Downsizing, Engine, Gasoline-Electric and Universal

Ricardo to display functional integration prototype of ADEPT 48V “intelligent electrification” diesel

Green Car Congress

SEPTEMBER 9, 2014

Ricardo will display the first functional integration prototype of the Advanced Diesel Electric Powertrain (ADEPT) collaborative research project ( earlier post ) in public for the first time this week at the Low Carbon Vehicle Event (LCV 2014) in the UK. ADEPT schematic. Click to enlarge.

Diesel

Diesel Downsizing Lead Acid Gasoline-Electric

ETH Zürich Developing Pneumatic Hybrid Engine; Approaches Hybrid-Electric Performance at Lower Cost

Green Car Congress

FEBRUARY 1, 2009

Pneumatic hybrid engine on the test bench. Researchers at ETH Zürich are developing a pneumatic hybrid engine—an internal combustion engine connected to a compressed air tank instead of a battery system. If fuel is also injected, the engine responds quickly. The compressed air supply also allows extreme downsizing.

Hybrid

Hybrid Engine Downsizing 2009

ADEPT project to apply gasoline engine HyBoost system to diesel; 48V architecture; full hybrid fuel economy at much lower cost

Green Car Congress

SEPTEMBER 4, 2013

The Ricardo-led Advanced Diesel Electric Powertrain (ADEPT) project will apply 48V “intelligent electrification” concepts, mild hybridization and waste heat recovery in a Ford Focus diesel demonstrator. In 2011, the HyBoost team reported that the HyBoost demonstrator was achieving comparable performance to the conventional 2.0L

Fuel Economy

Fuel Economy Diesel Economy Gasoline

Simulation study suggests ORC waste heat recovery system could deliver potential 7% improvement in fuel consumption in a PHEV on highway

Green Car Congress

OCTOBER 10, 2012

Their paper was presented at the ASME Internal Combustion Engine Division 2012 Fall Technical Conference by Marcello Canova, assistant professor at OSU; lead author was Philipp Skarke, from the University of Stuttgart Institute for Internal Combustion Engines and Automotive Engineering. —Skarke et al.

Waste

Waste PHEV Fuel Exhaust

UK Technology Strategy Board Awards More Than 12M to 22 Projects to Speed Up Development of Low-Carbon Technology for Vehicles; Includes Gas Turbine Range Extender and Li-S Battery Cells

Green Car Congress

JANUARY 22, 2010

We are funding innovative projects in a number of key areas which include internal combustion engine technologies, energy storage and management, lightweight structures and new propulsion technologies. Projects to be funded include: Ultra Lightweight Gas Turbine Range Extender for Electric Vehicles. Title Partners. GKN Eco-Trailer.

Carbon

Carbon Li-ion Downsizing Gas

DOE to award up to $137M for SuperTruck II, Vehicle Technology Office programs

Green Car Congress

AUGUST 16, 2016

will design and develop a new more-efficient engine and advanced drivetrain and vehicle technologies. will design and develop a vehicle and powertrain with electrified engine components that can enable higher engine efficiency and a significantly more aerodynamically reengineered cab. Navistar, Inc. Drive Oregon. 993,450.

Vehicles

Vehicles Plug-in Lithium Ion Universal

Optimizing a CNG-Fueled Spark Injection Engine for a Parallel Hybrid Powertrain

Green Car Congress

APRIL 24, 2010

In recent years two methods, namely downsizing and downspeeding, were established on the market to reduce CO 2 emissions while maintaining the driving performance of engines with identical effective power but a larger displacement. Active-WG control is used for improvements at all engine speeds (< 5500 rpm).

Engine

Engine Hybrid Fuel Exhaust

Researchers propose evaluating alt fuel efficiency based on energy rather than volume; impact of ethanol on vehicle efficiency and GHGs

Green Car Congress

MAY 17, 2013

Relative changes in vehicle energy efficiency (VEE) (km/MJ) on ethanol/gasoline blends over those on gasoline for different blending levels. Several recent highly cited LCAs that have incorporated vehicle efficiency differences between gasoline and ethanol/gasoline blends could potentially be misleading. Click to enlarge.

Fuel

Fuel Energy Gasoline-Electric Gasoline

CPT and Eminox to collaborate on development of retrofit electric supercharging and aftertreatment solutions for heavy-duty vehicles

Green Car Congress

OCTOBER 8, 2015

Essentially, the use of the Cobra supercharger helps reduce engine-out emissions, effectively making Eminox’s task easier. Electric supercharging provides a cost-effective technology for controlling emissions without increasing fuel consumption. Phil Bush, technology manager at Eminox. —Andy Dickinson. Earlier post.)

Vehicles

Vehicles Exhaust Emissions Diesel

Calls for an international 48V electrical standard for vehicles; looming WLTP implementation

Green Car Congress

DECEMBER 1, 2014

At the 2 nd International Conference Automotive 48 V Power Supply Systems , held last week in Düsseldorf, Germany, Controlled Power Technologies (CPT), a major sponsor of the event, together with leading car makers and Tier 1 suppliers, argued the need for an internationally agreed 48V electrical standard.

Standards

Standards International Vehicles Hybrid

Testing confirms Torotrak V-Charge variable drive mechanical supercharger enables more ambitious downsizing; 1.0L demo at Aachen

Green Car Congress

OCTOBER 10, 2016

Independent on-engine test results have verified the simulation predictions that a Torotrak V-Charge variable drive mechanical supercharger enables more ambitious levels of engine downsizing. GTDI engine producing 240 N·m torque, a 1.0L GTDI engine of the same Ford EcoBoost family outperformed the 1.5L

Downsizing

Downsizing Charging Engine Belgium

Promising Delphi 1st-gen Gasoline Direct Injection Compression Ignition engine meeting ultra fuel efficient program targets

Green Car Congress

APRIL 17, 2014

In a presentation at the SAE 2014 High Efficiency IC Engine Symposium and then in a paper given at SAE 2014 World Congress, Mark Sellnau, Engineering Manager, Delphi Advanced Powertrain, reported that Brake Specific Fuel Consumption for the 1.8L Earlier post , earlier post.). Earlier post.) DOE UFEV program targets.

Gasoline

Gasoline Engine Fuel Wisconsin

Update on the ACCESS fuel efficient engine project; simulations find up to 48.9% improvement in fuel economy over baseline

Green Car Congress

MAY 8, 2013

At the recent 2013 SAE World Congress, engineers from Bosch and AVL presented papers on progress in the ACCESS project, describing the design, combustion development and controls development for a resulting 4-cylinder gasoline turbocharged direct injection (GTDI) engine with part-load HCCI capability. I4 Ecotec engine.

Fuel Economy

Fuel Economy Economy Fuel Engine

Ford moving to vehicle testing with advanced 2.3L MiGTDI engine research project; Tier 3 SULEV30 target with 25% fuel economy improvement

Green Car Congress

JUNE 23, 2014

MiGTDI engine. At the US Department of Energy (DOE) Annual Merit Review in Washington, DC last week, Cory Weaver from Ford Research and Advanced Engineering reported that Ford has completed the planned build of 12 units of the new engine, and is working on vehicle integration for further testing per the project timeline.

Fuel Economy

Fuel Economy Economy Ford Engine

Controlled Power Technologies Packages Its Switched Reluctance Systems in ‘RegEnBoost’ System for Enhanced Support for Downsizing

Green Car Congress

DECEMBER 11, 2009

CPT says that the RegEnBoost system enables a typical family-sized car to achieve less than 100 g/km CO 2 with a 1-liter gasoline engine, but when required can offer the same lively performance and in-gear acceleration of a 2-liter naturally aspirated powertrain.

Downsizing

Downsizing Power Powered Exhaust

Lotus Omnivore Engine Shows Up To 10% Better Fuel Economy Than Spray-Guided GDI Engines; Achieves HCCI At Extremely Light Loads

Green Car Congress

DECEMBER 10, 2009

Comparison of fuel consumption of Omnivore, homogeneous Gasoline Direct Injection (GDI) and Spray-Guided GDI engines. The first testing phase of Lotus Engineering’s Omnivore variable compression ratio, flex-fuel direct injection two-stroke engine ( earlier post ) has been successfully completed on gasoline.

Fuel Economy

Fuel Economy Engine Light Fuel

Using the PHEV (Plug-In Hybrid Electric Vehicle) to Transition Society Seamlessly and Profitably From Fossil Fuel to 100% Renewable Energy

Green Car Congress

JULY 17, 2015

The PHEV (Plug-in Hybrid Electric Vehicle), a subset of the electric car, combines a primary electric motor with a much smaller back-up engine fueled with a hydrocarbon/biofuel mix. (In In this paper PHEV refers solely to the long-range PHEV of 60 miles (100 km) electric-only range.) It is much more than that.

PHEV

PHEV Plug-in Renewable Energy

NRC report finds Federal analysis to set LD CAFE and GHG standards generally of high quality; some technologies and issues should be re-examined

Green Car Congress

JUNE 19, 2015

The National Research Council is the principal operating arm of the National Academy of Sciences and the National Academy of Engineering. Michael Sivak of the University of Michigan Transportation Research Institute (UMTRI) examined several topics related to fuel economy and advanced vehicle technologies. gallon and $5/gallon.

Standards

Standards Fuel Economy Economy EPA

EALABC paper outlines approach to 48V hybrid systems with advanced lead-carbon batteries

Green Car Congress

NOVEMBER 19, 2014

Augmenting its existing LC Super Hybrid program ( earlier post ), which deploys a downsized gasoline-electric powertrain, ALABC is working on advanced diesel-electric applications in development programs being undertaken with car makers including Ford and Kia. These compact electrical machines can be rated up to 12.5

Carbon

Carbon Hybrid Batteries Battery

How Carmakers Are Responding to the Plug-In Hybrid Opportunity

Tony Karrer Delicious EVdriven

APRIL 21, 2009

GM has announced plans for public sales in 2010, and almost every carmaker now says it will sell PHEVs or highway-speed battery electric vehicles (BEVs) sometime after 2010. Shifted earlier focus to all-electric Focus in 2011 with Magna. Company says its focusing on gasoline and hydrogen. todays answer is "Yes -- but not yet."

Plug-in

Plug-in Plug Hybrid PHEV

EV Driven

Ricardo to display functional integration prototype of ADEPT 48V “intelligent electrification” diesel

ETH Zürich Developing Pneumatic Hybrid Engine; Approaches Hybrid-Electric Performance at Lower Cost

ADEPT project to apply gasoline engine HyBoost system to diesel; 48V architecture; full hybrid fuel economy at much lower cost

Simulation study suggests ORC waste heat recovery system could deliver potential 7% improvement in fuel consumption in a PHEV on highway

UK Technology Strategy Board Awards More Than 12M to 22 Projects to Speed Up Development of Low-Carbon Technology for Vehicles; Includes Gas Turbine Range Extender and Li-S Battery Cells

DOE to award up to $137M for SuperTruck II, Vehicle Technology Office programs

Optimizing a CNG-Fueled Spark Injection Engine for a Parallel Hybrid Powertrain

Researchers propose evaluating alt fuel efficiency based on energy rather than volume; impact of ethanol on vehicle efficiency and GHGs

CPT and Eminox to collaborate on development of retrofit electric supercharging and aftertreatment solutions for heavy-duty vehicles

Calls for an international 48V electrical standard for vehicles; looming WLTP implementation

Testing confirms Torotrak V-Charge variable drive mechanical supercharger enables more ambitious downsizing; 1.0L demo at Aachen

Promising Delphi 1st-gen Gasoline Direct Injection Compression Ignition engine meeting ultra fuel efficient program targets

Update on the ACCESS fuel efficient engine project; simulations find up to 48.9% improvement in fuel economy over baseline

Ford moving to vehicle testing with advanced 2.3L MiGTDI engine research project; Tier 3 SULEV30 target with 25% fuel economy improvement

Controlled Power Technologies Packages Its Switched Reluctance Systems in ‘RegEnBoost’ System for Enhanced Support for Downsizing

Lotus Omnivore Engine Shows Up To 10% Better Fuel Economy Than Spray-Guided GDI Engines; Achieves HCCI At Extremely Light Loads

Using the PHEV (Plug-In Hybrid Electric Vehicle) to Transition Society Seamlessly and Profitably From Fossil Fuel to 100% Renewable Energy

NRC report finds Federal analysis to set LD CAFE and GHG standards generally of high quality; some technologies and issues should be re-examined

EALABC paper outlines approach to 48V hybrid systems with advanced lead-carbon batteries

How Carmakers Are Responding to the Plug-In Hybrid Opportunity

Stay Connected