Green Car Congress

NOVEMBER 6, 2019

Mustang Lithium is low and sleek, with custom carbon fiber body components, a 1.0-inch Under the hood are a Phi-Power dual-core electric motor and dual power inverters—all powered by an 800-volt Webasto battery system with EVDrive Technology that can discharge a megawatt of electrical energy.

Ford 280

Ford F-150 Batteries Battery 280

Green Car Congress

FEBRUARY 17, 2014

In combination with a lighter body enabled by the partial adoption of carbon fiber construction, the new buses will be able to operate continuously over increased distances—up to 80 kilometers (50 miles) on a full charge, at a top speed of 85 km/h (53 mph). Load capacity is 72 passengers.

Li-ion 291

Li-ion Supplies Lithium Ion Batteries 291

Green Car Congress

NOVEMBER 13, 2020

Key changes include: Range: BEVs are overwhelmingly more efficient than ICE vehicles due to regenerative braking and more efficient motors. Bumpers are expected to benefit from design advancements that utilize glass fiber, carbon fiber, and thermoplastics. —Anthony Schiavo, Senior Analyst at Lux.

Electric Vehicles 243

Electric Vehicles Batteries Battery Vehicles 243

Green Car Congress

MARCH 26, 2013

The CEMI announcement was made at the ribbon cutting of the Department’s Carbon Fiber Technology Facility in Oak Ridge, Tennessee, a new advanced manufacturing facility to reduce the cost of carbon fiber. Officials from DOE, Oak Ridge National Laboratory (ORNL), Ford Motor Company, and Dow Chemical launched the facility.

Manufacturer 246

Manufacturer Carbon Fiber Clean Cleaning 246

Green Car Congress

JANUARY 18, 2014

The FOA will give equal consideration to all proposals submitted, including submissions that address the following Areas of Interest: Energy Storage R&D. Advanced Power Electronics and Electric Motors for Electric Traction Drives. The additional content which includes the motor, inverter, converter, and on?

Carbon Fiber 252

Carbon Fiber Engine Battery Powered Fuel 252

Green Car Congress

NOVEMBER 26, 2012

At the opening of Auto Guangzhou 2012, Shanghai General Motors launched its first localized new energy vehicle, the Sail SPRINGO EV. As a comparison, the new Chevrolet Spark EV uses a 100 kW motor with 542 N·m of torque. The Sail SPRINGO EV. Click to enlarge. Earlier post.). The Sail SPRINGO EV costs RMB 4.6 (US$0.74)

General Motors 240

General Motors 2020 2012 Green 240

Green Car Congress

SEPTEMBER 9, 2011

Quimera and Altran, its global technological partner of Quimera, will present the “All Electric GT” AEG prototype at the Frankfurt Motor Show. Featuring three UQM motors developing a combined 700 bhp (522 kW), the AEGT has a top speed currently limited to 300 km/h (186 mph). Shakedown was 26 July at the Motorland F1 race track.

All-Electric 210

All-Electric Carbon Fiber Polymer Energy Storage 210

Green Car Congress

NOVEMBER 17, 2016

Analysis suggests that cost parity between electric drive and internal combustion vehicles is possible under certain scenarios when battery pack costs fall below $125/kWh (useable energy). Integrated Computational Materials Engineering (ICME) Development of Low Cost Carbon Fiber for Lightweight Vehicles.

Carbon Fiber 150

Carbon Fiber Vehicles Nickel Lithium Low Cost 150

Green Car Congress

APRIL 4, 2019

This holistic approach also includes the use of vehicle batteries in stationary energy-storage devices after their mobile service life. The aspect of energy supply to the production locations also plays an important role. On downhill stretches and when braking, kinetic energy can be stored in the battery (recuperation).

Hydrogen 274

Hydrogen Mercedes Power Powered 274

Green Car Congress

JUNE 10, 2015

Made of carbon fiber and advanced composite materials, Proterra’s unibody design is a prime driver for its high performance with regard to weight and durability. The bus is powered either by an advanced Lithium Titanate fast-charge energy storage pack or an NMC extended range energy storage system.

Lithium Titanate 150

Lithium Titanate San Francisco Carbon Fiber Energy Storage 150

Green Car Congress

AUGUST 10, 2011

Ford Motor Company. Ford Motor Company. This project will develop a novel low cost route to carbon fiber using a lignin/PAN hybrid precursor and carbon fiber conversion technologies leading to high performance, low-cost carbon fiber. Plasan Carbon Composites. General Motors LLC.

Carbon Fiber 268

Carbon Fiber Lithium Ion Li-ion Vehicles 268

Green Car Congress

APRIL 30, 2009

Italian motorsport electronics specialist Magneti Marelli and UK high-speed flywheel specialist Flybrid Systems are collaborating to develop a new energy storage solution for Kinetic Energy Recovery Systems (KERS). The energy is stored into the Flywheel Capacitor by speeding up the flywheel.

Flywheel Capacitor 210

Flywheel Capacitor Carbon Fiber Energy Storage Hybrid Racing 210

Green Car Congress

JULY 11, 2015

Lightning Hybrids originally designed its own lightweight composite accumulator made of a thin steel or aluminum vessel wrapped with carbon fiber composite material. Steelhead has since increased its product line to include other products such as fuel storage vessels for vehicles running on compressed natural gas (CNG)).

Hybrid 150

Hybrid Carbon Fiber Store International 150

Green Car Congress

DECEMBER 20, 2013

VTO focuses on a mix of near- and long-term vehicle technologies including advanced batteries, power electronics and electric motors, lightweight and propulsion materials, advanced combustion engines, advanced fuels and lubricants, and other enabling technologies. Broadly, VTO program activities are focused on achieving: Saving 1.4

Vehicles 246

Vehicles Fuel Economy Carbon Fiber Plug-in 246

Green Car Congress

JULY 10, 2010

Improved Magnetic Materials for Motors. High-temperature, high-strength, lower-cost permanent magnets (PMs) are needed for traction motors for HEVs and PHEVs. Grant applications are sought to economically produce core material and magnet material with high resistivity that would improve motor efficiency and reduce fabrication costs.

Fuel 210

Fuel Motor Motors Motoring 210

Green Car Congress

SEPTEMBER 15, 2009

At the Frankfurt Motor Show, Audi unveiled the e-tron. a high-performance electric sports car featuring four drive motors—two each at the front and rear axles—making the concept car a true quattro. The two rear electric motors, which have their own cooling system, are mounted behind the rear axle. The Audi e-tron concept.

Audi 257

Audi Concept Cars Electric 257

Green Car Congress

NOVEMBER 30, 2017

With hybrid-specific all-wheel drive, the combustion engine driving the rear wheels and the electric motor driving the front wheels, acceleration from 0 to 60 mph takes just 4.2/4.4 These extra energy reserves have made it possible to raise the electric motor’s peak output by 12 hp to 141 hp; maximum torque is 184 lb-ft (249 N·m).

BMW 170

BMW 2019 Power Powered 170

Green Car Congress

MARCH 28, 2014

Range extending hybrids are a synergy between electric trucks and series hybrids, and their design reduces the energy storage size required for trucks to run on batteries alone. These shorter trips reduce the vehicles’ average trip speed and create more opportunities to recover energy through regenerative braking.

Li-ion 371

Li-ion Peterbilt Range Electric Vehicles 371

Green Car Congress

FEBRUARY 2, 2013

Carbon Fiber Polymer Composite. There is an emphasis on developing and improving energy storage technologies, as they are one of the most critical components needed to enable the wide-spread commercialization of electric drive vehicles. Steel (Mild, HSLA, AHSS, or Boron automotive alloy). Characteristics. Earlier post.)

Li-ion 240

Li-ion Fuel Vehicles Lithium Ion 240

Green Car Congress

DECEMBER 14, 2018

For the fifth season of the championship, ZF has developed an electric driveline for Venturi that includes an electric motor as well as newly developed transmission and power electronics. The Gen2 car will celebrate its debut on the track with double the battery energy storage capacity of its predecessor, the Gen1 car.

Monaco 239

Monaco Carbon Fiber Electric Electrical 239

Green Car Congress

AUGUST 27, 2020

The US Department of Energy announced $33 million in funding for 17 projects as part of the Advanced Research Projects Agency-Energy’s (ARPA-E) Aviation-class Synergistically Cooled Electric-motors with iNtegrated Drives (ASCEND) and Range Extenders for Electric Aviation with Low Carbon and High Efficiency (REEACH) programs.

Carbon 218

Carbon Hybrid Electric Electrical 218

Cars That Think

APRIL 27, 2022

It’s made almost entirely of carbon fiber bows that act as springs, along with rubber bands that store energy in tension. The center bit of the robot includes a motor, some batteries, and a latching mechanism attached to a string that connects the top of the robot to the bottom. times the mass of the motor. “We

Carbon Fiber 98

Carbon Fiber Store Motor Motors 98

Green Car Congress

FEBRUARY 15, 2022

SMCs are key to increased energy density and efficiency of electric motors and enable miniaturized electric vehicle chargers, transformers, and power generators. The battery would provide a transportation energy storage solution that could be charged very fast and have a comparable energy density with the state-of-the-art lithium ion.

Clean 284

Clean Cleaning Energy Li-ion 284

Green Car Congress

JULY 2, 2010

Its partner, the Life module, consists primarily of a high-strength and extremely lightweight passenger cell made from carbon fiber reinforced plastic (CFRP). The new vehicle architecture enables new production processes which are both simpler and more flexible, and use less energy, BMW said. The importance of weight.

BMW 247

BMW Design Carbon Fiber Vehicles 247

Green Car Congress

AUGUST 14, 2014

This includes improving “beyond lithium-ion technologies” that use higher energy storage materials, and developing and commercializing wide bandgap (WBG) semiconductors that offer significant advances in performance while reducing the price of vehicle power electronics. Ford Motor Company. Ford Motor Company. Eaton Corp.

Plug-in 299

Plug-in Li-ion Plug Vehicles 299

Green Car Congress

APRIL 10, 2012

Applicants are sought to develop electrochemical energy storage technologies which support commercialization of micro, mild, and full HEVs, PHEVs, and EVs. Materials for Traction Drive Motor Laminations, Cores, or Structures. L/100 km) for cars and more than 43 mpg (5.5 L/100 km) for trucks by 2025. kW in 2020 are needed.

Hydrogen 210

Hydrogen Fuel Range Vehicles 210

Green Car Congress

JANUARY 12, 2010

Audi introduced a new electric sportscar concept at the North American International Auto Show, its second following the introduction of the initial e-tron at the 2009 Frankfurt Motor Show in September. The two motors, which have their own cooling system, are mounted on the rear axle. Drive / motors. Earlier post.). Pack weight.

Detroit 246

Detroit Audi Concept Electric 246

Green Car Congress

JANUARY 22, 2014

AOI 2: Integrated Computational Materials Engineering (ICME) Development of Carbon Fiber Composites for Lightweight Vehicles. ($6M) For the purposes of this AOI, a carbon fiber composite is defined as a composite that combines carbon fiber with polymer resin. Carbon Fiber Composite Targets.

Emissions 252

Emissions Vehicles Fuel Economy Carbon Fiber 252

Green Car Congress

NOVEMBER 28, 2012

Like the original BMW i3 Concept ( earlier post ), the three-door coupe is propelled by an electric motor developed by the BMW Group, which develops a maximum output of 125 kW/170 hp and peak torque of 250 N·m (184 lb-ft). The passenger cell forms the core of the Life module, which is built from carbon fiber-reinforced plastic (CFRP).

BMW 225

BMW Connect Connected Concept 225

Green Car Congress

JANUARY 21, 2016

US Energy Secretary Ernest Moniz used the Washington DC Auto show as the venue to announce $58 million in funding for vehicle technology advancements. Carbon Fiber Polymer Composite. Area of Interest (AOI) 5: Advances for the Production of Low Cost Electric Drive Vehicle Motors.

Li-ion 150

Li-ion Ni-Li Vehicles Grid 150

Charged EVs

MAY 18, 2021

The battery packs were made by Williams Advanced Engineering, and a few other components such as motors, inverters and braking systems were made by undisclosed companies. There are two motors, each with 200 kW (225 hp) of power. The front and rear motors are traditionally cooled with water.”. Total torque is 450 Nm.

Saudi Arabia 67

Saudi Arabia Hydrogen Fuel Charging 67

Green Car Congress

JULY 17, 2015

The PHEV (Plug-in Hybrid Electric Vehicle), a subset of the electric car, combines a primary electric motor with a much smaller back-up engine fueled with a hydrocarbon/biofuel mix. (In These variations must be managed by adding a great deal of electric energy storage in order to work on a mass scale.

PHEV 150

PHEV Plug-in Renewable Energy 150