Green Car Congress

SEPTEMBER 22, 2022

Power delivery and torque build-up occur very spontaneously and without delay: as in Formula 1, the electric support of the exhaust gas turbocharger eliminates the turbo lag of the combustion engine, while at the same time the electric drive pushes powerfully from a standstill. liter engine with electrically assisted exhaust gas turbocharger.

Mercedes 259

Mercedes Hybrid Engine All-Electric 259

Green Car Congress

OCTOBER 21, 2016

From the end of 2016, diesel variants of the Renault Scénic and Grand Scénic models will be equipped with Continental’s 48-volt hybrid drive—the first application of the 48V “Hybrid Assist” in production vehicles. The first production solution combines an efficient, water-cooled induction motor with an integrated inverter.

Diesel 150

Diesel Hybrid Volt Production 150

Green Car Congress

OCTOBER 30, 2020

liter) V-8, three-speed automatic, fuel system and exhaust. Power is supplied by a 400-volt Bolt EV battery pack with 60 kWh of usable energy installed in the cargo area. Wiring harnesses, controllers and water pumps for battery heating and cooling. 200-horsepower electric motor.

Chevrolet 221

Chevrolet Convert DC Installation 221

Green Car Congress

APRIL 11, 2019

For the first time, Audi has combined an electric-powered compressor (EPC) with a 48-volt primary electrical system. The pairing of an electric compressor with a 48-volt primary electrical system takes the three-liter V6 TDI’s total power output to 257 kW (349 hp). 48-volt mild-hybrid system. With dual supercharging—i.e.,

Audi 150

Audi Diesel Exhaust MPH 150

Green Car Congress

JUNE 2, 2017

For the four-cylinder engines they are based on the familiar 12-volt electrical system. The six-cylinder and eight-cylinder engines, as well as the W12 cylinder units, will receive a new 48-volt system generally serving as the main vehicle electric system. 48-volt vehicle electrical system. Earlier post.) TFSI engine.

Hybrid 150

Hybrid Volt Audi Lithium Ion 150

Green Car Congress

JUNE 5, 2017

The cylinder heads have two-part water jackets for needs-based cooling. To optimize the air flow and the fuel mixture preparation, the intake ports (one each for swirl and the other for charging) and the exhaust ports have been modified relative to the predecessor engine. Both ports have lower flow resistance. The further developed 3.0

Diesel 186

Diesel Hybrid Audi Exhaust 186

Green Car Congress

APRIL 27, 2017

The new 'Coasting - Engine off' micro hybrid system represents a low-cost level of electric-powered motoring on a 12-volt basis. This new Volkswagen system adds a compact lithium-ion battery to the 12-volt vehicle electrics, with the battery supplying the electric consumer units with power when coasting. Coasting - Engine off.

Gas 207

Gas Engine Motor Motors 207

Green Car Congress

APRIL 17, 2019

Both systems are embedded in the standard 48-volt main electrical system. For the first time in the S5 TDI, a powerful 48–volt belt alternator starter is the heart of the mild hybrid system with maximum recuperation power of up to 8 kW. A DC/DC converter steps this voltage down for components in the 12–volt electrical system.

Audi 247

Audi Diesel Volt Connect 247

Plug in America

MARCH 1, 2024

She asked why their car didn’t have exhaust coming out of a pipe like everyone else’s did. Now, Jazmin’s daughter covers her face when she walks around gas cars so she doesn’t breathe in the exhaust. Written by Amanda Goebel – During daily pick-up and drop-offs at her daughter’s elementary school in Phoenix, Arizona, Jazmin L.’s

Phoenix 40

Phoenix Gas Power Powered 40

Green Car Congress

SEPTEMBER 12, 2018

The Mercedes-Benz GLE 450 4MATIC as the first gasoline model is powered by a six-cylinder engine systematically electrified with 48-volt technology (combined fuel consumption: 9.6 – 8.3 The slim design, together with the physical separation of intake/exhaust, creates space for near-engine exhaust aftertreatment.

Mercedes 220

Mercedes Plug-in 2019 Exhaust 220

Green Car Congress

APRIL 19, 2017

Technologies such as the 48-volt Integrated Starter Alternator and the electric booster compressor celebrate their world première in the lineup as well. The in-line six-cylinder gasoline engine (M 256) in the powertrain range incorporates a 48-volt on-board power supply. 48V system.

Mercedes 170

Mercedes PHEV Hybrid MPG 170

Green Car Congress

AUGUST 19, 2019

For the first time on a Mercedes-Benz vehicle, the combustion engine is started by the electric motor—the compact hybrids do not have a separate 12-volt starter. The high-voltage battery is water-cooled and weighs approximately 150 kg. The electric machine achieves 75 kW. Together with the 1.33-liter

Plug-in 317

Plug-in Mercedes Plug Hybrid 317

Green Car Congress

OCTOBER 26, 2017

Technologies such as the EQ-Boost starter-Generator, 48 volt on-board electrical system and a gasoline particulate filter (GPF) contribute to enhanced environmental compatibility. The engine’s special features include twin-scroll turbochargers, belt-driven 48 V starter-alternator (EQ Boost) and electric 48 V water pump.

Engine 150

Engine Mercedes Gasoline-Electric MPG 150

Green Car Congress

FEBRUARY 16, 2016

Seven years ago we defined a challenging durability cycle for a water-cooled electric machine operating in the harsh under-bonnet environment, combining the most damaging events experienced by both a starter motor and an alternator at 12V. SpeedTorq is a 20,000 rpm SRM designed for low voltage (.

Industrial 150

Industrial Industry Hybrid Volt 150

Green Car Congress

MARCH 3, 2020

For the first time on a Mercedes-Benz vehicle, the combustion engine is started by the electric motor—the compact hybrids do not have a separate 12-volt starter. The high-voltage battery is water-cooled and weighs approximately 150 kg. The electric machine achieves 75 kW. Together with the 1.33-liter

Mercedes 259

Mercedes Power Powered PHEV 259

Drive Electric

SEPTEMBER 19, 2022

Because EVs run on electricity, the vehicle emits no exhaust from a tailpipe and does not contain the typical liquid fuel components in ICEVs. Plug-in and fully electric cars operate between 200 and 800 volts. Water is no problem when it comes to EVs. What happens if water does get into the battery. THE BOTTOM LINE.

Gas-Electric 98

Gas-Electric Electric Vehicles Gas Power 98

Green Car Congress

OCTOBER 8, 2015

Having better control over the combustion process reduces the emission load on the exhaust aftertreatment systems. Eminox SCRT technology can significantly reduce harmful diesel exhaust gases, particularly in urban operating conditions. —Andy Dickinson. Earlier post.)

Vehicles 150

Vehicles Exhaust Emissions Diesel 150

Green Car Congress

JANUARY 25, 2011

The high voltage energy flow from and to the battery or E-motor is managed by the power electronics, which operates at 220 Volts. The XL1’s body electrical system is supplied with the necessary 12 Volts through a DC/DC converter. Equipped in this way, the 0.8 TDI already fulfils the limits of the Euro-6 emissions standard.

Qatar 334

Qatar PHEV MPG Motor 334

Green Car Congress

FEBRUARY 18, 2014

Sixty volts is defined by the United Nations Economic Commission for Europe (UNECE) regulation R100 as the boundary between low and high voltage in a direct current circuit, and so is a critical point where a step change in system cost can be identified. Rick Quinn, senior manager for advanced engineering. Technical Paper 2014-04-01.

Congress 236

Congress Hybrid Exhaust Gas-Electric 236

Green Car Congress

JULY 7, 2014

liter turbocharged gasoline engine has a combination water-cooled cylinder head, integrated exhaust manifold and twin-scroll turbocharger. To minimize turbo lag, the four-into-two exhaust manifold system pairs cylinders according to their expansion or compression stroke to reduce pumping losses and eliminate exhaust gas interference.

North America 210

North America Lexus America Fuel Economy 210

Green Car Congress

FEBRUARY 21, 2013

Operating at 220 volts, the power electronics manage the flow of high voltage energy from and to the battery or E-motor and converts direct current to alternating current. The body electrical system of the XL1 is supplied with the necessary 12 Volts via a DC/DC converter and a small auxiliary battery. Equipped in this way, the 0.8

Plug-in 382

Plug-in MPG Diesel Plug 382

Revenge of the Electric Car

FEBRUARY 26, 2010

“They can dip their toe in the water without making a big commitment of a purchase.&# ‘ Here’s the full text of the article, in case the link goes bad: [link]. “They can dip their toe in the water without. The Roadster is charged not with gas but with a 240-volt house plug which. consumers. .

Auto 162

Auto Tesla Gasoline-Electric Porsche 162

Green Car Congress

SEPTEMBER 15, 2009

On both drivetrains there is exhaust gas recirculation, an oxidation catalytic converter and a diesel particulate filter. Its external water pump is controlled by engine management so that cooling is only activated while engine operating conditions require it. This thermal management also contributes to reduced fuel consumption.

Diesel 296

Diesel Concept Design Hybrid 296

Green Car Congress

JANUARY 13, 2014

All-new aluminum cylinder heads feature water-cooled integrated exhaust manifolds. Intake and exhaust variable cam timing that improves torque while helping lower emissions. Other new features of the 2.7-liter Variable displacement oil pump reduces internal engine friction to improve fuel economy.

F-150 329

F-150 Ford Engine Fuel Economy 329

Green Car Congress

NOVEMBER 2, 2015

Its heart is the exhaust manifold integrated into the cylinder head. It quickly warms up the engine following a cold start, and at high load the water jacket reduces the temperature of the exhaust gas. kWh battery pack ranges between 280 and 390 volts, depending upon level of charge. Battery pack. The voltage of the 8.8

Audi 150

Audi Plug-in Plug Hybrid 150

DIY Electric Car

MARCH 3, 2012

No engine, no fuel tank, no alternator, pumps, radiators, exhaust pipes, or muffler. The air conditioning evaporator is now able to be converted to my cold water heat exchanger. Motor volts, amps, temperature will be showed on 2 inch round dials in the place of oil temp, 12V battery voltage, and fuel level.

Conversion 100

Conversion 2012 Deep Cycle Lead Acid 100

Green Car Congress

JUNE 24, 2013

The ceramic brakes make a sound similar to sliding out on gravel, or swooshing through water. kWh lithium-ion battery—integrated in the front section of the XL1—supplies the electric motor with 220 volts of electrical energy. The mechanical water pump actively cools the engine only when operating conditions require it.

Plug-in 324

Plug-in Diesel Plug Hybrid 324

Clean Fleet Report

MAY 13, 2021

Without being exhaustive, let’s take a look at some examples. Good examples of all-new electric cars are the Nissan Leaf battery-electric and the Chevrolet Volt plug-in hybrid , which both debuted in 2010 as 2011 models. GM, shifting focus to pure EVs, built the last Volt on February 19, 2019. I’m looking primarily at the U.S.

Market 70

Market Motorcycles Saturn Prius 70

Green Car Congress

SEPTEMBER 19, 2011

Maximum motor drive voltage is 650 volts DC. Key components include an electric water pump that requires no belts, and an exhaust gas recirculation (EGR) system that helps warm the engine quickly, reducing fuel consumption when the engine is cold. It also does not include any animal-based material. Connectivity.

Prius 255

Prius MPG Sale Toyota 255

Green Car Congress

SEPTEMBER 1, 2021

The basis for the high performance of the AMG 400 volt battery is the innovative direct cooling: for the first time, a high-tech coolant based on an electrically non-conductive liquid flows around all 560 cells and cools them individually. When the combustion engine starts, the selected setting influences the sound of the exhaust system.

Mercedes 221

Mercedes Hybrid Production MPH 221

Charged EVs

AUGUST 4, 2023

High-voltage DC current is more dangerous and harder to interrupt than the comparatively sedate 48 volts used in smaller vehicles. I’m on the SAE Truck and Bus Electrical Systems Committee, and I know we are trying to write 48-volt standards now. When will they need to go higher than 1,000 volts? Geoff Schwartz: Yes.

Standards 72

Standards Market Volt Vehicles 72

Green Car Congress

JULY 17, 2014

The electric biturbo system comprises a classic exhaust turbocharger (mono- or bi-turbo) working together with a supplemental, electric-powered compressor arranged in series and powered by a separate 48-volt electrical system. Note the position of the single exhaust gas turbocharger and the electrically driven compressor.

Audi 338

Audi Volt Exhaust Production 338

Green Car Congress

SEPTEMBER 10, 2009

The lithium-ion battery pack is also linked via a DC-DC converter to the 12-volt on-board network, which provides power to standard consumers such as the headlamps and various comfort devices. To ensure a consistently high level of electrical efficiency, the voltage transformers are water-cooled via an additional low-temperature circuit.

Plug-in 210

Plug-in Mercedes Plug Hybrid 210

Green Car Congress

NOVEMBER 17, 2015

The current 12-volt electrical system and, above all, the new 48-volt system offer many ways of making driving even sportier, more comfortable and more efficient. mi) on a single tank, with nothing more than a few drops of water leaving the tailpipe. Audi Q7 e-tron 3.0 TDI quattro plug-in hybrid. lb-ft) of system torque.

Audi 150

Audi PHEV Diesel Fuel 150

Green Car Congress

NOVEMBER 20, 2014

The protons migrate through the membrane to the cathode, where they react with the oxygen present in air to form water vapor. The entire fuel cell operates in the voltage range of 230 to 360 volts. Because the exhaust system only has to handle water vapor, it is made of weight-saving plastic.

Audi 278

Audi Hydrogen Fuel Concept 278

Green Car Congress

JULY 20, 2015

The cylinder head has a water-cooled exhaust manifold integrated within the aluminum casting. Improved durability results from eliminating the need for gasket sealing around the exhaust ports, as well as offering under-hood packaging advantages. Piston-cooling oil jets that minimize piston temperatures. Four-wheel disc brakes.

Buick 150

Buick 2016 Oil Exhaust 150

Green Car Congress

FEBRUARY 12, 2016

Making 103 horsepower, the new engine marks the first combination of the Atkinson Cycle, cooled exhaust gas recirculation (EGR), GDI and a long-stroke-narrow-bore specification to maximize efficiency. Also adding to the equation is a new electric water pump and a new electric oil pump, which help improve overall fuel economy.

Hybrid 150

Hybrid Chicago Plug-in Kia 150