Green Car Congress

APRIL 20, 2010

CO 2 reduction potential vs. OEM On-cost for turbocharged GDi and turbo-Diesel technologies to meet Euro 6 standards. The Delphi study assessed the technology of downsizing and turbocharging; GDI fueling and its synergies with turbocharging; and an analysis of downsized 3-cylinder versus 4-cylinder engines. Source: Kirwan et al.

Gasoline 231

Gasoline Downsizing Engine CO2 231

Green Car Congress

MAY 23, 2009

Schematic of downsized and supercharged four-stroke hybrid pneumatic spark injection engine. The reduction in fuel consumption is obtained mainly through enabling the effective use of a heavily downsized engine, rather than from regenerative efficiency. Source: ETH Zürich. Click to enlarge. Earlier post.). Earlier post.). Dönitz et al.

Downsizing 170

Downsizing Concept Engine Hybrid 170

Green Car Congress

DECEMBER 1, 2014

At the 2 nd International Conference Automotive 48 V Power Supply Systems , held last week in Düsseldorf, Germany, Controlled Power Technologies (CPT), a major sponsor of the event, together with leading car makers and Tier 1 suppliers, argued the need for an internationally agreed 48V electrical standard. Click to enlarge. The conference.

Standards 257

Standards International Vehicles Hybrid 257

Green Car Congress

AUGUST 4, 2011

However, while Mazda plans to offer hybrid vehicles in the medium-term, its engineers are pushing hard to increase the efficiencies of both the gasoline and diesel platforms, moving toward what they call “the ideal Internal Combustion Engine.” Extreme compression ratio rather than downsizing. Although downsizing—i.e.,

Mazda 322

Mazda Engine Gasoline Diesel 322

Green Car Congress

MAY 14, 2009

Continuing to emphasize a downsizing approach, Volkswagen presented two new engines at the at the 30 th Vienna Engine Symposium (7-8 May): the 1.2-liter liter TSI gasoline engine and the 1.6-liter The potential of internal combustion engines is far from exhausted. It meets the EU 5 exhaust emission standard.

Downsizing 150

Downsizing Engine MPG Exhaust 150

Green Car Congress

SEPTEMBER 4, 2013

This combined combined aggressive 50% downsizing of the engine with an electric supercharger for transient low-speed performance and a 12+X volt micro-hybrid stop-start and energy recuperation systems. It is capable of operating in exhaust temperatures up to 850 °C, at speeds up to 60,000 rpm and delivering a peak power of 2 kW (@12V).

Fuel Economy 239

Fuel Economy Diesel Economy Gasoline 239

Green Car Congress

NOVEMBER 17, 2013

liter EcoBoost gasoline turbocharged direct injection (GTDI) four-cylinder unit. Featuring a twin-scroll turbocharger and a three-port integrated exhaust manifold (IEM), the 2.3-liter Featuring a twin-scroll turbocharger and a three-port integrated exhaust manifold (IEM), the 2.3-liter Ford specifically engineered the 2.3-liter

Louisville 286

Louisville Exhaust Future Fuel Economy 286

Green Car Congress

MAY 6, 2013

The new MY2014 Mercedes-Benz Sprinter van for the US now features a 2.1L, 4-cylinder diesel with a t-speed automatic transmission as standard. The two overhead camshafts actuate 16 intake and exhaust valves. Charging takes place at all times via a two-stage exhaust-gas turbocharger system.

2014 306

2014 Diesel Standards Exhaust 306

Green Car Congress

MARCH 14, 2010

In addition to its twin turbos, the new eight-cylinder unit—known internally as the M 157—features gasoline direct injection with spray-guided combustion and twin turbochargers. The improved fuel economy is also in large measure due to the standard stop-start function. AMG has developed a 5.5-liter The new AMG 5.5-liter

Downsizing 186

Downsizing Standards Fuel Mercedes 186

Green Car Congress

SEPTEMBER 30, 2014

Automakers are turning to downsized turbocharged engines to satisfy more stringent global fuel economy and emission regulations and customer demand for better-performing vehicles. In addition to improving fuel efficiency, downsized turbocharged engines also reduce harmful exhaust emissions.

2019 261

2019 Global Sale Downsizing 261

Green Car Congress

MAY 27, 2014

has launched the New Skyline 200GT-t (the next-generation turbo model) featuring a high-power, fuel-efficient lightweight turbocharged gasoline engine with maximum power output of 155 kW?(208 All grades of the next-generation Skyline turbo model achieve the 2015 fuel economy standard, qualifying for tax breaks.

Japan 262

Japan Nissan Fuel Economy Economy 262

Green Car Congress

AUGUST 10, 2009

Under California’s vehicle emissions ratings, PZEVs (Partial Zero Emission Vehicles) meet SULEV (Super Ultra Low Emission Vehicle) tailpipe emission standards and also have zero evaporative emissions. The SULEV standard, established under the current LEV II regulation, is equivalent to the Federal Tier 2 Bin 2 standard.

Gasoline 150

Gasoline Diesel Engine Emissions 150

Green Car Congress

JUNE 29, 2012

For the 2013 XF and XJ lineup, Jaguar is adding two new downsized forced induction gasoline powerplants: 3.0-liter liter V8 gasoline units. Eight-speed ZF automatic transmissions are now fitted to all gasoline and diesel XJ and XF variants as standard for greater efficiency and performance. liter i4 Turbodiesel, 3.0-liter

Gasoline 225

Gasoline Engine 2013 MPH 225

Green Car Congress

MARCH 5, 2014

Among the changes in the new Juke are a new design at the front and rear with greater emphasis on both premium refinement and sporty design cues; a new downsized 1.2-liter Three engines are available for new Juke, with changes to the two gasoline options: one is new and the other extensively revised. Click to enlarge. The existing 1.5

Nissan 255

Nissan Engine Downsizing Europe 255

Green Car Congress

SEPTEMBER 11, 2015

Today’s CNG vehicles are generally bivalent, running on gasoline and CNG with engines designed for gasoline direct injection. However, because methane behaves differently from gasoline when injected directly, it is important to optimize the combustion process for methane. By 2025, this limit could be even lower.

Gas 150

Gas Engine Gasoline Downsizing 150

Green Car Congress

JUNE 18, 2013

Bosch does not believe there is just one powertrain solution for the future; most of the cars on the world’s roads are still running on diesel and gasoline, and things will stay that way for the rest of the decade, Bohr noted. Only the diesel engine will achieve this in the compact class, but the gasoline engine will come close.

Future 291

Future Gasoline-Electric Vehicles Gasoline 291

Green Car Congress

MAY 25, 2009

liter, four-cylinder turbocharged gasoline direct-injection engine—the 1.8 Di Turbo Jet E5 drive torque is comparable to the one of an aspirated V6 engine which is almost twice its displacement, according to Fiat, but with significant efficiency gains through the downsizing. The 200 HP 1.8 Di TurboJet. Click to enlarge.

Gasoline 150

Gasoline Exhaust Engine Convert 150

Green Car Congress

MARCH 8, 2012

The new Yaris Hybrid, which is equipped with a version of the downsized hybrid powertrain featured in the Prius c/Aqua ( earlier post ), is a major step in the company’s full hybrid European roll-out strategy. The downsized full hybrid system combines the new 1NZ-FXE 1.5-liter liter Atkinson Cycle gasoline engine is 16.5

Hybrid 240

Hybrid Toyota Downsizing Sale 240

Green Car Congress

JUNE 16, 2015

The entire engine range (115 to 220 PS) meets the Euro-6 standard. The two gasoline (TSI) and three diesel (TDI) engines are four-cylinder, 16-valve engines feature turbocharging and direct fuel injection. Also included as standard is a Stop-Start system plus battery regeneration mode (BlueMotion Technology / BMT). l/100 km (36.8

Standards 150

Standards Fuel MPG Batteries 150

Green Car Congress

SEPTEMBER 29, 2011

At 48 volts, a VTES electric supercharger will transform 7kW of battery power into a highly boosted charge of air for downsized gasoline and diesel engines. There will be no torque deficit or other tradeoffs from essential engine downsizing and higher gearing, which now dominates the development of internal combustion engines.

Volt 207

Volt Hybrid Downsizing Lead Acid 207

Green Car Congress

SEPTEMBER 22, 2009

VTES is optimized to use the standard 12V vehicle architecture. When applied to a radically downsized 1.2-liter liter turbocharged engine, VTES delivers in excess of a 50% increase in torque at engine speeds below 3,000rpm, more than compensating for insufficient power from the exhaust turbine. Compared with a 1.6-liter

Downsizing 231

Downsizing Electric Electrical Exhaust 231

Green Car Congress

AUGUST 4, 2009

Heat required to bring the fuel to SC states is recovered from the exhaust gas of the engine. Given the high reactivity of diesel fuels compared to gasoline, the ignition and combustion of pre-mixed fuel-air charges poses a challenging control problem. Earlier post.). At SC conditions, however (T?450 450 °C, P ?600

Diesel 225

Diesel Fuel Emissions 2009 225

Green Car Congress

OCTOBER 8, 2015

Having better control over the combustion process reduces the emission load on the exhaust aftertreatment systems. Eminox SCRT technology can significantly reduce harmful diesel exhaust gases, particularly in urban operating conditions. —Andy Dickinson, the senior manager at CPT responsible for Cobra. —Andy Dickinson.

Vehicles 150

Vehicles Exhaust Emissions Diesel 150

Green Car Congress

MAY 17, 2013

Relative changes in vehicle energy efficiency (VEE) (km/MJ) on ethanol/gasoline blends over those on gasoline for different blending levels. Standard deviations increase by >10% and >200% when used in high and low blends, respectively. Credit: ACS, Yan et al. Click to enlarge.

Fuel 210

Fuel Energy Gasoline-Electric Gasoline 210

Green Car Congress

JUNE 7, 2010

Renault’s ongoing downsizing strategy is aimed at reducing the cubic capacity of its engines in order to bring down fuel consumption and CO 2 emissions, without detracting from performance. The downsizing process involved shortening the piston stroke by reducing the size of the crank pin and conrod assembly. Select Engines.

Environment 230

Environment Engine 2010 Parts 230

Green Car Congress

APRIL 24, 2010

In recent years two methods, namely downsizing and downspeeding, were established on the market to reduce CO 2 emissions while maintaining the driving performance of engines with identical effective power but a larger displacement. bar) is achieved by applying high- or low-pressure exhaust-gas recirculation loops. < IMEP < 22.5

Engine 170

Engine Hybrid Fuel Exhaust 170

Green Car Congress

SEPTEMBER 30, 2009

The new Astra is launching with a complete line-up of eight gasoline and diesel engines ranging from 70 kW/95 hp to 132 kW/180 hp. The gasoline range comprises naturally-aspirated and turbocharged 1.4 The average fuel consumption of the four gasoline engine line-up is 6.1 Turbo gasoline engine replaces the current 1.8

Exhaust 199

Exhaust MPG Gasoline-Electric Engine 199

Green Car Congress

SEPTEMBER 23, 2014

The new approach to natural gas combustion technology is designed to provide vehicle and engine original manufacturers (OEMs) with a “downsized” natural gas solution that is cost competitive while providing similar levels of power, torque, and fuel economy to a larger diesel engine. Environmental Protection Agency 2014 standards.

Diesel 259

Diesel Gas Fuel Economy Power 259

Green Car Congress

DECEMBER 9, 2016

In addition, Honeywell’s forecast calls for electric boosting products to help support compliance with more stringent national environmental standards. Regional highlights include: In North America, more engine downsizing is expected. The current average engine size is a 3.0-liter liter six-cylinder.

Global 150

Global Sale Transportation Vehicles 150

Green Car Congress

JULY 7, 2014

liter Atkinson-cycle gasoline engine, which brings the brand’s number of hybrid offerings to six—the most among luxury brands. liter turbocharged gasoline engine has a combination water-cooled cylinder head, integrated exhaust manifold and twin-scroll turbocharger. Standard energy-efficient LED headlights and taillights.

North America 210

North America Lexus America Fuel Economy 210

Green Car Congress

APRIL 17, 2014

GDCI engine was significantly better than advanced production spark injection gasoline engines, and comparable to very efficient hybrid vehicle engines at their best efficiency conditions (214 g/kWh). This early work established that gasoline-like fuels with high resistance to autoignition are preferred for PPCI. 35% (PFI baseline).

Gasoline 304

Gasoline Engine Fuel Wisconsin 304

Green Car Congress

APRIL 10, 2014

ExxonMobil, Corning and Toyota have collaborated to develop an Onboard Separation System (OBS) to optimize gasoline engine efficiency and performance. In a paper on the OBS presented at the SAE 2014 World Congress, the researchers suggested that potential applications include downsizing to increase fuel economy by ?10% Background.

Gasoline 316

Gasoline Engine Toyota Fuel Economy 316

Green Car Congress

SEPTEMBER 16, 2009

Ford revealed further details of the upcoming four-cylinder versions of its turbocharged, gasoline direct-injected EcoBoost engine family (earlier post) at the Frankfurt Motor Show, prior to their first European production applications in 2010. I-4 EcoBoost. Click to enlarge. The all-new EcoBoost 1.6-liter liter and 2.0-liter liter and 2.0-liter

Engine 186

Engine Ford Downsizing United Kingdom 186

Green Car Congress

AUGUST 16, 2016

Most of the projects will support the goals of EV Everywhere, an Energy Department program that aims to make PEVs as affordable and convenient as gasoline-powered vehicles by 2022. valve faces, piston crowns, and exhaust ports) to improve fuel economy. valve faces, piston crowns, and exhaust ports) to improve fuel economy.

Vehicles 150

Vehicles Plug-in Lithium Ion Universal 150

Green Car Congress

JUNE 2, 2015

mpg US) (99 g/km CO 2 )—more efficient than any previous Golf with a gasoline engine. The new TSI engine also offers the highest specific torque of any large-scale production series gasoline engines: 200 N·m per liter displacement. The turbocharged gasoline engine with its 10.5:1 The exhaust manifold of the 1.0

Gasoline 150

Gasoline MPG Exhaust Engine 150

Green Car Congress

OCTOBER 2, 2014

Hyundai Motor is showcasing two new turbocharged gasoline direct injected (T-GDI) engines at the Paris Motor Show 2014. liter T-GDI is the first of a new generation of small turbocharged gasoline engines, offering enhanced performance, driving pleasure and efficiency. New engines and transmission. Click to enlarge. liter and 1.4-liter

Hyundai 239

Hyundai Downsizing Engine Hybrid 239

Green Car Congress

NOVEMBER 23, 2011

Whereas future US gasoline demand is expected to be flat for the next 20 years, diesel fuel demand is expected to grow, necessitating changes in refinery operations. the validation, demonstration, and deployment of advanced truck and bus technologies, and growing their reliability sufficient for adoption in the commercial marketplace.

EPA 199

EPA Fuel Engine Hybrid 199