Emissions, Engine and Exhaust

Purem by Eberspaecher introduces efficient exhaust technology for hydrogen engines

Green Car Congress

MAY 25, 2022

Purem by Eberspaecher is introducing efficient exhaust technology for hydrogen engines. At the Hannover Messe, the company will be presenting its H 2 -ICE exhaust system for the first time. The H 2 -ICE exhaust system for hydrogen engines from Purem by Eberspaecher.

Exhaust

Exhaust Hydrogen Engine Conversion

New Emissions Analytics study suggests pollution from tire wear now 1,850 times worse than exhaust emissions

Green Car Congress

MAY 13, 2022

In early 2020, UK-based independent testing firm Emissions Analytics published a study claiming that tire particulate wear emissions were 1,000 times worse than exhaust emissions ( earlier post ). —Emissions Analytics. Quoting such ratios, however, needs careful interpretation.

Exhaust

Exhaust Emissions Pollution Legal

SwRI engineers develop near-zero emissions diesel engine technology; 90% reduction of NOx

Green Car Congress

MAY 27, 2020

Southwest Research Institute engineers have developed the next generation of clean diesel engine technology to reduce hazardous nitrogen oxides (NO x ) and carbon dioxide emissions while minimizing fuel consumption. g/hp-hr NO x emissions). g/hp-hr NO x emissions).

Engine

Engine Emissions Diesel 2020

Webinars

Tara's Event

MORE WEBINARS

Exhaust and aftertreatment on the Achates ULNOx heavy-duty opposed-piston diesel

Green Car Congress

DECEMBER 28, 2020

opposed-piston (OP) heavy-duty diesel engine achieved Ultralow NO x (ULNO x ) performance results. A key element of the achievement is the low engine-out NO x from the opposed-piston engine, which reduced the requirements for the aftertreatment system (ATS). Earlier post.)

Exhaust

Exhaust Diesel Engine Light

Optimized heavy-duty CI engine fueled with DME delivers diesel performance, significantly reduces engine-out emissions

Green Car Congress

AUGUST 14, 2023

A team from Empa - Swiss Federal Laboratories for Materials Science and Technology and FPT Motorenforschung reports in an open-access paper in the journal Fuel on the performance and emission characteristics of an 11-liter heavy-duty compression ignition engine which was optimized specifically for DME (dimethyl ether) combustion.

Engine

Engine Emissions Diesel Fuel

ClearFlame Engine Technologies partners with Alto Ingredients to demo ethanol-fueled MCCI in heavy-duty diesels; high efficiency, low emissions

Green Car Congress

MAY 18, 2021

Startup ClearFlame Engine Technologies announced a partnership with Alto Ingredients, a leading producer of specialty alcohols and essential ingredients, to conduct pilot demonstrations of ClearFlame’s solution for diesel engines using low-cost ethanol in Class 8 trucks.

Diesel

Diesel Emissions Engine Fuel

Mercedes-AMG, Garrett developing 48V electric exhaust gas turbocharger

Green Car Congress

JUNE 18, 2020

An electric exhaust gas turbocharger, which in future will be used for the first time in a series production model, is already in the final stages of development. This electronically-controlled electric motor drives the compressor wheel before this accepts the exhaust gas flow.

Exhaust

Exhaust Gas-Electric Mercedes Gas

UK expert group focuses attention on non-exhaust emissions from road traffic as regulatory concern

Green Car Congress

JULY 14, 2019

A new report released by the Air Quality Expert Group ( AQEG ) in the UK recommends as an immediate priority that non-exhaust emissions (NEE) are recognized as a source of ambient concentrations of airborne PM, even for vehicles with zero exhaust emissions of particles. and PM 10 emissions. of all UK primary PM 2.5

Exhaust

Exhaust Emissions Ireland Pollution

Achates opposed-piston 3-cylinder 10.6L diesel emissions meet 2027 EPA, CA requirements

Green Car Congress

DECEMBER 18, 2020

opposed-piston heavy-duty diesel engine has achieved performance results that comply with pending 2027 requirements of the US Environmental Protection Agency (EPA) and California to reduce sharply emissions of nitrogen oxides (NO x ). liter engine. Achates Power’s innovative 3-cylinder, 10.6L Rendering of the 10.6-liter

EPA

EPA Diesel Emissions San Diego

MAN Engines showcasing D3876 diesel engine for EU Stage V locomotives without exhaust after-treatment systems

Green Car Congress

SEPTEMBER 20, 2018

At InnoTrans 2018, the International Trade Fair for Transport Technology, MAN Engines is exhibiting the D3876 LE63x for locomotives, which produces 471 kW (632 hp) at 1,800 rpm. This means that a single technical solution equally covers emission requirements for all currently recognised emissions threshold values up to EU Stage V.

Exhaust

Exhaust Engine Diesel 2016

Mercedes-AMG entry-level SL 43 features electric exhaust gas turbocharger from Formula 1 for the first time in production vehicle

Green Car Congress

APRIL 7, 2022

Following two variants with V8 engines, Mercedes-AMG is presenting the entry-level SL 43 version of its newly developed roadster icon. The SL 43 features an M139 in-line two-liter, four-cylinder gasoline engine with an electric exhaust gas turbocharger—used for the first time in a production vehicle.

Exhaust

Exhaust Gas-Electric Mercedes Gas

Rolls-Royce supplying two mtu gas engines for first LNG-hybrid tugboat

Green Car Congress

JANUARY 19, 2021

Rolls-Royce is supplying two mtu 16V 4000 M55RN gas engines to Sembcorp Marine Integrated Yard for the construction of the first liquefied natural gas (LNG)-hybrid powered tug. This is the first LNG-hybrid tug to be powered by mtu gas engines. The new engines are part of Rolls-Royce’s Green and High-Tech program.

Gas

Gas Engine Hybrid Supplies

Cummins B6.7 Performance Series engine now features stop-start capability

Green Car Congress

MAY 5, 2021

This feature also delivers the sociability benefits that contractors are looking for by reducing on-site noise and exhaust emissions. Improving fuel efficiency reduces CO 2 greenhouse gas emissions. The engine system was thoroughly tested to confirm its durability for the rigors of Stop-Start operations. Cummins Inc.

Engine

Engine Exhaust Emissions Fuel

HyMethShip seeks to fuel ship engines with hydrogen from methanol

Green Car Congress

JULY 2, 2022

The EU-funded HyMethShip project developed a system that innovatively combined a membrane reactor, a CO 2 capture system, a storage system for CO 2 and methanol as well as a hydrogen-fueled combustion engine to power ships. The bottom part shows how hydrogen for the engine is obtained from methanol in the reactor (blue arrow).

Hydrogen

Hydrogen Engine Fuel Carbon

Empa and partners exploring DME as fuel with new heavy-duty test engine

Green Car Congress

NOVEMBER 30, 2020

Empa, together with FPT Motorenforschung AG Arbon, Politechnico di Milano, lubricant manufacturer Motorex and other partners, is exporing the use of DME as a fuel for heavy-duty engines. A DME test engine has been in operation on a dynamometer in Empa’s Automotive Powertrains Technologies Laboratory. Image: Empa. —Patrik Soltic.

Engine

Engine Fuel Exhaust Gas-Electric

ORNL team achieves diesel-like efficiency with SI engine

Green Car Congress

APRIL 9, 2021

A team at Oak Ridge National Laboratory (ORNL) has achieved diesel-like efficiency in a single-cylinder spark-ignition (SI) research engine while maintaining compatibility with stoichiometric 3-way catalyst (TWC) systems. A paper on their work is published in the International Journal of Engine Research. Splitter et al.

Diesel

Diesel Engine Gasoline Fuel

Rolls-Royce successfully tests 12-cylinder mtu engine with pure hydrogen

Green Car Congress

JANUARY 17, 2023

Rolls-Royce has conducted successful tests of a 12-cylinder gas variant of the mtu Series 4000 L64 engine running on 100% hydrogen fuel. The tests, carried out by the Power Systems business unit, showed very good characteristics in terms of efficiency, performance, emissions and combustion. We are very pleased with the rapid progress.

Hydrogen

Hydrogen Engine Gas-Electric Installation

WinGD and HHI-EMD extend collaboration to develop sustainable two-stroke engine technology

Green Car Congress

NOVEMBER 6, 2021

Marine engine designer and power system integrator WinGD and engine builder Hyundai Heavy Industries’ Engine Machinery Division (HHI-EMD) will strengthen their collaboration by partnering to develop environmentally sustainable two-stroke engine technology. development. development. Up to 50% reduction of methane slip.

Engine

Engine Exhaust Gas Mariner

WinGD and HSD Engine collaborate to deliver methanol-fueled two-stroke engines

Green Car Congress

SEPTEMBER 5, 2022

Swiss marine power company WinGD and Korean engine builder HSD Engine have initiated a Joint Development Project (JDP) to advance the development of WinGD’s methanol-fueled big-bore engines. Under the JDP, WinGD will oversee combustion and injection research, exhaust aftertreatment requirements and engine concept design.

Engine

Engine Fuel Mariner Diesel

Rolls-Royce Power Systems road map for climate-neutrality; 35% cut by 2030 from 2019; key role of mtu engines

Green Car Congress

JULY 22, 2021

By 2030, the Rolls-Royce business unit is to cut greenhouse gas emissions by 35% compared to its 2019 level through the use of new net zero and zero carbon technologies. The engines are used in a wide variety of applications, for example, in energy supply, commercial shipping, heavy land vehicles, passenger trains and in yachts.

2019

2019 Engine Climate Power

MAN ES reports Tier III exhaust-after-treatment orders for low-speed engines pass 1,000

Green Car Congress

FEBRUARY 15, 2021

MAN Energy Solutions’ Two-Stroke Business has surpassed 1,000 orders for secondary-measure, Tier III-compliant, emission-reduction technology for its portfolio of MAN B&W-branded, low-speed ship engines. MAN SCR system for 2-stroke engines. Currently, almost half of all orders have entered active service. MAN EGR system.

Exhaust

Exhaust Engine Emissions 2019

Yuchai ignites 16L hydrogen engine

Green Car Congress

JULY 3, 2022

The Yuchai YCK16H hydrogen-fueled engine was successfully ignited in Yulin, Guangxi. The engine, with a displacement of 15.93 liters and a maximum horsepower of 560 hp, is the largest hydrogen-fueled engine with the largest displacement and horsepower in China.

Hydrogen

Hydrogen Engine China Carbon

MAN Engines puts first dual-fuel hydrogen-powered engines for workboats into operation

Green Car Congress

JUNE 17, 2022

MAN Engines recently put its first two dual-fuel hydrogen-powered engines for work boats into serial operation. The engines are twelve-cylinder diesel engines of type MAN D2862 LE448, each with an output of 749 kW (1019 hp) at 2100 rpm. —Werner Kübler, Head of Development at MAN Engines. Hydrocat engine room.

Engine

Engine Hydrogen Fuel Powered

BorgWarner Exhaust Heat Recovery System for hybrids can improve fuel economy by up to 8.5%

Green Car Congress

JULY 31, 2018

Developed for hybrid electric vehicles (HEVs) and plug-in hybrid electric vehicles (PHEVs), BorgWarner’s innovative Exhaust Heat Recovery System (EHRS) can improve fuel economy by up to 8.5% and reduce emissions significantly. —Joe Fadool, President and General Manager, BorgWarner Emissions & Thermal Systems.

Fuel Economy

Fuel Economy Exhaust Economy Hybrid

Swiss team finds particle emissions from aircraft turbine engines at ground-idle induce oxidative stress in bronchial cells

Green Car Congress

MAY 17, 2019

In a study on the effect of exhaust particles from aircraft turbine engines on human lung cells, Swiss researchers have found that cells reacted most strongly to particles emitted during ground idling. Turbine engine in the testing facility (not running). Image: University of Bern /SR Technics Switzerland AG.

Engine

Engine Emissions Switzerland Gasoline

UK researchers report that alcohols in windshield washer fluid are major unreported source of VOCs emissions from cars, including EVs

Green Car Congress

JUNE 8, 2023

In a recent open-access paper published in ACS’ Environmental Science & Technology , researchers from the University of York report that alcohols in windshield washer fluid account for a larger fraction of real-world vehicle emissions than previous estimates have suggested. Cliff et al. —Cliff et al.

Emissions

Emissions Exhaust Cars Ozone

Japan, China researchers develop plasma-assisted MnO2 filter that produces zero-NO2, -SO2 diesel exhaust

Green Car Congress

MARCH 8, 2019

This research, published in the journal Separation and Purification Technology , shows that ozone can be used to remove not only SO x but also NO x from fossil fuel combustion exhaust streams. In this study, to improve absorption performance of SO 2 and NO 2 , we added ozone in exhaust gas. 2018.12.077. 2018.12.077.

Exhaust

Exhaust Ozone Japan Diesel

Volkswagen 2.0 TDI diesel for Euro 6d; SCR twin-dosing

Green Car Congress

DECEMBER 15, 2020

Volkswagen continues to refine its most important diesel engine, the 2.0-liter With SCR twin dosing technology in the exhaust gas system, the diesel unit now undercuts the Euro 6d emission standard limits while also running quietly and smoothly, according to the company. As previously, the 2.0

Diesel

Diesel Exhaust Convert Emissions

Researchers capture first images of CO2 emissions from commercial aircraft engine using chemical species tomography

Green Car Congress

SEPTEMBER 30, 2022

Researchers have used a novel near-infrared light imaging technique to capture the first cross-sectional images of carbon dioxide in the exhaust plume of a commercial jet engine. To image such a large area, the researchers used a 7m-diameter optical mounting frame (red) located just 3 m from the exit nozzle of the engine.

Commercial

Commercial Engine Emissions CO2

EPFL team develops on-board system to capture CO2 from trucks; reducing emissions by 90%

Green Car Congress

DECEMBER 26, 2019

Researchers at EPFL have patented a new concept that could cut trucks’ CO 2 emissions by almost 90%. The EPFL system captures CO 2 directly in the trucks’ exhaust system and liquefies it in a box on the vehicle’s roof. First, the vehicle’s flue gases in the exhaust pipe are cooled down and the water is separated from the gases.

Emissions

Emissions CO2 Exhaust Carbon

Hyundai Motor Group unveils CVVD engine technology; +4% performance, +5% fuel economy, -12% emissions

Green Car Congress

JULY 3, 2019

T-GDi—the first engine to feature the technology. CVVD optimizes both engine performance and fuel efficiency while reducing emissions. The technology cuts emissions by 12%. T-GDi engine. T-GDi Engine, a four-cylinder gasoline turbo unit with 180 horsepower and 27.0 Smartstream G1.6

Fuel Economy

Fuel Economy Hyundai Engine Emissions

SJTU team investigating ammonia HCCI combustion in free piston engine

Green Car Congress

FEBRUARY 13, 2023

Researchers at Shanghai Jiao Tong University are investigating ammonia-fueled HCCI combustion in a free piston engine. Ammonia is a promising carbon–neutral fuel, able to power heavy-duty vehicles, non-road machineries and ocean ships with zero CO 2 emission. 2023.127634

Engine

Engine Exhaust Emissions Fuel

ClearFlame Engine Technologies secures $17M in Series A financing

Green Car Congress

OCTOBER 29, 2021

ClearFlame Engine Technologies , a startup developing net-zero engine technology ( earlier post ), has secured $17 million in Series A financing, which will enable commercialization of the company’s innovative engine technology for the long-haul trucking, agriculture and power generation sectors.

Financing

Financing Engine Iowa Diesel

HEI launches two new non-tailpipe particulate emission studies

Green Car Congress

JANUARY 8, 2023

The Health Effects Institute (HEI) has launched two new studies funded under RFA 21-1, Quantifying Real-World Impacts of Non-Tailpipe Particulate Matter Emissions. The new studies are: Improved Characterization of the Real-World Contributions and Impacts of Non-tailpipe Particulate Matter Emissions ,” led by Greg Evans, University of Toronto.

Emissions

Emissions Pollution Exhaust London

Achates near-zero heavy-duty opposed-piston diesel enters fleet service; compliant with 2027 NOx levels

Green Car Congress

APRIL 7, 2022

liter, heavy-duty opposed-piston, three-cylinder diesel engine it developed in a project funded by the California Air Resources Board (CARB) and several partners ( earlier post ) has entered fleet service with WALMART Corporation in a Peterbilt 579 tractor. liter engine. Achates Power announced that the 10.6-liter,

Diesel

Diesel Fleet Peterbilt Eaton

Vitesco Technologies wins major order for electric heating elements for diesel catalytic converters in 48V MHEVs

Green Car Congress

MARCH 15, 2020

The capability to heat up the catalytic converter rapidly at all times increases the overall efficiency of exhaust-gas aftertreatment. The EMICAT e-catalyst developed by Vitesco Technologies ensures effective exhaust gas aftertreatment, even when the exhaust gas is actually too cold for this purpose.

Convert

Convert Diesel Exhaust Gas-Electric

VW’s 1.0 TSI in the new up! GTI wins International Engine of the Year 2018 award in its category; Euro 6d-TEMP

Green Car Congress

JUNE 6, 2018

GTI1 has been named International Engine of the Year 2018 in its category. The 85 kW / 115 PS gasoline-fired engine is the first of its kind to be combined with a four-way catalytic converter and installed in the up! GTI—available since spring this year—is the latest addition to the EA211 range of engines.

2018

2018 Engine International Exhaust

MAN D3876 engine ensures high thrust and future-proofing in PistenBully 800; engine basis for possible H2 variant

Green Car Congress

APRIL 19, 2023

MAN Engines is now equipping the PistenBully 800 from Kässbohrer Geländefahrzeug AG with its MAN D3876 engine. The basis for the delivery of the in-line six-cylinder engine was the further development and adaptation of the MAN D3876 to the extreme working environment of the new high-performance snow groomer from Laupheim.

Engine

Engine Future Exhaust Diesel

ClearFlame Engine Technologies completes on-road demo of Class 8 truck with Cummins X15 running E98 ethanol

Green Car Congress

FEBRUARY 10, 2022

ClearFlame Engine Technologies, a a startup developing net-zero engine technology ( earlier post ), successfully completed an on-road demonstration of its proprietary technology that enables a heavy-duty truck diesel engine to operate on low-carbon and carbon-negative fuels, including 100% renewable plant-based fuels.

Engine

Engine Diesel Exhaust Fuel

International automotive researchers emphasize the importance of continued development of the internal combustion engine

Green Car Congress

OCTOBER 9, 2019

Thirty-seven globally prominent scientists representing the International Journal of Engine Research have published an open-access editorial addressing the future of the Internal Combustion Engine, and stressing the importance for continued development of more efficient and even lower-emitting technologies. —Reitz et al.

International

International Engine Exhaust Emissions

New exhaust catalyst features thermal durability and high reactivity at low operating temperatures

Green Car Congress

MARCH 26, 2019

Catalytic converters have been used in the US since the 1970s as a way to clean up pollutants from vehicle exhaust. As cars have become more fuel-efficient, however, they use less energy and the temperature of the exhaust gases is lower, which makes it harder to clean up the pollutants. —Yong Wang.

Exhaust

Exhaust Pollution Convert Universal

Volkswagen adds third tank to Polo and Golf natural gas models; new TGI engine for Golf

Green Car Congress

FEBRUARY 1, 2019

three-cylinder engine (66 kW / 90 PS) the additional tank carries 16.5 liter four-cylinder engine, which is powerful, efficiency and environmentally friendly. kg natural gas over 100 kilometers, and CO 2 emissions of just 98–95 g/km. 1, to increase efficiency and decrease CO 2 emissions. On the Polo with 1.0

Gas

Gas Engine Gasoline Exhaust

Korean team develops 2L-class direct-injection hydrogen-fueled engine

Green Car Congress

SEPTEMBER 8, 2023

The joint research team of KIMM and HMC injected hydrogen directly into the combustion chamber of the engine of an existing HMC hybrid vehicle, with a pressure of more than 30 bar.

Hydrogen

Hydrogen Engine Fuel Carbon

Hydrogen Opposed Piston Engine Working Group formed

Green Car Congress

MAY 26, 2022

Several organizations, encompassing companies, research labs, and academia, have formed the Hydrogen Opposed Piston Engine Working Group. The Working Group consists of members undertaking research and development in the field of hydrogen combustion in an opposed-piston engine. The only criteria emission of concern is NO x.

Hydrogen

Hydrogen Engine Saudi Arabia Universal

Purem by Eberspaecher introduces efficient exhaust technology for hydrogen engines

New Emissions Analytics study suggests pollution from tire wear now 1,850 times worse than exhaust emissions

Webinars

Trending Sources

SwRI engineers develop near-zero emissions diesel engine technology; 90% reduction of NOx

Webinars

Exhaust and aftertreatment on the Achates ULNOx heavy-duty opposed-piston diesel

Optimized heavy-duty CI engine fueled with DME delivers diesel performance, significantly reduces engine-out emissions

ClearFlame Engine Technologies partners with Alto Ingredients to demo ethanol-fueled MCCI in heavy-duty diesels; high efficiency, low emissions

Mercedes-AMG, Garrett developing 48V electric exhaust gas turbocharger

UK expert group focuses attention on non-exhaust emissions from road traffic as regulatory concern

Achates opposed-piston 3-cylinder 10.6L diesel emissions meet 2027 EPA, CA requirements

MAN Engines showcasing D3876 diesel engine for EU Stage V locomotives without exhaust after-treatment systems

Mercedes-AMG entry-level SL 43 features electric exhaust gas turbocharger from Formula 1 for the first time in production vehicle

Rolls-Royce supplying two mtu gas engines for first LNG-hybrid tugboat

Cummins B6.7 Performance Series engine now features stop-start capability

HyMethShip seeks to fuel ship engines with hydrogen from methanol

Empa and partners exploring DME as fuel with new heavy-duty test engine

ORNL team achieves diesel-like efficiency with SI engine

Rolls-Royce successfully tests 12-cylinder mtu engine with pure hydrogen

WinGD and HHI-EMD extend collaboration to develop sustainable two-stroke engine technology

WinGD and HSD Engine collaborate to deliver methanol-fueled two-stroke engines

Rolls-Royce Power Systems road map for climate-neutrality; 35% cut by 2030 from 2019; key role of mtu engines

MAN ES reports Tier III exhaust-after-treatment orders for low-speed engines pass 1,000

Yuchai ignites 16L hydrogen engine

MAN Engines puts first dual-fuel hydrogen-powered engines for workboats into operation

BorgWarner Exhaust Heat Recovery System for hybrids can improve fuel economy by up to 8.5%

Swiss team finds particle emissions from aircraft turbine engines at ground-idle induce oxidative stress in bronchial cells

UK researchers report that alcohols in windshield washer fluid are major unreported source of VOCs emissions from cars, including EVs

Japan, China researchers develop plasma-assisted MnO2 filter that produces zero-NO2, -SO2 diesel exhaust

Volkswagen 2.0 TDI diesel for Euro 6d; SCR twin-dosing

Researchers capture first images of CO2 emissions from commercial aircraft engine using chemical species tomography

EPFL team develops on-board system to capture CO2 from trucks; reducing emissions by 90%

Hyundai Motor Group unveils CVVD engine technology; +4% performance, +5% fuel economy, -12% emissions

SJTU team investigating ammonia HCCI combustion in free piston engine

ClearFlame Engine Technologies secures $17M in Series A financing

HEI launches two new non-tailpipe particulate emission studies

Achates near-zero heavy-duty opposed-piston diesel enters fleet service; compliant with 2027 NOx levels

Vitesco Technologies wins major order for electric heating elements for diesel catalytic converters in 48V MHEVs

VW’s 1.0 TSI in the new up! GTI wins International Engine of the Year 2018 award in its category; Euro 6d-TEMP

MAN D3876 engine ensures high thrust and future-proofing in PistenBully 800; engine basis for possible H2 variant

ClearFlame Engine Technologies completes on-road demo of Class 8 truck with Cummins X15 running E98 ethanol

International automotive researchers emphasize the importance of continued development of the internal combustion engine

New exhaust catalyst features thermal durability and high reactivity at low operating temperatures

Volkswagen adds third tank to Polo and Golf natural gas models; new TGI engine for Golf

Korean team develops 2L-class direct-injection hydrogen-fueled engine

Hydrogen Opposed Piston Engine Working Group formed

Stay Connected