Green Car Congress

MAY 16, 2019

Reducing the number of exhaust gas particulates, including those smaller than 23 nm, will help manufacturers meet increasingly stringent future global emissions standards. —Walter Piock, chief engineer, Gasoline Systems, Delphi Technologies. Delphi 500+ bar GDi pump.

Emissions 257

Emissions Gasoline Fuel Exhaust 257

Green Car Congress

AUGUST 19, 2012

Dennis Assanis at the University of Michigan suggests that accessing the “thermodynamic sweet spot” in high-efficiency, dilute, boosted gasoline engines has the potential for vehicle fuel economy gains between 23% and 58%. Assanis (2012) Thermodynamic sweet spot for high-efficiency, dilute, boosted gasoline engines.

Fuel Economy 236

Fuel Economy Gasoline Economy Engine 236

Green Car Congress

JANUARY 19, 2014

Exhaust particle size distributions measured by ELPI (color map) and particle concentration measured by CPC (white line) during individual engine braking conditions (speed change from 32 km/h to 0 km/h). The exhaust sample was taken from the exhaust manifold. The exhaust sample was taken from the exhaust manifold.

Exhaust 319

Exhaust Engine Fuel Greece 319

Green Car Congress

SEPTEMBER 4, 2013

The project aims to deliver full hybrid equivalent fuel economy and performance with less than 70 g/km CO 2 emissions as measured over the European Drive Cycle, but at a significantly lower cost. version of its vehicle (a 2009 Ford Focus) but with fuel economy and CO 2 emissions approaching those of a Prius.

Fuel Economy 239

Fuel Economy Diesel Economy Gasoline 239

Green Car Congress

JUNE 20, 2014

liter ESTEC (Economy with Superior Thermal Efficient Combustion) in-line 4-cylinder Gasoline Engine (1NR-FKE). Further, at low loads, the ESTEC engine improves fuel consumption by 11% in the JC08 mode. Further, at low loads, the ESTEC engine improves fuel consumption by 11% in the JC08 mode. Performance recovery.

Fuel Economy 278

Fuel Economy Economy Engine Toyota 278

Green Car Congress

FEBRUARY 25, 2014

Southwest Research Institute (SwRI) has built a demonstrator vehicle, based on a 2012 Buick Regal GS, incorporating the latest D-EGR (dedicated EGR) technology ( earlier post ), an outgrowth of SwRI’s HEDGE (High Efficiency Dilute Gasoline Engine) consortium projects ( earlier post ). In 2013, SwRI reported a 2.0-liter

Fuel Economy 277

Fuel Economy Engine Fuel Economy 277

Green Car Congress

MARCH 25, 2015

Using technology from the 2016 Chevrolet Volt propulsion system ( earlier post ), Malibu Hybrid will offer an estimated combined fuel economy rating exceeding 45 mpg (5.22 The engine also features Chevrolet’s first application of Exhaust Gas Heat Recovery, or EGHR, technology, which uses exhaust heat to warm the engine and cabin.

Fuel Economy 150

Fuel Economy Malibu Hybrid MPG Volt 150

Green Car Congress

AUGUST 8, 2017

As part of the new technology to achieve this vision, the company disclosed plans to introduce a next-generation gasoline engine called SKYACTIV-X in 2019. This new proprietary combustion engine combines the advantages of gasoline and diesel engines to optimize environmental performance, power and acceleration performance. Yamasaki, Y.,

Mazda 186

Mazda Gasoline Fuel Economy Gasoline-Electric 186

Green Car Congress

MARCH 26, 2015

The Cummins team not only surpassed all fuel-economy targets, but also achieved criteria emissions lower than the stringent Tier 2/Bin 2 levels. The demonstration vehicle, provided by Nissan North America, is a 2010 Nissan Titan originally equipped with a gasoline V8 engine. Test cycle fuel economy (mpg).

Fuel Economy 150

Fuel Economy Economy Diesel Light 150

Green Car Congress

FEBRUARY 22, 2018

The researchers assessed the gaseous, particulate, and genotoxic pollutants from two current technology gasoline direct injection vehicles when tested in their original configuration and with a catalyzed gasoline particulate filter (GPF). Yang et al. Click to enlarge.

Gasoline 253

Gasoline Emissions Engine Fuel Economy 253

Green Car Congress

JANUARY 5, 2015

Drive cycle fuel economy for PFI, CDC, and multi-mode RCCI operation. Among their findings were that multi-mode RCCI has the potential to offer greater than 15% fuel economy improvement over a 2009 gasoline PFI baseline over many light-duty driving cycles, despite the lack of complete drive cycle coverage for RCCI mode.

Fuel Economy 150

Fuel Economy Economy Light Fuel 150

Green Car Congress

JULY 23, 2014

Enerpulse Technologies said that it has further identified the underlying mechanism by which its its pulsed energy ignition technology improves fuel economy, reduces emission and delivers higher torque in spark ignited (SI) internal combustion (IC) engines. Earlier post.) —Wes Helgeson, senior research engineer.

Fuel Economy 210

Fuel Economy Plug Economy Energy 210

Green Car Congress

JUNE 26, 2018

Corning Incorporated’s Environmental Technologies business reached a significant production milestone at its Kaiserslautern, Germany manufacturing facility with the production of its 1 millionth Corning DuraTrap GC gasoline particulate filter (GPF) for automotive emissions control.

Gasoline 186

Gasoline Production China Exhaust 186

Green Car Congress

MAY 31, 2017

A joint study by Controlled Power Technologies (CPT) and Austria’s Technische Universität Wien (TU Wien) into 48V diesel mild hybrid technology verified a 9% reduction of NO x in raw engine-out emissions, while retaining the fuel economy and CO 2 benefits of diesel engine technology.

Fuel Economy 150

Fuel Economy Diesel Economy Engine 150

Green Car Congress

JUNE 2, 2014

Although gasoline direct injection engines (GDI) are a favorable technology for reducing fuel consumption and greenhouse gas emissions, recent studies have shown that GDI vehicles could emit more PM than traditional PFI (gasoline port fuel injection) vehicles as well as heavy-duty diesel trucks equipped with diesel particulate filters.

Environment 230

Environment Exhaust Gasoline Canada 230

Green Car Congress

JULY 11, 2020

The expected fuel economy ratings will deliver the highest driving range on one tank of fuel yet for Gladiator. There are more than 40 individual shift maps to optimize shift points for fuel economy, performance and 4x4 capability. 1 to improve fuel economy and reduce engine noise. axle ratio.

Jeep 269

Jeep Available Fuel Economy Economy 269

Green Car Congress

APRIL 20, 2011

is the smallest Hyundai engine yet to benefit from the application of Gasoline Direct Injection technology. Total fuel savings. fed by multipoint fuel injection (MPI)— and 123 lb-ft (167 N·m) of torque with a 30 mpg city and 40 mpg highway fuel economy rating. The new Gamma 1.6L MPG Contributions.

Fuel Economy 236

Fuel Economy MPG Economy 2012 236

Green Car Congress

NOVEMBER 1, 2014

Corning Incorporated has boosted its light-duty vehicle filter capacity at its manufacturing facility in Kaiserslautern, Germany for both gasoline and diesel engined vehicles. Diesel vehicle manufacturers are striving for greater engine performance and fuel economy while meeting Euro 6 emissions standards under a myriad of driving conditions.

Germany 210

Germany Exhaust Light Fuel Economy 210

Green Car Congress

MARCH 6, 2012

liter gasoline-fueled TSI of the Polo BlueGT. The TSI develops a power output of 103 kW / 138 hp, with a combined fuel consumption of 4.7 If the Polo BlueGT is ordered with the optional 7-speed dual clutch gearbox (DSG), fuel consumption drops further to 4.5 TSI of the Polo BlueGT, an exhaust camshaft adjuster is added.

MPG 257

MPG Fuel Economy Gasoline Engine 257

Green Car Congress

APRIL 6, 2016

Since 2013, the share of premium gasoline in total motor gasoline sales in the US has steadily increased to 11.3% Further, there is increasing interest among stakeholders in exploring the benefits of higher octane fuels that would lead to higher compression ratios which would lead to more efficient engines and reduced fuel consumption.

Downsizing 150

Downsizing Gasoline Engine Design 150

Green Car Congress

JANUARY 2, 2019

Their paper is published in the ACS journal Energy & Fuels. Their paper is published in the ACS journal Energy & Fuels. Regulated emissions for all test fuels over the cold-start and hot-start LA92 cycles. A fuel economy penalty was also observed for lower energy content E30 and E78 blends compared to both E10 fuels.

Pollution 255

Pollution Fuel Vehicles Emissions 255

Green Car Congress

SEPTEMBER 6, 2012

At a “Go Further with Ford” event in Amsterdam, Ford Motor Company detailed plans for an aggressive product acceleration in Europe, targeting opportunities for growth in the large car, SUV and commercial vehicle segments while emphasizing fuel economy and enabling technologies such as the EcoBoost engines. New Fiesta.

Fuel Economy 261

Fuel Economy Europe Ford Economy 261

Green Car Congress

MARCH 4, 2010

The use of a supercritical fuel charge enables very fast and complete combustion with minimized thermal losses. TSCi combustion minimizes heat loss to the cylinder walls and in the exhaust. The TSCi injectors can work with a range of fuels (given appropriate software adjustment and control). Source: Transonic. Earlier post.).

Fuel Economy 297

Fuel Economy Fuel Economy Engine 297

Green Car Congress

SEPTEMBER 16, 2015

Tenneco introduced its oval-shaped gasoline particulate filter design at the 2015 Frankfurt Motor Show. The filters are designed for gasoline direct injection (GDI) engines to reduce particulate emissions in compliance with the Euro 6c emissions regulations, which take effect on 1 September 2017.

Gasoline 150

Gasoline Fuel Economy Exhaust 2017 150

Green Car Congress

JANUARY 11, 2015

Peak torque arrives at 1,750 rpm in the Td6 while the gasoline V6 produces its 332 lb-ft (450 N·m) at 3,500 rpm. Similarly, the low-end torque of the Td6 allows the vehicles to deliver 0-60 acceleration times comparable to the higher horsepower V6 gasoline models. seconds for gasoline V6 models. for the Range Rover.

Land Rover 150

Land Rover Fuel Economy MPG Diesel 150

Green Car Congress

AUGUST 7, 2013

Opel will introduce the first in an all-new modular family of small-displacement three- and four-cylinder gasoline direct injection engines at the upcoming Frankfurt International Motor Show next month. Matthias Alt, Opel’s Chief Engineer, Small Gasoline Engines. Click to enlarge. The new three-cylinder 85 kW/115 hp, 1.0-liter

Fuel Economy 236

Fuel Economy Fuel Economy Engine 236

Green Car Congress

MARCH 31, 2014

The selected projects include 6 vehicle-related technologies and 2 hydrogen and fuel cell technologies, as well as new hydropower, heat pump, solar and manufacturing technologies. Hybrid Electric Turbocharger for Exhaust Energy Recovery and Transient Lag Reduction. A Novel Exhaust after Treatment Catalyst. Nextech Materials.

Exhaust 261

Exhaust Wind 2014 Motor 261

Green Car Congress

MAY 3, 2013

liter turbocharged and direct-injected TSI gasoline engine. The new engine delivers a manufacturer-estimated improvement in fuel efficiency for the Beetle models of between 4-8% percent on the combined cycle and by up to 9% percent on the city cycle. Engines Fuel Efficiency' Engine weight has been reduced by 8 lbs (3.6

Fuel Economy 284

Fuel Economy Engine Fuel Economy 284

Green Car Congress

OCTOBER 16, 2012

Opel revealed more details about its new mid-size gasoline engine family at the Aachen Colloquium in Germany. liter, four-cylinder, SIDI (spark ignition direct injection) ECOTEC Turbo engines, which begin Opel’s renewal of its powertrain portfolio, deliver improved fuel consumption, performance and refinement. Earlier post.)

Gasoline 350

Gasoline Engine Fuel Power 350

Green Car Congress

JULY 23, 2019

These changes increase Accent’s EPA estimated fuel economy to 33 mpg city, 41 highway, 36 combined, up considerably from the 28 city, 38 highway, 32 combined mpg rating with last year’s 1.6-liter liter Gasoline Direct Injection (GDI) engine and 6-speed automatic transmission. A chain improves fuel efficiency by an additional 1.2%

MPG 220

MPG 2020 Engine Hyundai 220

Green Car Congress

AUGUST 22, 2013

The European Union-funded PowerDriver project—a two-year, €3-million (US$4-million) research project initiated in February 2012 to turn exhaust gas waste heat into electricity using thermoelectric generator (TGEN) technology—has completed simulation work on on a potential automotive application.

Exhaust 210

Exhaust Waste Land Rover Fuel 210

Green Car Congress

SEPTEMBER 23, 2020

Importantly, dDSF is able to combine improved tailpipe emissions while simultaneously reducing fuel consumption, thus combining two critical objectives that have previously competed against each other. Engine controller with dDSF: Tula’s proprietary SW for smooth, efficient operation and fuel economy gains. Source: Tula.

Diesel 221

Diesel Future Fuel Economy China 221

Green Car Congress

JULY 16, 2020

With the refresh for 2021 Camry models, Toyota is introducing the first XSE Hybrid grade, combining the Camry’s most fuel-efficient powertrain with its highest expression of the sport and luxury blend. for XSE grade, which uses a dual-outlet exhaust). 2021 Camry XSE Hybrid. -ft. of peak torque at 5,000 rpm (206 hp and 186 lb.-ft.

Toyota 400

Toyota Hybrid Camry Hybrid Exhaust 400

Green Car Congress

SEPTEMBER 9, 2014

The new Ford Focus for Europe ( earlier post ) delivers the car’s most fuel-efficient powertrain line-up yet with improvements of up to 19%, and a significant CO 2 emission reduction across the entire line-up. liter EcoBoost gasoline engine and new Focus also will be available for the first time with Ford’s 1.5-liter liter and 2.0-liter

Fuel Economy 218

Fuel Economy Ford Europe Fuel 218

Green Car Congress

SEPTEMBER 23, 2010

liter V6, while also improving fuel economy. The 2011 Highlander Hybrid receives EPA estimated fuel economy ratings of 28 mpg city and 28 mpg highway (8.4 The 2010 Highlander Hybrid carries an EPA fuel economy rating of 27 mpg city, 25 mpg highway. liter V6 for 2011, replacing the previous 3.3-liter

Highlander 186

Highlander Fuel Economy 2011 Economy 186

Green Car Congress

FEBRUARY 7, 2014

Mercedes-Benz announced that seven new versions of the Mercedes-Benz A-, B- and CLA-Class now offer enhanced fuel savings compared with their respective predecessors. Stratified charge operation enables sharply reduced fuel consumption when running at lower loads. l/100 km (43.6 mpg US)—7% less compared to its predecessor.

Fuel Economy 236

Fuel Economy Mercedes Diesel Fuel 236

Green Car Congress

APRIL 9, 2014

improvement in city fuel economy (24.5 Southwest Research Institute (SwRI) announced preliminary test results of its Dedicated-Exhaust Gas Recirculation (D-EGR) demonstration vehicle ( earlier post ) at the SAE 2014 World Congress in Detroit. liter gasoline direct injection engine. liter gasoline direct injection engine.

Gasoline 317

Gasoline Emissions Diesel Exhaust 317