Conference, Cost, Downsizing and Gasoline-Electric

HyBoost concept achieving close to Prius-level CO2 emissions; aggressive downsizing with advanced boosting and micro-hybrid system

Green Car Congress

NOVEMBER 1, 2011

version of its vehicle (a 2009 Ford Focus) but with fuel economy and CO 2 emissions approaching those of a Prius, according to David Boggs, Ricardo Technical Specialist, Engines, in a presentation at the recent 2011 Directions in Engine-Efficiency and Emissions Research Conference (DEER) hosted by the Department of Energy in Detroit.

Downsizing

Downsizing Prius Hybrid Emissions

Ricardo HyBoost “Intelligent Electrification” project awarded automotive environmental prize by Institution of Mechanical Engineers

Green Car Congress

OCTOBER 11, 2013

The Automobile Division of the Institution of Mechanical Engineers has awarded its Prize for the Environment to Ricardo, Ford Motor Company, Controlled Power Technologies and Valeo engineers for their paper HyBoost—An Intelligently Electrified Optimized Downsized Gasoline Engine Concept. Earlier post.). Earlier post.)

Engine

Engine Downsizing Lead Acid Automobile

CPT/AVL Study: New Generation of Micro-Hybrid Technologies Can Enable More than 25% Reduction in Fuel Consumption at Lower Cost Than Full Hybrid Drive Systems

Green Car Congress

SEPTEMBER 13, 2010

liter ELC-Hybrid to downsized 1.4L VTES + SpeedStart. The intent is to enable aggressive yet near term downsizing and downspeeding of existing engine families, delivering proven CO reduction and fuel economy improvement, without the usual dynamic compromises that typically limit market acceptance.

VRLA

VRLA Hybrid Downsizing Fuel

AVL Concept Turbohybrid Mild Hybrid System Approaches Full Hybrid Fuel Savings at Lower Cost; Improved Driveability

Green Car Congress

FEBRUARY 4, 2009

Comparison of Fuel Consumption, Fun to Drive and System Cost of the different powertrain concepts. However, the system cost of the Turbohybrid was 150% that of the baseline, while the system cost of the full hybrid was more than 300% that of the baseline. Downsizing a gasoline engine (e.g., Click to enlarge.

Hybrid

Hybrid Concept Downsizing Fuel

Toyota Aims to Reduce Fuel Cell Vehicle Cost to 1/10 of Current By Commercialization in 2015; Reduction to Another 1/10 With Scale

Green Car Congress

OCTOBER 4, 2009

Toyota’s targeted cost reductions in fuel cell vehicles. In a news conference at the Japan National Press Club on Friday, Toyota Motor President Akio Toyoda said that the company plans to begin mass production of electric vehicles in the US in 2012, followed by US production of fuel cell vehicles in 2015. Source: Toyota.

2015

2015 Toyota Commercial Fuel

CPT developing 48-volt electric supercharger for micro-mild hybrids

Green Car Congress

SEPTEMBER 29, 2011

Controlled Power Technologies (CPT) is developing a 48-volt version of its 12 volt electric supercharger based on its variable torque enhancement system known as VTES. At 48 volts, a VTES electric supercharger will transform 7kW of battery power into a highly boosted charge of air for downsized gasoline and diesel engines.

Volt

Volt Hybrid Downsizing Lead Acid

Calls for an international 48V electrical standard for vehicles; looming WLTP implementation

Green Car Congress

DECEMBER 1, 2014

At the 2 nd International Conference Automotive 48 V Power Supply Systems , held last week in Düsseldorf, Germany, Controlled Power Technologies (CPT), a major sponsor of the event, together with leading car makers and Tier 1 suppliers, argued the need for an internationally agreed 48V electrical standard.

Standards

Standards International Vehicles Hybrid

CPT VTES Electric Supercharger Selected for Two Projects

Green Car Congress

SEPTEMBER 22, 2009

Controlled Power Technologies’ VTES (Variable Torque Enhancement System) electric supercharger ( earlier post ) is being incorporated in a project by engine developer AVL ( earlier post ) and will also feature in the Ricardo-led £3 million (US$5-million) HyBoost program announced by the Technology Strategy Board on 9 September ( earlier post ).

Downsizing

Downsizing Electric Electrical Exhaust

Toyota continues prepare the market for fuel cell vehicle in 2015

Green Car Congress

MARCH 11, 2014

The output power is more than 100kW, despite significant unit downsizing. From the perspective of mobility zones based on travel distance, hybrid and plug-in hybrid vehicles can match the everyday usability of a current gasoline car, and become mainstream environmentally friendly vehicles. Toyota’s view of hydrogen. Click to enlarge.

2015

2015 Toyota Fuel Market

Simulation study suggests ORC waste heat recovery system could deliver potential 7% improvement in fuel consumption in a PHEV on highway

Green Car Congress

OCTOBER 10, 2012

Their paper was presented at the ASME Internal Combustion Engine Division 2012 Fall Technical Conference by Marcello Canova, assistant professor at OSU; lead author was Philipp Skarke, from the University of Stuttgart Institute for Internal Combustion Engines and Automotive Engineering. Δ in electric range. Skarke et al.

Waste

Waste PHEV Fuel Exhaust

CPT and Eminox to collaborate on development of retrofit electric supercharging and aftertreatment solutions for heavy-duty vehicles

Green Car Congress

OCTOBER 8, 2015

Electric supercharging provides a cost-effective technology for controlling emissions without increasing fuel consumption. This can be achieved without the cost and complexity of replacing an entire fleet with brand new vehicles before older vehicles have been fully amortized. Phil Bush, technology manager at Eminox.

Vehicles

Vehicles Exhaust Emissions Diesel

EALABC paper outlines approach to 48V hybrid systems with advanced lead-carbon batteries

Green Car Congress

NOVEMBER 19, 2014

The European Advanced Lead-Acid Battery Consortium (EALABC) is delivering a paper this week outlining the consortium’s approach to 48V hybridization at the 2 nd International Conference on Advanced Automotive 48V Power Supply Systems in Düsseldorf. The Valeo electric supercharger was developed in the UK by Controlled Power Technologies.

Carbon

Carbon Hybrid Batteries Battery

Using the PHEV (Plug-In Hybrid Electric Vehicle) to Transition Society Seamlessly and Profitably From Fossil Fuel to 100% Renewable Energy

Green Car Congress

JULY 17, 2015

The PHEV (Plug-in Hybrid Electric Vehicle), a subset of the electric car, combines a primary electric motor with a much smaller back-up engine fueled with a hydrocarbon/biofuel mix. (In In this paper PHEV refers solely to the long-range PHEV of 60 miles (100 km) electric-only range.) It is much more than that.

PHEV

PHEV Plug-in Renewable Energy

How Carmakers Are Responding to the Plug-In Hybrid Opportunity

Tony Karrer Delicious EVdriven

APRIL 21, 2009

GM has announced plans for public sales in 2010, and almost every carmaker now says it will sell PHEVs or highway-speed battery electric vehicles (BEVs) sometime after 2010. Shifted earlier focus to all-electric Focus in 2011 with Magna. Company says its focusing on gasoline and hydrogen. todays answer is "Yes -- but not yet."

Plug-in

Plug-in Plug Hybrid PHEV

EV Driven

HyBoost concept achieving close to Prius-level CO2 emissions; aggressive downsizing with advanced boosting and micro-hybrid system

Ricardo HyBoost “Intelligent Electrification” project awarded automotive environmental prize by Institution of Mechanical Engineers

CPT/AVL Study: New Generation of Micro-Hybrid Technologies Can Enable More than 25% Reduction in Fuel Consumption at Lower Cost Than Full Hybrid Drive Systems

AVL Concept Turbohybrid Mild Hybrid System Approaches Full Hybrid Fuel Savings at Lower Cost; Improved Driveability

Toyota Aims to Reduce Fuel Cell Vehicle Cost to 1/10 of Current By Commercialization in 2015; Reduction to Another 1/10 With Scale

CPT developing 48-volt electric supercharger for micro-mild hybrids

Calls for an international 48V electrical standard for vehicles; looming WLTP implementation

CPT VTES Electric Supercharger Selected for Two Projects

Toyota continues prepare the market for fuel cell vehicle in 2015

Simulation study suggests ORC waste heat recovery system could deliver potential 7% improvement in fuel consumption in a PHEV on highway

CPT and Eminox to collaborate on development of retrofit electric supercharging and aftertreatment solutions for heavy-duty vehicles

EALABC paper outlines approach to 48V hybrid systems with advanced lead-carbon batteries

Using the PHEV (Plug-In Hybrid Electric Vehicle) to Transition Society Seamlessly and Profitably From Fossil Fuel to 100% Renewable Energy

How Carmakers Are Responding to the Plug-In Hybrid Opportunity

Stay Connected