Green Car Congress

DECEMBER 17, 2019

Advanced Carbon Fiber for Compressed Hydrogen and Natural Gas Storage Tanks. This potential area, coordinated with AMO and the Vehicle Technologies Office (VTO), would focus on R&D to reduce the cost of hydrogen and natural gas storage tanks through development of low-cost, high-strength carbon fiber (CF).

Market 195

Market Carbon Fiber Hydrogen Mariner 195

Green Car Congress

OCTOBER 31, 2013

Most of the hydrogen that is used today is stored as a compressed gas (with pressures typically ranging from 150 to 700 bar) or a liquid (liquid storage requires cryogenic temperatures near 20 K). 350 to 700 bar) storage vessels are constructed using expensive high-strength carbon fiber. DOE targets for hydrogen storage.

Carbon Fiber 218

Carbon Fiber Hydrogen 2017 Carbon 218

Green Car Congress

DECEMBER 12, 2011

DOE’s Pacific Northwest National Laboratory, in collaboration with Ford Motor Company, Lincoln Composites, Toray Carbon Fibers America, Inc. The project will focus on improving carbon fiber composite materials and the design and manufacture of hydrogen storage tanks. and AOC Inc.,

Hydrogen 330

Hydrogen Carbon Fiber Oregon Alabama 330

Green Car Congress

DECEMBER 2, 2009

Lite concept. Lite concept at the LA Auto Show. The new concept, based on Volkswagen’s New Small Family (the Up! models), incorporates a variation on the two-cylinder TDI hybrid powertrain from the L1 concept unveiled earlier this year at the Frankfurt Motor Show. Lite concept features a weight-optimized mix of metals.

MPG 265

MPG Concept Diesel Hybrid 265

Green Car Congress

FEBRUARY 28, 2023

—Oliver Zipse, Chairman of the Board of Management of BMW AG The BMW iX5 Hydrogen developed on the basis of the current BMW X5 was first unveiled as a concept at the IAA show in 2019. The pressure plate forms a gas-tight and water-tight seal around the stack housing. Earlier post.)

BMW 259

BMW Hydrogen Fleet Lithium Ion 259

Green Car Congress

JANUARY 13, 2016

In a demonstration of its ongoing development of advanced alternative powertrains, Audi unveiled the new h-tron quattro fuel cell concept vehicle at the North American International Auto Show (NAIAS). The Audi h-tron quattro concept combines an Audi fifth-generation fuel cell stack delivering up to 110 kW with a power-optimized 1.8

Audi 150

Audi Concept Detroit Fuel 150

Green Car Congress

MARCH 6, 2012

Toyota Motor Corporation (TMC) unveiled the FT-Bh (Future Toyota B-segment Hybrid), a lightweight, next-generation small gasoline-electric hybrid concept car at the 82nd Geneva International Motor Show. This concept shows what can be done when every aspect of the car is designed to reduce emissions.

Plug-in 317

Plug-in Hybrid Toyota MPG 317

Teslarati

OCTOBER 19, 2022

And in 2021, the company debuted the iX5 Hydrogen fuel cell concept car at the International Motor Show in Germany. Zipse, for his part, highlighted that the ability to supply fuel cells from carbon-fiber-reinforced plastic tanks gives hydrogen a significant advantage over electric power , which requires a vast charging network.

BMW 93

BMW Hydrogen Electric Cars Carbon Fiber 93

Green Car Congress

NOVEMBER 15, 2021

MAZDA SPIRIT RACING Bio concept DEMIO. It also plans to enter the ST-Q class of the Super Taikyu Race in Okayama in its MAZDA SPIRIT RACING Bio concept DEMIO vehicle, which is equipped with a 1.5-liter Challenge 2: Matters related to the allowable pressure of metal tanks limit the amount of hydrogen that can be filled per tank.

Mazda 387

Mazda Hydrogen Toyota Transportation 387

Green Car Congress

APRIL 4, 2019

Development of the components in the new powertrain was accompanied by concepts for eventual recycling. Savings of more than 50% are possible compared to the scenario with hydrogen from natural gas and the EU power mix. Two carbon-fiber encased tanks in the vehicle floor of the GLC F-CELL hold 4.4

Hydrogen 274

Hydrogen Mercedes Power Powered 274

Green Car Congress

AUGUST 26, 2016

The new DOE funding opportunity announcement ( DE-FOA-0001622 ) focuses on the second of these pathways which is focused on securing applications for projects that will develop CO 2 -utilization technologies that produce useful products at lower cost than currently available technologies, without generating additional greenhouse gas emissions.

Convert 150

Convert Production Coal CO2 150

Green Car Congress

SEPTEMBER 18, 2015

Eight projects are aimed at improvements including developing and demonstrating dual-fuel or dedicated natural gas engine technologies for high-efficiency medium and heavy-duty vehicles to reduce petroleum usage and developing advanced computational fluid dynamics models to accelerate the development of advanced engine technologies.

Fuel 150

Fuel Carbon Fiber Lithium Ion Vehicles 150

Green Car Congress

AUGUST 10, 2011

This project will develop a novel low cost route to carbon fiber using a lignin/PAN hybrid precursor and carbon fiber conversion technologies leading to high performance, low-cost carbon fiber. Plasan Carbon Composites. . $6,000,000. Zoltek Companies, Inc. Grantee Description. Amerigon Incorporated.

Carbon Fiber 268

Carbon Fiber Lithium Ion Li-ion Vehicles 268

Teslarati

FEBRUARY 1, 2023

Fitted with carbon fiber body panels, the tried and true aerodynamics of Porsche’s fastest racecars, and a stripped interior, it is the real deal and has the performance to back it up. Second, the drivetrain, likely using a dual or tri-motor system , produces similarly insane power as its gas counterparts.

Porsche 101

Porsche Sweden Carbon Fiber North America 101

DIY Electric Car

JULY 11, 2017

Instead of being dependent on gas, cars make use of electricity that can power your vehicle. And with its carbon fiber body, it has an excellent power-to-weight ratio. And the good thing about this car is that there is no gas needed to operate this elite car. Rimac Concept One. Why make electric cars? Renovo Coupe.

Electric Cars 140

Electric Cars Cars Electric Electrical 140

Green Car Congress

SEPTEMBER 16, 2010

Materials Innovation Technologies will develop low cost carbon fiber composite manufacturing technology to address the need for cost-effective, high volume production, lighter-weight components for automobiles and other vehicles by designing, manufacturing and testing several target components. DOE Funding: $3,000,000.

Fuel 210

Fuel Energy Carbon Fiber Polymer 210

Green Car Congress

JUNE 29, 2018

Natural gas-fired engine inside the combined heat and power station at BMW Group Plant Dingolfing. At this automotive think tank, specialists from different divisions are working together to develop innovative, mixed-material concepts and production procedures for future vehicle generations. BMW Group Plant Landshut.

Grid 191

Grid BMW Power Powered 191

Green Car Congress

JANUARY 22, 2015

Topics addressed include: advanced batteries (including manufacturing processes) and electric drive R&D; Lightweight materials; Advanced combustion engine and enabling technologies R&D; and Fuels technologies (dedicated or dual-fuel natural gas engine technologies). Applications must present a sound business case for the proposed technology.

Fuel 150

Fuel Hydrogen Vehicles Carbon Fiber 150

Green Car Congress

DECEMBER 20, 2013

VTO supports a broad technology portfolio aimed at developing and deploying advanced highway transportation technologies to reduce petroleum consumption and greenhouse gas emissions, while meeting or exceeding vehicle performance and cost expectations. high octane fuels), and advanced powertrain work.

Vehicles 246

Vehicles Fuel Economy Carbon Fiber Plug-in 246

Green Car Congress

DECEMBER 16, 2010

Such engines may incorporate novel thermodynamic cycles, but should not simply involve regurgitation of existing concepts (e.g., The objective of this AOI is to accelerate the realization of lighter weight vehicle materials made from magnesium and carbon fiber capable of attaining 50% weight reduction of passenger vehicles.

Li-ion 231

Li-ion Carbon Fiber Vehicles Low Cost 231

Green Car Congress

MAY 16, 2013

Porsche had unveiled the concept version of the 918 Spyder Plug-in Hybrid at the Geneva Motor Show in 2010. The 918 Spyder features a novel all-wheel drive concept with a combination of a 608 hp (453 kW) V8 combustion engine, 115 kW electric motor on the rear axle and ~95 kW electric motor on the front axle. Earlier post.)

Porsche 259

Porsche Plug-in Hybrid Plug 259

Green Car Congress

NOVEMBER 20, 2014

The concept car has high-voltage 1.1 Two of the total of four carbon fiber composite hydrogen tanks are housed under the rear seat and the other two in the luggage compartment floor. The key drive components of the Golf SportWagen HyMotion were developed by Volkswagen Group Research in Germany. Click to enlarge.

Hydrogen 259

Hydrogen Fuel Hybrid Li-ion 259

Green Car Congress

SEPTEMBER 13, 2011

With inner surfaces of up to 10,000 m 2 per gram—the current status of research—MOFs are attractive for numerous applications: they are suitable as gas cleaners for fuel cells, for example, and also, as envisaged for the F125!, as a storage medium for gases.

Mercedes 334

Mercedes Hydrogen Plug-in Plug 334

Green Car Congress

MAY 12, 2015

Hydrogen stations are being built in these areas from industrial gas suppliers such as Linde, Air Products, Air Liquide, Iwatani and other companies such as H2 Logic, First Element and Hydrogen Frontiers are working to create these stations. He also showed Honda’s power generation concept also using renewable energy. Earlier post.).

Congress 150

Congress Commercial Fuel Hydrogen 150

Green Car Congress

JULY 10, 2010

Phase III applications are sought, to further develop and specifically demonstrate a promising system concept for bio-fueled SOFCs in distributed generation applications, with potential commercial viability. Office of Electricity Delivery and Energy Reliability.

Fuel 210

Fuel Motor Motors Motoring 210

Green Car Congress

JANUARY 4, 2020

Department of Energy (DOE) selected 16 projects to receive nearly $25 million in federal funding for cost-shared projects to advance natural gas infrastructure technology development. AOI 2: Process-Intensified Technologies for the Upcycling of Flare Gas into Transportable, Value-Added Products.

Gas 186

Gas Gas-Electric West Virginia Carbon Fiber 186

Green Car Congress

SEPTEMBER 30, 2010

Jaguar has unveiled the C-X75 concept, an extended range electric vehicle that uses twin gas micro-turbines from Bladon Jets to power two switched reluctance generators from SR Drives. The driver and passenger are seated ahead of a sealed airbox that houses the micro gas-turbines. Click to enlarge. Earlier post.) C-X75 airflow.

Extended Range 371

Extended Range Gas-Electric Gas Electric Vehicles 371

Green Car Congress

DECEMBER 11, 2015

These storage methods also have potential synergies in advanced natural gas storage, such as liquid natural gas (LNG) storage, and these methods may be applicable for hydrogen delivery and early market applications (e.g., fleets, buses, etc.) as well, and not solely for light‐duty vehicles. The Ultimate Full Fleet targets are 2.5

Hydrogen 150

Hydrogen Fuel Climate Production 150

Green Car Congress

JUNE 10, 2015

The intelligent body concept uses this mixed-materials approach to increase the strength and rigidity of the passenger cell while at the same time significantly reducing vehicle weight. 7 Series body-in-white / carbon. The innovative insulation concept has the additional effect of further improving acoustic comfort.

BMW 150

BMW Plug-in Plug Hybrid 150

Green Car Congress

MARCH 19, 2011

The goal of research carried out under this topic is to reduce the cost of 350 to 700 bar compressed gas storage vessels by at least 50% from the current high volume projections of $15.4/kWh An example of a possible solution is using fibers with mechanical strengths matching or exceeding the properties of aerospace quality carbon fiber (e.g.

Hydrogen 210

Hydrogen Carbon Fiber Low Cost Carbon 210

Green Car Congress

NOVEMBER 20, 2014

This is the opposite of the approach taken by Toyota with its Mirai fuel cell vehicle ( earlier post ) and Honda with its new FCV Concept ( earlier post ). The h-tron concept car shows that we have also mastered fuel cell technology. An outer skin made from carbon fiber reinforced polymer (CFRP) encases the inner aluminum shell.

Audi 278

Audi Hydrogen Fuel Concept 278

Green Car Congress

NOVEMBER 17, 2015

TDI quattro plug-in hybrid ( earlier post ); the Audi A7 h-tron quattro fuel cell vehicle ( earlier post ); the Audi e-tron quattro concept battery-electric SUV ( earlier post ); the Audi TT clubsport turbo concept ( earlier post ); the Audi RS 5 TDI competition concept ( earlier post ); and the Audi R18 e-tron quattro ( earlier post ).

Audi 150

Audi PHEV Diesel Fuel 150

Green Car Congress

OCTOBER 20, 2014

The passenger compartment consists of carbon fiber-reinforced plastic, while aluminum is used in the front, rear and room frame. In addition, the engineers have developed a security concept that consistently incorporates forward-looking analysis of the traffic. Click to enlarge. weighs only 450 kg (992 lbs).

Miles 236

Miles Range Carbon Fiber Batteries 236

Green Car Congress

MARCH 1, 2016

Techrules, a new China-based automotive R&D company, made its global debut at the 2016 Geneva International Motor Show with the unveiling of a Turbine-Recharging Electric Vehicle (TREV) series hybrid system applied in a 6-motor, all-wheel drive supercar concept. The two concepts. The battery powers the motors that drive the wheels.

Range 150

Range Companies China Carbon Fiber 150

Green Car Congress

FEBRUARY 15, 2022

Argonne National Laboratory seeks to disrupt the steel industry by developing a potentially zero-carbon ironmaking process that eliminates the use of coke or natural gas and requires less energy than current processes. A Zero-emission Process for Direct Reduction of Iron by Hydrogen Plasma in a Rotary Kiln Reactor - $1,200,000.

Clean 284

Clean Cleaning Energy Li-ion 284

Green Car Congress

AUGUST 27, 2020

The proposed approach combines decades of knowledge in gas turbine engines with novel advances in additive manufacturing research and sCO 2 power generation experience to increase the overall power system efficiency and its power density. The system can operate with any carbon neutral liquid fuel to achieve net-zero GHG emissions.

Carbon 218

Carbon Hybrid Electric Electrical 218

Green Car Congress

AUGUST 14, 2014

Integrated Computational Materials Engineering (ICME) Development of Carbon Fiber Composites for Lightweight Vehicles (Area of Interest 2). This project will develop, integrate and implement predictive models for Carbon-Fiber Reinforced Polymer composites that link the material design, molding process and final performance.

Plug-in 299

Plug-in Li-ion Plug Vehicles 299