Green Car Congress

DECEMBER 6, 2011

Unlike exhaust-driven turbochargers, electric superchargers are driven by an electric motor. Highly efficient at low engine revolutions, electric superchargers make it possible to downsize engines. version of the vehicle but with fuel economy and CO 2 emissions approaching those of a Prius. Earlier post.). Earlier post.).

Power 326

Power Powered Downsizing Electric 326

Green Car Congress

SEPTEMBER 30, 2014

Automakers are turning to downsized turbocharged engines to satisfy more stringent global fuel economy and emission regulations and customer demand for better-performing vehicles. In addition to improving fuel efficiency, downsized turbocharged engines also reduce harmful exhaust emissions.

2019 261

2019 Global Sale Downsizing 261

Green Car Congress

JUNE 18, 2013

At the company’s 61 st Automotive Press Briefing in Boxberg, Germany, Bosch senior executives outlined the company’s view on the general future of automotive technology—“ efficient and increasingly electrical ”, and provided a thumbnail of the way they see—and thus are developing products for—sector-specific technology trends.

Future 291

Future Gasoline-Electric Vehicles Gasoline 291

Green Car Congress

MAY 14, 2009

Continuing to emphasize a downsizing approach, Volkswagen presented two new engines at the at the 30 th Vienna Engine Symposium (7-8 May): the 1.2-liter liter TDI engine will serve as a basis for all future four-cylinder diesel engines of Volkswagen. The potential of internal combustion engines is far from exhausted.

Downsizing 150

Downsizing Engine MPG Exhaust 150

Green Car Congress

OCTOBER 10, 2012

The analysis used the Ohio State University EcoCAR, a student prototype PHEV, as the basis for the preliminary fuel economy evaluation. This evolution has led to the point where achieving significant fuel savings through the introduction of new technologies has become difficult. Exhaust gas exergy map of EcoCAR engine.

Waste 312

Waste PHEV Fuel Exhaust 312

Green Car Congress

MARCH 6, 2012

This combination of efficiency and dynamic performance is enabled by the systematic interplay of ACT, downsizing (reduced engine displacement plus direct injection and charging) and BlueMotion Technology (Stop/Start system, battery regeneration). TSI of the Polo BlueGT, an exhaust camshaft adjuster is added. Earlier post.)

MPG 257

MPG Fuel Economy Gasoline Engine 257

Green Car Congress

JULY 30, 2009

The work of the consortium will be structured into a series of modules, the first of which will focus on the effect of downsized light duty gasoline and diesel engine technologies on lubricant soot levels and engine wear. The drive towards thinner, lower viscosity lubricants for reduced friction.

Engine 150

Engine Future Downsizing Carbon 150

Green Car Congress

FEBRUARY 22, 2018

The found that using a GPF did not show any fuel economy and CO 2 emission penalties, while the emissions of total hydrocarbons (THC), carbon monoxide (CO), and nitrogen oxides (NOx) were generally reduced. liter downsized turbocharged centrally-mounted direct injection engine. Yang et al. Click to enlarge.

Gasoline 253

Gasoline Emissions Engine Fuel Economy 253

Green Car Congress

FEBRUARY 5, 2020

In this report, MECA provides our assessment of technologies being commercialized by component suppliers, including MECA members, to help their customers comply with future lower NO x standards. This has resulted in higher catalyst loading per volume of substrate and led to downsizing of systems from those available in 2010.

Emissions 291

Emissions Diesel Engine 2010 291

Green Car Congress

SEPTEMBER 23, 2014

The new approach to natural gas combustion technology is designed to provide vehicle and engine original manufacturers (OEMs) with a “downsized” natural gas solution that is cost competitive while providing similar levels of power, torque, and fuel economy to a larger diesel engine.

Diesel 259

Diesel Gas Fuel Economy Power 259

Green Car Congress

AUGUST 10, 2009

First of all, future passenger vehicles have to stay as clean as the best vehicles out there today. Current 50-state baseline Projected future baseline. Many improvements in fleet fuel economy in Europe have been achieved through increased diesel market share, with the diesel market share in Europe now above 50%.

Gasoline 150

Gasoline Diesel Engine Emissions 150

Green Car Congress

FEBRUARY 26, 2018

Shift responsiveness has improved through downsizing of the pulley and reduction of inertia by 40%. It also achieves greater thermal efficiency, resulting in high output, due to a reduction in energy loss associated with exhaust and cooling systems, the movement of mechanical parts, and other aspects.

Toyota 264

Toyota Engine Hybrid Gasoline-Electric 264

Green Car Congress

SEPTEMBER 29, 2011

The higher-voltage variant will support moves by European vehicle manufacturers announced earlier this year to introduce 48 volt passenger vehicle power networks to help meet the requirement for lower fuel consumption and CO 2 emissions. —Guy Morris, CPT’s engineering director and chief technical officer. Micro-mild hybrids.

Volt 207

Volt Hybrid Downsizing Lead Acid 207

Green Car Congress

DECEMBER 9, 2016

By rightsizing engines with available technologies, automakers are able to continue applying the benefits of smaller turbocharged engines while fine-tuning powertrain systems to further optimize fuel economy, emissions and performance. Regional highlights include: In North America, more engine downsizing is expected.

Global 150

Global Sale Transportation Vehicles 150

Green Car Congress

OCTOBER 16, 2013

Homogeneous GDI provides fuel efficiency benefits from charge air cooling, more facile turbocharging, and the downsizing that these permit. Schematic diagram of test vehicle engine & exhaust system and PM sampling systems. Fuel injectors were side-mounted. The vehicles were fueled with an E10 ethanol?gasoline

Standards 246

Standards Emissions Miles Engine 246

Green Car Congress

JUNE 28, 2010

Southwest Research Institute (SwRI) has successfully demonstrated that its HEDGE (High-Efficiency, Dilute Gasoline Engine) technology, using cooled exhaust gas recirculation (EGR) and advanced ignition systems, suppresses low-speed pre-ignition in turbocharged gasoline direct-injection engines. Earlier post.).

Engine 186

Engine Fuel Economy Gasoline Emissions 186

Green Car Congress

SEPTEMBER 15, 2016

An enhanced version of Volvo’s I-See, a new feature that memorizes thousands of routes traveled and uses that knowledge to optimize cruise speed and keep the I-shift automated manual transmission in the most fuel-efficient gear possible, was an integral part of the fuel efficiency gains seen during SuperTruck on-road testing.

Volvo 150

Volvo Fuel North America Waste 150

Green Car Congress

JUNE 7, 2010

Renault’s ongoing downsizing strategy is aimed at reducing the cubic capacity of its engines in order to bring down fuel consumption and CO 2 emissions, without detracting from performance. The future 1.6 The downsizing process involved shortening the piston stroke by reducing the size of the crank pin and conrod assembly.

Environment 230

Environment Engine 2010 Parts 230

Green Car Congress

MAY 6, 2013

Since 2010, all Sprinters in the US have been powered by BlueTEC diesel engines, marking the first use of BlueTEC technology, with its selective catalytic reduction (SCR) exhaust aftertreatment system, in the commercial van market here. The two overhead camshafts actuate 16 intake and exhaust valves.

2014 306

2014 Diesel Standards Exhaust 306

Green Car Congress

MAY 8, 2013

Especially with increased production volume of renewable fuels and optimized powertrain solutions for flexible fuel vehicles, there is a chance for combustion engines to not only remain in the market but also be sustainable for future vehicle. improvement in fuel economy over the baseline. Earlier post.).

Fuel Economy 278

Fuel Economy Economy Fuel Engine 278

Green Car Congress

MARCH 27, 2015

The Freightliner SuperTruck uses a downsized and downsped 10.7-liter The Freightliner SuperTruck features a low-back-pressure, next-generation aftertreatment system that efficiently removes NO x from the exhaust stream. The aftertreatment system features additional insulation to retain maximum heat energy in the exhaust.

2009 150

2009 Engine Detroit Oregon 150

Green Car Congress

MAY 17, 2013

Given these substantial effects of ESR on the net GHG impact of ethanol observed herein, we assert that it is important and feasible to reduce the uncertainties in ESR and to take ESR into account in future stochastic LCAs to capture these potential risks that have been largely overlooked. Future potential for ethanol optimization.

Fuel 210

Fuel Energy Gasoline-Electric Gasoline 210

Green Car Congress

APRIL 14, 2011

Results of this study showed that the pre-chamber jet ignition combustion system roughly matches HCCI fuel economy across both NEDC and FTP drive cycles, with a 13% improvement in fuel economy recorded over the baseline stoichiometric (λ=1) spark ignition combustion system. Click to enlarge. liter) GM engine.

Fuel Economy 210

Fuel Economy Economy Engine Fuel 210

Green Car Congress

SEPTEMBER 16, 2009

Compared to conventional fuel injection, direct injection produces a cooler, denser charge, delivering improved fuel economy and performance. Like in a modern diesel engine, multiple injections are also possible per combustion cycle, which further enhances economy and emissions.

Engine 186

Engine Ford Downsizing United Kingdom 186

Green Car Congress

AUGUST 1, 2016

High-research octane number (RON) fuels are known to enable more efficient, higher-performance SI operation via engine downsizing and boosting. Many biofuel blending components exhibit high RON and can be introduced into the market in the near- to medium-term for engines optimized to operate on those fuels.

Engine 150

Engine Fuel Emissions Pollution 150

Green Car Congress

APRIL 10, 2014

The system, say the researchers, offers the potential to exploit most of the benefits of operating on premium high octane fuel while using less expensive regular grade more effectively. 100 RON product when using regular unleaded (RUL) 92 RON gasoline as the base fuel. increase in fuel economy, according to their work; 8.5%

Gasoline 316

Gasoline Engine Toyota Fuel Economy 316

Green Car Congress

DECEMBER 11, 2009

Power for the battery and VTES electric supercharger is not only supplied by the SpeedStart ISG but also the TIGERS exhaust driven turbo-generator. Small displacement engines offer excellent CO 2 and fuel economy benefits; they have lower parasitic losses and operate more efficiently under part load conditions.

Downsizing 191

Downsizing Power Powered Exhaust 191

Green Car Congress

NOVEMBER 4, 2011

The A dvanced C ombustion C oncepts— E nabling S ystems and S olutions (ACCESS) is developing advanced combustion control concepts along with with an enabling system, subsystem and component level solutions for the management of multi-mode/multi-fuel combustion events. turbocharged direct injected inline 4 (based on the GM Ecotec 2.0L

Fuel Economy 218

Fuel Economy Gasoline Light Engine 218

Green Car Congress

FEBRUARY 20, 2015

In addition to a range of visual upgrades, the new cee’d GT Line features the debut of Kia’s all-new downsized 1.0-liter liter T-GDi is a downsized, three-cylinder power unit engineered to improve fuel consumption and emissions while offering strong performance and immediate response. Kia cee’d GT Line. Click to enlarge.

Kia 150

Kia Downsizing Fuel Economy Cleaner Emissions 150

Green Car Congress

OCTOBER 2, 2014

The unit features a six-hole GDI injector, pressured to a higher-than-average 200 bar, securing a clean combustion and improving fuel economy and emissions to fulfill Euro 6c emission standards, three years ahead of their introduction in 2017. As well as being lighter and smaller, it features greater efficiency and power.

Hyundai 239

Hyundai Downsizing Engine Hybrid 239

Green Car Congress

DECEMBER 10, 2009

A multi-cylinder version is practical for a wide variety of vehicles and offers greatest benefit to C and D class passenger cars which can take advantage of the low cost architecture and significantly improved fuel economy and emissions. Displacement. Compression ratio. Porting arrangement.

Fuel Economy 218

Fuel Economy Engine Light Fuel 218

Green Car Congress

MARCH 20, 2013

Variable valve timing is an established technique for improving the fuel economy of a gasoline engine via several mechanisms. Such downsizing may help offset the low energy density of ethanol, while problems with cold star due to reduced volatility can also be reduced via, for example, advanced DI operating strategies.

Gasoline 225

Gasoline Exhaust Downsizing Engine 225

Green Car Congress

APRIL 10, 2013

Focused on meeting a growing customer demand for ‘downsized’ engines offering strong power with reduced fuel consumption and CO2 emissions, the new gasoline and diesel powertrains are being progressively introduced across the Opel product range. The engine retains the proven concept of a turbine-integrated exhaust manifold.

Engine 287

Engine 2016 Fuel Economy Fuel 287

Green Car Congress

SEPTEMBER 21, 2009

On 15 Sep, NHTSA and the US EPA proposed a joint rulemaking on fuel economy and greenhouse gas emissions for light duty vehicles: an average new car 34.1 mpg if the automotive industry were to meet this CO 2 level just through fuel economy improvements.) ( Earlier post.). mpg and 250 g CO 2 /km for model year 2016.

2016 210

2016 MPG Fuel Economy EPA 210

Green Car Congress

FEBRUARY 1, 2012

Volkswagen says that its MQB strategy represents a turning point in the design and production of its future automobiles with transverse-mounted engines. In the future, all of these models could theoretically be produced on the same assembly line, despite their different wheelbases and track widths. Earlier post. ).

Engine 294

Engine Exhaust Diesel Gasoline-Electric 294

Green Car Congress

SEPTEMBER 11, 2011

On the diesel side—now available solely as BlueTEC units with SCR aftertreatment technology) , the focus is on downsizing and the new version of the V6 CDI engine. The HP turbine is located directly at the exhaust manifold and initially allows exhaust gas to flow through it; it then rotates at up to 215,000 revolutions per minute.

Mercedes 220

Mercedes SUV Fuel Energy 220

Green Car Congress

OCTOBER 8, 2013

Based on these engine studies, they installed a downsized four-cylinder 1.6-liter liter diesel engine adapted with piezoelectric fuel injectors, EGR cooling and two-stage air-boosting system in a demonstration vehicle equipped with an on-board combustion control system.

Gasoline 207

Gasoline Fuel Range Diesel 207