiber 252

Carbon Fiber Engine Battery Powered Fuel 252

Green Car Congress

APRIL 30, 2010

Electrofuels approaches will use organisms able to extract energy from other sources, such as solar-derived electricity or hydrogen or earth-abundant metal ions. The critical barrier to wider deployment of electric vehicles is the high cost and low energy of today’s batteries. Electrofuels. per gallon. BASF, LBNL, PNNL).

Carbon 249

Carbon Batteries Battery Li-ion 249

Green Car Congress

FEBRUARY 17, 2014

Credit: ACS, Li et al. In particular, silicon nanowires (SiNW) are widely studied as a promising anode material for high-capacity LIBs due to its low cost of fabrication and volume production potential. —Li et al. —Li et al. Click to enlarge.

Li-ion 265

Li-ion Batteries Battery Milwaukee 265

Green Car Congress

FEBRUARY 2, 2013

Advanced Electrolytes for Next-Generation Lithium Ion Chemistries. Further, alloying or coating pathways towards low-cost, effective passive films, have not been sufficiently explored in a sound and scientific way. Temperature range of ambient air, °C. -40 Computer Aided Engineering for Electric Drive Batteries.

Li-ion 240

Li-ion Fuel Vehicles Lithium Ion 240

Green Car Congress

NOVEMBER 9, 2011

Li-ion battery manufacturer A123 Systems reported. A123 Systems is currently sourced or in production in 21 vehicle programs, ranging from starter batteries to electric vehicle packs. There remains much more work to be done to hit the targeted cost goal for the fourth quarter of 2012. A123 Systems quarterly revenue.

Li-ion 186

Li-ion 2011 Fisker 2010 186

Green Car Congress

FEBRUARY 15, 2022

The selected projects—spanning 22 states and coordinated at universities, national laboratories, and private companies—will advance technologies for a wide range of areas, including electric vehicles, offshore wind, storage and nuclear recycling. Select OPEN 2021 projects include: Synteris. Massachusetts Institute of Technology.

Clean 284

Clean Cleaning Energy Li-ion 284

Green Car Congress

MARCH 11, 2016

Vouchers range from $50,000-300,000. Big Delta will demonstrate that the new process at the core of its manufacturing technology is scalable, reliable and significantly reduces the cost of manufacturing high-performance Li-ion cells. The companies were competitively chosen from a pool of hundreds of applications.

Clean 150

Clean Cleaning Energy Li-ion 150

Green Car Congress

DECEMBER 20, 2013

Some specific goals include: Cutting battery costs from their current $500/kWh to $125/kWh. Reducing the cost of electric drive systems from $30/kW to $8/kW. Possible areas of interest for the EV Everywhere Grand Challenge include, but are not limited to: Development of low-cost, high-strength automotive aluminum sheet.

Vehicles 246

Vehicles Fuel Economy Carbon Fiber Plug-in 246

Green Car Congress

MARCH 27, 2017

This synthesis consumes only CO 2 and electricity, and is constrained only by the cost of electricity. This research article focuses on a highly favored route to the synthesis of controlled nanostructures at high rate, high yield, and low cost by molten carbonate electrolysis. Addition of BaCO 3 increases electrolyte density.

CO2 150

CO2 Carbon Gas-Electric 2017 150

Green Car Congress

MARCH 15, 2011

published in the ACS journal Chemical Reviews , reviews in detail four stationary storage systems considered the most promising candidates for electrochemical energy storage: vanadium redox flow; sodium-beta alumina membrane; lithium-ion; and lead-carbon batteries. In their study, Yang et al. —Yang et al. —Yang et al.

Li-ion 231

Li-ion Energy Storage Grid Carbon 231

Green Car Congress

SEPTEMBER 14, 2016

The US Department of Energy (DOE) Advanced Research Projects Agency-Energy (ARPA-E) announced $37 million in funding for 16 innovative new projects as part of a new ARPA-E program: Integration and Optimization of Novel Ion-Conducting Solids ( IONICS ). Li-ion conductors that enable the cycling of Li metal without shorting.

Li-ion 150

Li-ion Polymer Batteries Battery 150

Green Car Congress

APRIL 9, 2011

The Lupo EL (“Electric Lightweight”)vehicle combines a very low weight (1,060 kg, 2,337 lbs) with a large battery pack (27 kWh). The Thundersky batteries use a lithium iron phosphate (LiFePO 4 ) chemistry, which has a comparatively low cost of less than €300/kWh (US$434/kWh), is considered safe and has a long cycle life.

Convert 337

Convert Range Li-ion DC 337

Green Car Congress

FEBRUARY 27, 2016

IONICS also seeks to develop and apply methods for processing of solid ion conductors and their integration into electrochemical devices. Program Categories include: Lithium (Li) ion conductors that enable the cycling of Li metal without shorting; Selective and low-cost separators for batteries with liquid reactants (e.g.,

Li-ion 150

Li-ion Batteries Battery Fuel 150

Green Car Congress

DECEMBER 20, 2015

Accelerated Development and Deployment of Low-Cost Automotive Magnesium (Mg) Sheet Components. Advances for the Production of Low Cost Electric Drive Vehicle Motors. Models will include electrochemical/chemical and transport processes (kinetics, thermodynamics, phase transitions, ion transport, etc.)

Li-ion 150

Li-ion Vehicles Low Cost Grid 150

Green Car Congress

JANUARY 21, 2016

Secretary Moniz also announced that two innovative projects at CALSTART and the National Association of Regional Councils will receive $3 million to develop systems that help companies combine their purchasing of advanced vehicles, components, and infrastructure to reduce incremental cost and achieve economies of scale.

Li-ion 150

Li-ion Ni-Li Vehicles Grid 150

Green Car Congress

NOVEMBER 28, 2012

petroleum fuels by increasing flight range up to 20%. sunlight through low-cost, plastic light-guiding sheets and then. If successful, the new crop would have a lower cost of. Turbo-POx For Ultra Low-Cost Gasoline. temperature ranges similar to internal combustion engines. The increased energy.

2012 240

2012 Energy Lithium Sulfur Conversion 240