Green Car Congress

JUNE 20, 2014

Performance of the new ESTEC engine (1NR-FKE) compared to the current 1NR-FE engine applied in the Yaris. Engineers at Toyota have developed an approach to applying the Atkinson cycle—used in the engines in Toyota hybrids since 1997—for engines in conventional, non-hybrid vehicles. Yamada et al.

Fuel Economy 278

Fuel Economy Economy Engine Toyota 278

Green Car Congress

JANUARY 18, 2013

Huff Fuels, Engines and Emissions Research Center, Oak Ridge National Laboratory. This website, jointly maintained by the US Department of Energy and the US Environmental Protection Agency (EPA), provides information such as official EPA “window label” fuel economy estimates for city, highway, and combined driving for all U.S.-legal

Fuel Economy 326

Fuel Economy Economy Fuel MPH 326

Green Car Congress

SEPTEMBER 7, 2017

A team at Carnegie Mellon University has found that engineering design modifications that compromise other performance attributes—specifically acceleration—offer a pathway to reduce the cost to automakers of compliance with fuel economy standards. —Whitefoot et al.

Fuel Economy 150

Fuel Economy Economy Design Fuel 150

Green Car Congress

NOVEMBER 11, 2014

These formulations have also been certified by the American Petroleum Institute (API) to exceed requirements of the most recent service category issued by API’s Lubricants Group—the API SN “Resourcing Conserving” designation. A key component of the ILSAC GF-5 designation is demonstrated fuel economy improvement.

Fuel Economy 230

Fuel Economy Oil Economy Motor 230

Green Car Congress

DECEMBER 30, 2013

Prototype low-viscosity ionic liquid-additized engine oil demonstrated a 2% improved fuel economy compared to Mobil 1 5W-30 engine oil (3.93% over the 20W-30 baseline oil) in standard fuel efficiency engine dynamometer tests. Jun Qu, Dinesh G. Bansal, Bo Yu, Jane Y. Blau, Bruce G.

Fuel Economy 369

Fuel Economy Oil Economy Engine 369

Green Car Congress

JANUARY 25, 2020

The gasoline direct injection (GDI) engine is one of the most prominent technologies car manufacturers adopted to achieve the fuel economy and carbon dioxide emission goals established in 2012 by the US Environmental Protection Agency. will be equipped with GDI engines by 2025. will be equipped with GDI engines by 2025.

Climate 348

Climate Carbon Engine Fuel Economy 348

Green Car Congress

MARCH 14, 2013

The new SuperTruck achieved a 54% increase in fuel economy. and Peterbilt Motors Company, a division of PACCAR, released test results showing their demonstration SuperTruck tractor-trailer achieved a 54% increase in fuel economy, averaging nearly 10 mpg US (23.5 Sources of increased engine thermal efficiency.

Peterbilt 342

Peterbilt Fuel Economy Economy Fuel 342

Green Car Congress

SEPTEMBER 29, 2012

Laboratory and in-use fuel economy results Source: NREL. The NREL team collected and analyzed in-service fuel economy, maintenance, and other vehicle performance data on 11 hybrid (P100H) and 11 conventional diesel (P100D) step vans operated by the United Parcel Service (UPS) in Minneapolis. Click to enlarge.

Fuel Economy 350

Fuel Economy Economy Hybrid Diesel 350

Green Car Congress

OCTOBER 10, 2014

EPA released the latest edition of its annual report on trends in CO 2 emissions, fuel economy and powertrain technology for new personal vehicles in the US. Fuel economy has now increased in eight of the last nine years; average carbon dioxide emissions are also at a record low of 369 g/mile in model year 2013.

Fuel Economy 230

Fuel Economy MPG Economy EPA 230

Green Car Congress

JUNE 30, 2016

Electric vehicles (EVs) will need to increase their combined market share to 16% by 2020 for markets to achieve the aggressive fuel economy standards set by regulators, according to new research by the World Energy Council, the UN-accredited global energy body representing the entire energy spectrum. In the EU, the EV gap is 1.4

Fuel Economy 247

Fuel Economy 2020 Economy Standards 247

Green Car Congress

MARCH 6, 2013

Sivak found that while the vehicle fuel economy of the entire light-duty fleet improved by 40% (from 13 mpg US to 21.6 l/100km), because of the decrease in vehicle load, the occupant fuel economy only improved by 17% (from 24.8 Combining these two effects yields a reduction of about 14% in the amount of fuel used.

Fuel Economy 311

Fuel Economy Economy Fuel North America 311

Green Car Congress

NOVEMBER 1, 2013

For the target market (the Asian scooter market), the low NO x capability of the Pinnacle engine provides a significant cost benefit to manufacturers. Further, Pinnacle noted, recently developed hardware designed for additional lean limit extension is under test. When the entire vehicle costs around $700, that’s a significant difference.

Fuel Economy 231

Fuel Economy Economy Engine Fuel 231

Green Car Congress

MARCH 31, 2011

Illustration of a three-cylinder configuration of the Pinnacle opposed-piston engine. Startup Pinnacle Engines unveiled plans to commercialize a new, more efficient combustion engine by 2013. The Pinnacle engine is based on a four-stroke, spark-ignited (SI), opposed-piston, sleeve-valve architecture. Click to enlarge.

Fuel Economy 236

Fuel Economy Engine Economy Fuel 236

Green Car Congress

NOVEMBER 3, 2017

Initially, the researchers have focused on the combustion of liquid fuel sprays found in engines, where the extreme pressures and temperatures create an environment that is optically challenging. Imaging flames at temperatures and pressures found in engines can be difficult because of a phenomenon called “beam steering.”

Fuel Economy 150

Fuel Economy Economy Emissions Fuel 150

Green Car Congress

MARCH 22, 2017

l/100 km) in 2016, the The ICCT team assessed increased consumer label fuel economy (as opposed to the regulatory test fuel economy) to 35 mpg (6.71 The resulting trajectory would reduce CO 2 emissions by half and increase fuel economy by more than 60% from 2016 through 2030. Advanced engines.

Fuel Economy 210

Fuel Economy Economy Fuel Price 210

Green Car Congress

AUGUST 19, 2012

Dennis Assanis at the University of Michigan suggests that accessing the “thermodynamic sweet spot” in high-efficiency, dilute, boosted gasoline engines has the potential for vehicle fuel economy gains between 23% and 58%. Their paper is published in the International Journal of Engine Research. —Lavoie et al.

Fuel Economy 236

Fuel Economy Gasoline Economy Engine 236

Green Car Congress

MARCH 24, 2016

Autonomous vehicle driving behavior can have a considerable effect on fuel economy. However, the study also showed that autonomous vehicle (AV) technology following algorithms designed without considering efficiency can degrade fuel economy by up to 3%. —Mersky and Samaras (2016).

Fuel Economy 150

Fuel Economy Economy Fuel Vehicles 150

Green Car Congress

MAY 9, 2012

Christopher Thomas, BorgWarner VP, Advanced Engineering, Engine Group and VP, Advanced Engineering, Drivetrain Group presented the basic concepts of VEMB and current BorgWarner test results at the recent SAE 2012 High Efficiency IC Engine Symposium. improvement in fuel economy on an E-class vehicle (e.g.,

Fuel Economy 218

Fuel Economy Downsizing Economy Engine 218

Green Car Congress

MARCH 26, 2015

The Cummins team not only surpassed all fuel-economy targets, but also achieved criteria emissions lower than the stringent Tier 2/Bin 2 levels. The challenge was making those significant advancements while ensuring that the engine we produced would be commercially viable. Test cycle fuel economy (mpg). mpg (12.45

Fuel Economy 150

Fuel Economy Economy Diesel Light 150

Green Car Congress

FEBRUARY 20, 2012

A recent, independent, third-party test of a Thomas Built Buses Saf-T-Liner C2 against an IC Bus™ CE Series found that the SCR technology in the Thomas Bus delivers 7-27% better fuel economy than the EGR technology in the IC bus and, when factoring in the cost of diesel exhaust fluid (DEF), is the more cost-effective choice.

Fuel Economy 210

Fuel Economy Economy Fuel Exhaust 210

Green Car Congress

DECEMBER 13, 2013

EPA projects advanced transmissions (6+ speeds and CVTs), gasoline direct injection (GDI) systems, and turbocharged engines will be installed on at least 15% of all MY 2013 vehicles. MY 2012 adjusted fuel economy is 23.6 l/100 km) fuel economy, which, if achieved, will again represent all-time records. mpg, or 22%.

Fuel Economy 247

Fuel Economy 2012 Economy EPA 247

Green Car Congress

MAY 9, 2012

Researchers from Southwest Research Institute (SwRI) and Eaton have demonstrated the application of downspeeding and supercharging a diesel vehicle, in conjunction with optimizing transmission gear ratios and the shift schedule, to deliver a greater improvement in fuel economy than a downsped and turbocharged configuration.

Fuel Economy 199

Fuel Economy Economy Fuel Eaton 199

Green Car Congress

JANUARY 20, 2020

A team from the Beijing Institute of Technology and Beiqi Foton Motor are proposing a performance optimization strategy for the Atkinson cycle gasoline engine, which is playing a key role in the development of hybrid electric vehicles due to its greater fuel economy than a conventional Otto cycle engine. —Niu et al.

Engine 150

Engine Hybrid Fuel Economy Economy 150

Green Car Congress

AUGUST 21, 2018

XL received approval from the California Air Resources Board (CARB) to sell hybrid electric Ford F-250 pickup trucks in California, marking the 14 th CARB executive order achieved by the company. XL has earned the highest number of CARB executive orders for commercial vehicle electrification in the automotive industry. .

California 260

California Ford North America Fleet 260

Green Car Congress

SEPTEMBER 11, 2013

Among the objectives of the project is delivering a 5% fuel economy improvement by direct conversion of engine waste heat to useful electric power for light-duty vehicle application. For light duty passenger vehicles, the fuel economy improvement must be measured over the US06 cycle. Doug Crane, Gentherm.

Fuel Economy 218

Fuel Economy Waste Economy Fuel 218

Green Car Congress

AUGUST 17, 2015

In a new report, researchers at the University of Michigan Transportation Research Institute (UMTRI) have calculated the actual, on-road fuel economy for the entire fleet of all vehicles in the US, and for different classes of vehicles, with primary interest in light-duty vehicles (cars, pickup trucks, vans, and SUVs), between 1923 and 2013.

Fuel Economy 150

Fuel Economy Economy 2013 MPG 150

Green Car Congress

JULY 23, 2014

Enerpulse Technologies said that it has further identified the underlying mechanism by which its its pulsed energy ignition technology improves fuel economy, reduces emission and delivers higher torque in spark ignited (SI) internal combustion (IC) engines. —Wes Helgeson, senior research engineer. Earlier post.)

Fuel Economy 210

Fuel Economy Plug Economy Energy 210

Green Car Congress

FEBRUARY 25, 2014

Southwest Research Institute (SwRI) has built a demonstrator vehicle, based on a 2012 Buick Regal GS, incorporating the latest D-EGR (dedicated EGR) technology ( earlier post ), an outgrowth of SwRI’s HEDGE (High Efficiency Dilute Gasoline Engine) consortium projects ( earlier post ). The compression ratio of the engine was increased to 11.7:1

Fuel Economy 277

Fuel Economy Engine Fuel Economy 277

Green Car Congress

NOVEMBER 8, 2013

Increasingly efficient conventional combustion-engine vehicles will be key in moving towards a low carbon future, according to the GFEI. Far better fuel economy from cost-effective conventional technologies can keep fuel demand steady and save close to half the CO 2 emissions from cars by this date.

Fuel Economy 225

Fuel Economy Economy Plug-in Plug 225

Green Car Congress

MARCH 11, 2012

While engine size has been decreasing slightly in recent years, overall engine horsepower has continued to increase, with the notable exception of MY 2009. Nearly all engines now have multiple valves (approximately 85%) and variable valve timing (projected to approach 95% in MY 2011). and from 2.6% to 4.9%, respectively).

Fuel Economy 236

Fuel Economy 2011 Economy EPA 236

Green Car Congress

MARCH 15, 2013

Adjusted CO 2 emissions and adjusted fuel economy, MY 1975-2011. The report finds that CO 2 emissions rates and fuel economy values reflect a very favorable multi-year trend beginning in MY 2005. The fleet-wide average real world MY 2011 personal vehicle CO 2 emissions value is 398 g/mi and average fuel economy is 22.4

Fuel Economy 284

Fuel Economy 2012 EPA Economy 284

Green Car Congress

JANUARY 5, 2015

Drive cycle fuel economy for PFI, CDC, and multi-mode RCCI operation. Their paper is published in the International Journal of Engine Research. RCCI is a dual-fuel combustion technology developed by Dr. Rolf Reitz and colleagues at the University of Wisconsin-Madison Engine Research Center laboratories.

Fuel Economy 150

Fuel Economy Economy Light Fuel 150

Green Car Congress

APRIL 25, 2016

In a paper presented at the 2016 SAE World Congress, Tula Technology, developer of Dynamic Skip Fire (DSF) cylinder deactivation technology, reported significant fuel economy gains of up to 18% over a conventional GM 6.2-liter Meaning, DSF reduces fuel consumption by 14-18% over V8. liter V8 by operating using Dynamic Skip Fire.

Fuel Economy 150

Fuel Economy Economy GM GMC 150

Green Car Congress

JUNE 27, 2011

Federal-Mogul Corporation has developed an electrical brushless diesel fuel pump for on- and off-highway engines with significantly improved durability. Federal-Mogul says that its electrical brushless fuel pump addresses the shortcomings of a conventional fuel pump. Aviation JP fuel: > 2,000 hours.

Fuel Economy 302

Fuel Economy Diesel Economy Fuel 302

Green Car Congress

AUGUST 31, 2021

Biologists at Sandia National Laboratories have developed comprehensive software that will help scientists in a variety of industries create engineered chemicals more quickly and easily. Synthetic biology involves redesigning organisms for useful purposes by engineering them to have new abilities.

Engine 221

Engine Fuel Economy Waste Industrial 221

Green Car Congress

SEPTEMBER 8, 2011

The types of vehicles consumers select has by far the most dominant impact on on-road fuel economy—the best vehicle currently available for sale in the US is nine times more fuel efficient than the worst vehicle. Average on-road fuel economy in the US for all vehicles in 2008 was 17.4 mpg US (13.5

Fuel Economy 252

Fuel Economy Economy Fuel North America 252

Green Car Congress

MARCH 5, 2022

Cumulative greenhouse gas emissions versus vehicle mileage for (a) internal combustion engine and battery electric sedans, SUVs, and pickup trucks, and (b) hybrid electric and battery electric sedans, SUVs, and pickup trucks. For battery-electric vehicles and internal-combustion-engine vehicles, the breakeven time is 1.2 Woody et al.

Light 435

Light Gas Ford Vehicles 435