Green Car Congress

SEPTEMBER 11, 2013

Tenneco and Gentherm (formerly BSST/Amerigon) are part of a US Department of Energy (DOE) consortium actively developing a thermoelectric generator (TEG) for capturing waste exhaust heat in vehicles and converting it to electrical energy to be used to power electrical systems within the vehicle.

Fuel Economy 218

Fuel Economy Waste Economy Fuel 218

Green Car Congress

OCTOBER 8, 2021

Excess heat and pressure from the exhaust gas are recaptured by the turbo-compound unit. The Volvo integrated driveline then uses extreme downspeeding to maintain road speed at lower RPM, saving even more fuel. Additionally, Tyson Foods made the D13TC-powered Volvo VNL 740 the preferred tractor in its nationwide fleet.

Volvo 243

Volvo Engine Fuel Economy Economy 243

Green Car Congress

MARCH 25, 2015

Using technology from the 2016 Chevrolet Volt propulsion system ( earlier post ), Malibu Hybrid will offer an estimated combined fuel economy rating exceeding 45 mpg (5.22 4-cylinder engine mated to a two-motor drive unit slightly modified from the 2016 Chevrolet Volt drive unit powers the Malibu Hybrid. Engine and Drive Unit.

Fuel Economy 150

Fuel Economy Malibu Hybrid MPG Volt 150

Green Car Congress

JUNE 23, 2014

At the US Department of Energy’s (DOE’s) Annual Merit Review meeting in Washington, DC last week, Michael Ruth from Cummins noted that the DOE program target for the project is a fuel economy (CAFE) target of 26 mpg (9.05 Lightweight steel pistons provide reduced friction & compression height with increased power density.

Fuel Economy 357

Fuel Economy Economy Gasoline Downsizing 357

Green Car Congress

FEBRUARY 20, 2012

A recent, independent, third-party test of a Thomas Built Buses Saf-T-Liner C2 against an IC Bus™ CE Series found that the SCR technology in the Thomas Bus delivers 7-27% better fuel economy than the EGR technology in the IC bus and, when factoring in the cost of diesel exhaust fluid (DEF), is the more cost-effective choice.

Fuel Economy 210

Fuel Economy Economy Fuel Exhaust 210

Green Car Congress

MARCH 19, 2018

Volkswagen has developed and deployed a gasoline engine that offers diesel-like fuel economy but is significantly cheaper to buy. TSI ACT BlueMotion delivers 96 kW / 130 PS with combined fuel consumption of 4.8 This enables further reduced fuel consumption and emission levels plus powerful torque even at low engine speeds.

Fuel Economy 257

Fuel Economy Gasoline Engine Economy 257

Green Car Congress

APRIL 1, 2013

In addition to highway fuel economy estimates that are 2 mpg higher than a 2013 Ford V8 pickup equipped with a 5.0L 2WD Pickup truck fuel economy comparisons. In addition to highway fuel economy estimates that are 2 mpg higher than a 2013 Ford V8 pickup equipped with a 5.0L Fuel economy.

Sierra 262

Sierra Fuel Economy Economy F-150 262

Green Car Congress

MARCH 9, 2020

Power management company Eaton has expanded its portfolio of valvetrain solutions for diesel off-highway vehicles to help OEMs reduce emissions and improve fuel economy. Eaton’s new technology allows for cost-effective, variable valve actuation with hydraulic lash adjustment (HLA) function.

Eaton 269

Eaton Fuel Economy CO2 Vehicles 269

Green Car Congress

MARCH 31, 2014

Hybrid Electric Turbocharger for Exhaust Energy Recovery and Transient Lag Reduction. of Rockledge, Florida is developing a hybrid electric turbocharger for cars and trucks that both reduces fuel consumption and improves drivability by shortening the transient response time (reducing turbo lag) during acceleration. Lead organization.

Exhaust 261

Exhaust Wind 2014 Motor 261

Green Car Congress

MAY 31, 2017

A joint study by Controlled Power Technologies (CPT) and Austria’s Technische Universität Wien (TU Wien) into 48V diesel mild hybrid technology verified a 9% reduction of NO x in raw engine-out emissions, while retaining the fuel economy and CO 2 benefits of diesel engine technology.

Fuel Economy 150

Fuel Economy Diesel Economy Engine 150

Green Car Congress

OCTOBER 19, 2022

Debuting a more powerful hybrid system and available Electronic On-Demand All-Wheel Drive, the 2023 Corolla Hybrid also gains new safety and multimedia systems, updated styling and new paint colors. The new Corolla SE Hybrid grades (FWD and AWD) inherit the Gas SE’s sport suspension and the firmer-feel Electronic Power Steering.

Hybrid 459

Hybrid Toyota Fuel Economy Economy 459

Green Car Congress

OCTOBER 8, 2019

Ram Truck announced EPA fuel economy ratings for the 2020 Ram 1500 powered by the new 3.0-liter Ram 1500’s unsurpassed 29 mpg highway fuel economy rating for 4x4 models is significant in that 4x4 models represent more than 80% of the U.S. Redesigned intake ports to improve engine performance and fuel economy.

MPG 223

MPG 2020 EPA Fuel Economy 223

Green Car Congress

DECEMBER 29, 2011

Designed to be the most fuel-efficient Chrysler flagship sedan yet, the new 2012 Chrysler 300 Luxury Series combines an eight-speed automatic transmission with the 292 hp (218 kW) 3.6-liter Best-in-class V-6 AWD fuel economy (18 mpg city, 27 mpg highway / 13.0 Leading city fuel economy (19 city mpg RWD, 18 mpg AWD / 12.4

Fuel Economy 236

Fuel Economy Chrysler Economy MPG 236

Green Car Congress

MARCH 25, 2015

Also included is the special factory-installed aerodynamic package introduced last year with longer 76-inch sleeper side extenders, lower cab fairing extenders, front air dam, aerodynamic mud flaps, rear fairing without steps coupled with an air deflector, exhaust cut out covers, and optional wheel covers for drive tires.

Fuel Economy 150

Fuel Economy Kenworth Economy Fuel 150

Green Car Congress

APRIL 20, 2011

fed by multipoint fuel injection (MPI)— and 123 lb-ft (167 N·m) of torque with a 30 mpg city and 40 mpg highway fuel economy rating. The 2012 Accent’s highway fuel economy of 40 mpg is an 18% improvement over its predecessor’s 34 mpg highway manual transmission fuel economy rating.

Fuel Economy 236

Fuel Economy MPG Economy 2012 236

Green Car Congress

MAY 3, 2013

The new engine delivers a manufacturer-estimated improvement in fuel efficiency for the Beetle models of between 4-8% percent on the combined cycle and by up to 9% percent on the city cycle. Peak power is generated 200 revs higher in the engine range, at 5300 rpm, and torque remains unchanged at 207 lb-ft (280 N·m).

Fuel Economy 284

Fuel Economy Engine Fuel Economy 284

Green Car Congress

SEPTEMBER 4, 2013

The project aims to deliver full hybrid equivalent fuel economy and performance with less than 70 g/km CO 2 emissions as measured over the European Drive Cycle, but at a significantly lower cost. version of its vehicle (a 2009 Ford Focus) but with fuel economy and CO 2 emissions approaching those of a Prius.

Fuel Economy 239

Fuel Economy Diesel Economy Gasoline 239

The Truth About Cars

APRIL 26, 2024

Techron Complete Fuel System Cleaner will help to prevent deposits from forming, it cleans and protects your fuel system, it optimizes performance, and perhaps most importantly, it maximizes fuel economy.

Cleaner 111

Cleaner Fuel Chevron Fuel Economy 111

Green Car Congress

JULY 23, 2014

Enerpulse Technologies said that it has further identified the underlying mechanism by which its its pulsed energy ignition technology improves fuel economy, reduces emission and delivers higher torque in spark ignited (SI) internal combustion (IC) engines. Earlier post.)

Fuel Economy 210

Fuel Economy Plug Economy Energy 210

Green Car Congress

NOVEMBER 1, 2014

Diesel vehicle manufacturers are striving for greater engine performance and fuel economy while meeting Euro 6 emissions standards under a myriad of driving conditions. For gasoline vehicles, direct injection (GDI) engines are growing in popularity as drivers demand more fuel efficiency and engine power.

Germany 210

Germany Exhaust Light Fuel Economy 210

Green Car Congress

NOVEMBER 13, 2019

Jeep will offer a diesel-powered Wrangler for the first time in North America with the introduction of the 2020 Jeep Wrangler EcoDiesel. There are more than 40 individual shift maps to optimize shift points for fuel economy, performance and 4x4 capability. Wrangler four-door models will offer the new 3.0-liter

Jeep 191

Jeep 2020 Diesel America 191

Green Car Congress

SEPTEMBER 2, 2015

Depending on the application, the redesigned V-6 delivers fuel-economy improvements of more than 6% while increasing torque more than 14.9%. The system is designed to remain mostly in low-lift mode until the customer demands more power; then it responds by switching to high-lift mode for improved combustion. Click to enlarge.

Fuel Economy 150

Fuel Economy Economy Fuel 2016 150

Green Car Congress

OCTOBER 19, 2021

Both intake and exhaust camshafts feature continuously variable valve timing, and the exhaust camshaft further adds variable valve lift and duration through the use of two distinct camshaft lobe profiles. At high engine speeds, the flap closes, and maximum power can be achieved. 1 for the Golf R and 9.6:1 1 for the GTI.

Engine 397

Engine Exhaust Hungary MPG 397

Green Car Congress

NOVEMBER 16, 2017

Federal-Mogul Powertrain has completed the acquisition of UK-based Controlled Power Technologies Ltd (CPT). The new unit will offer its solutions under the name “Federal-Mogul Controlled Power Ltd”. Earlier post.). Earlier post.). Financial details of the acquisition have not been released.

Power 150

Power Powered Fuel Economy Exhaust 150

Green Car Congress

MARCH 26, 2015

The Cummins team not only surpassed all fuel-economy targets, but also achieved criteria emissions lower than the stringent Tier 2/Bin 2 levels. Test cycle fuel economy (mpg). The Highway Fuel Economy Test (HFET) and FTP-75 Test (city) cycles demonstrated fuel economy above 35 mpg (6.72

Fuel Economy 150

Fuel Economy Economy Diesel Light 150

Green Car Congress

AUGUST 19, 2012

Dennis Assanis at the University of Michigan suggests that accessing the “thermodynamic sweet spot” in high-efficiency, dilute, boosted gasoline engines has the potential for vehicle fuel economy gains between 23% and 58%. Their paper is published in the International Journal of Engine Research. —Lavoie et al.

Fuel Economy 236

Fuel Economy Gasoline Economy Engine 236

Green Car Congress

SEPTEMBER 1, 2012

liter engine and next-generation Xtronic CVT with sub-planetary gear, offers combined fuel economy of 34 mpg (6.9 The lighter and more aerodynamic new Sentra allows Nissan to use the more fuel-efficient 1.8-liter Fuel economy is rated at 30 mpg (7.84 2013 Nissan Sentra. Click to enlarge. L/100km) on the highway.

Fuel Economy 231

Fuel Economy MPG 2013 Economy 231

Green Car Congress

JANUARY 5, 2015

Drive cycle fuel economy for PFI, CDC, and multi-mode RCCI operation. Among their findings were that multi-mode RCCI has the potential to offer greater than 15% fuel economy improvement over a 2009 gasoline PFI baseline over many light-duty driving cycles, despite the lack of complete drive cycle coverage for RCCI mode.

Fuel Economy 150

Fuel Economy Economy Light Fuel 150

Green Car Congress

APRIL 25, 2016

In a paper presented at the 2016 SAE World Congress, Tula Technology, developer of Dynamic Skip Fire (DSF) cylinder deactivation technology, reported significant fuel economy gains of up to 18% over a conventional GM 6.2-liter Meaning, DSF reduces fuel consumption by 14-18% over V8. liter V8 by operating using Dynamic Skip Fire.

Fuel Economy 150

Fuel Economy Economy GM GMC 150

Green Car Congress

FEBRUARY 13, 2015

For improved fuel efficiency, the 2016 Pilot will also include a stop start feature—Honda’s first non-hybrid application of this technology. Honda VCM deactivates the cylinder by using its VTEC (Variable Valve Timing and Lift Electronic Control) technology to keep the intake and exhaust valves in the closed position to halt fuel supply.

Fuel Economy 150

Fuel Economy Honda 2016 Economy 150

Green Car Congress

MARCH 26, 2018

liter Dynamic-Force direct-injection inline four-cylinder engine (M20A-FKS) ( earlier post ) with gains in power, fuel efficiency, and cleaner emissions. Together, the valve timing systems enhance power output and fuel economy, and cut harmful emissions. The all-new TNGA-based powertrain features the 2.0-liter

2019 261

2019 Engine Power Powered 261

Green Car Congress

AUGUST 22, 2013

The European Union-funded PowerDriver project—a two-year, €3-million (US$4-million) research project initiated in February 2012 to turn exhaust gas waste heat into electricity using thermoelectric generator (TGEN) technology—has completed simulation work on on a potential automotive application.

Exhaust 210

Exhaust Waste Land Rover Fuel 210

Green Car Congress

OCTOBER 15, 2010

A one-way clutch, which allows for smoother 1-2 and 2-1 shifts, faster downshifts and improved fuel economy, has been added. The gear ratios, span and shift schedule have been optimized for better off-the-line performance and improved fuel economy. The double-overdrive gear also provides better fuel economy.

F-150 225

F-150 Fuel Economy 2011 Economy 225

Green Car Congress

APRIL 30, 2018

Shell has partnered with the Airflow Truck Company to collaborate on a hyper-aerodynamic, fuel-efficient Class 8 concept truck: Starship. This next-generation concept truck features a custom, aerodynamic design and aims to demonstrate improvements in fuel economy for Class 8 trucks. and ending in Jacksonville, Fla.

San Diego 281

San Diego Fuel Jacksonville Fuel Economy 281

Green Car Congress

NOVEMBER 1, 2013

The engineers tested a prototype 100cc engine on a dyno to gather steady-state fuel consumption, emissions, and combustion stability data over a matrix of speed, load, mixture ratio, and combustion phasing. Four engine control modes were evaluated with the goal of reducing NO x and minimizing fuel economy impact.

Fuel Economy 231

Fuel Economy Economy Engine Fuel 231

Green Car Congress

SEPTEMBER 23, 2010

Among the changes, the Highlander Hybrid debuts a new, more powerful 3.5-liter liter V6, while also improving fuel economy. The 2011 Highlander Hybrid receives EPA estimated fuel economy ratings of 28 mpg city and 28 mpg highway (8.4 liter V6 for 2011, replacing the previous 3.3-liter Active Safety.

Highlander 186

Highlander Fuel Economy 2011 Economy 186

Green Car Congress

JULY 16, 2020

for XSE grade, which uses a dual-outlet exhaust). Most AWD grades have 202 hp, while the Camry XSE AWD grade has 205 hp with dual exhaust. The Camry’s four-cylinder engine uses a very high compression ratio (13:1) and Toyota’s innovative D-4S fuel injection, which employs both direct injection and additional port injectors.

Toyota 400

Toyota Hybrid Camry Hybrid Exhaust 400