Green Car Congress

APRIL 14, 2011

GM is exploring the use of an ultracapacitor-based Active Energy Recovery Buffer (AERB) scheme as a low-cost means to improve fuel economy in conventional vehicles; results of a simulation study presented at SAE 2011 World Congress showed improvement of up to 1.3% liter engine and a six-speed transmission.

Fuel Economy 240

Fuel Economy Low Cost Economy GM 240

Green Car Congress

FEBRUARY 24, 2011

Source: Barnitt 2011. On a drive cycle representing routes with frequent stops and accelerations, the gHEV trucks exhibited a 20% improvement in fuel economy. On drive cycles representing routes with fewer stops and accelerations, the gHEV trucks demonstrated similar fuel economy to the diesels. Click to enlarge.

Fuel Economy 186

Fuel Economy Economy Gasoline Diesel 186

Green Car Congress

SEPTEMBER 4, 2013

The project aims to deliver full hybrid equivalent fuel economy and performance with less than 70 g/km CO 2 emissions as measured over the European Drive Cycle, but at a significantly lower cost. In 2011, the HyBoost team reported that the HyBoost demonstrator was achieving comparable performance to the conventional 2.0L

Fuel Economy 239

Fuel Economy Diesel Economy Gasoline 239

Green Car Congress

DECEMBER 22, 2022

Tire rolling resistance is closely related to overall vehicle fuel economy or range in both ICE and electric vehicles (EVs). Currently, it is understood that rolling resistance reduction is a reliable strategy for optimizing a vehicle’s fuel economy or cruising range. —Henry He.

Fuel Economy 210

Fuel Economy Economy China Range 210

Green Car Congress

AUGUST 2, 2011

A European-based Vauxhall Vivaro van retrofitted with Protean Electric’s electric wheel motors ( earlier post )applied in a through-the-road plug-in hybrid system (TTRH) has shown a more than three-fold improvement in fuel economy in hybrid mode over a conventional Vivaro on the New European Driving Cycle (NEDC).

Fuel Economy 220

Fuel Economy Plug-in Economy Plug 220

Green Car Congress

OCTOBER 1, 2010

The US Department of Transportation’s (DOT) National Highway Traffic Safety Administration (NHTSA) and the US Environmental Protection Agency (EPA) issued a Notice of Intent (NOI) to begin developing new standards for greenhouse gases and fuel economy for light-duty vehicles for the 2017-2025 model years. Earlier post.). Technologies.

Fuel Economy 199

Fuel Economy EPA 2017 Economy 199

Green Car Congress

APRIL 16, 2010

will introduce a new Prius minivan equipped with Li-ion batteries early next year—the first of a coming rollout of hybrids equipped with Li-ion packs. A hybrid vehicle that Toyota plans to introduce around 2015 will also offer a choice between the two batteries. The Nikkei reports that Toyota Motor Corp.

Minivan 239

Minivan Lithium Ion Nickel Metal Hydride Prius 239

Green Car Congress

MARCH 31, 2010

The 2011 Lincoln MKZ Hybrid. Ford’s Lincoln brand revealed its first hybrid—the new mid-size 2011 Lincoln MKZ Hybrid—during the press preview to the New York International Auto Show. The 2011 Lincoln MKZ Hybrid uses Ford’s second-generation hybrid system, based on the 2.5-liter Adds engine output power and battery output power.

2011 170

2011 HS 250h MPG Hybrid 170

Green Car Congress

OCTOBER 26, 2010

Ford Motor Company plans to invest an additional $850 million in Michigan between 2011 and 2013 as part of the company’s commitment to competitively grow its engineering and manufacturing employee base, upgrade its facilities in the state and further improve its vehicle fuel economy. facility by 2012. facility by 2012.

Michigan 186

Michigan 2013 2011 Ford 186

Green Car Congress

MARCH 4, 2013

Axion Power International, Inc, the developer of advanced lead-carbon PbC batteries and energy storage systems ( earlier post ), has entered a strategic relationship with ePower Engine Systems LLC. The first truck to be outfitted with a PbC battery string has been completed and is now on the road going through its final test procedures.

Diesel 231

Diesel Peterbilt Fuel Economy Lead Acid 231

Green Car Congress

OCTOBER 21, 2013

PowerGenix, the developer of nickel-zinc (NiZn) rechargeable batteries ( earlier post ), has signed a product evaluation contract with HELLA, a Tier 1 supplier to major automotive manufacturers worldwide. In 2011, PowerGenix delivered its first production prototype product for the micro-hybrid stop-start market. Marc Nalbach of HELLA.

Nickel Cadmium 230

Nickel Cadmium NiCd Hybrid Nickel Metal Hydride 230

Green Car Congress

APRIL 7, 2015

12V Li-Start battery. Li-ion battery developer and manufacturer A123 Systems has introduced the third generation of its 12 Volt Starter Battery in its Li-Start product line. Every component of this third-generation battery system has been optimized for low voltage automotive applications. Batteries' Product Specs.

Li-ion 150

Li-ion Lead Acid Batteries Battery 150

Green Car Congress

JULY 19, 2010

liter EcoBoost I-4 engine ( earlier post ) version of the 2011 Ford Explorer SUV, achieving at least a 30% increase in fuel efficiency with comparable power compared with the current V-6-powered Explorer. Overall vehicle weight in the 2011 Explorer is reduced compared to the previous model. Ford will offer a 2.0-liter

2011 210

2011 Ford SUV Engine 210

Green Car Congress

AUGUST 25, 2011

ALTe has signed a long-term supply agreement with A123 Systems for complete lithium-ion battery packs to be integrated into ALTe’s range-extended hybrid electric powertrain systems. The packs will be matched with a four-cylinder engine, electric motors and proprietary controls modules to increase fuel economy by up to 200%.

Lithium Ion 218

Lithium Ion Supplies Fuel Economy Batteries 218

Green Car Congress

SEPTEMBER 6, 2012

The importance of mass reduction as a means of improving fuel economy, vehicle dynamics and enhancing the driving experience of the new Avalon was a major consideration. The smaller width helps minimize drag losses to help enhance fuel economy, too. for 2011 Camry Hybrid vs. 3,417 lbs. 1,669 kg) for 2011 Camry).

Camry Hybrid 278

Camry Hybrid 2013 Toyota Fuel Economy 278

Green Car Congress

JULY 31, 2013

PowerGenix, the developer of high-performance, automotive Nickel-Zinc (NiZn) batteries, has entered into an innovation contract with PSA Peugeot Citroën Automobiles under which PSA will conduct a comprehensive evaluation of the use of PowerGenix’s NiZn batteries as a replacement for lead-acid in stop-start vehicles.

Lead Acid 170

Lead Acid Nickel Cadmium Batteries Battery 170

Green Car Congress

JUNE 25, 2013

Among the transportation-related elements of US President Barack Obama’s new climate action plan, which he is outlining today in a speech at Georgetown University, is the development of new fuel economy standards for heavy-duty vehicles post-2018. Earlier post.).

Obama 249

Obama Cleaner Climate Fuel Economy 249

Green Car Congress

JUNE 12, 2012

Cold cranking performance of EXT battery systems, 80 Ah and 60 Ah. The dots represent the capability of Johnson Control’s current AGM battery at that temperature point. EXT batteries will go into production next year on a mainstream micro-hybrid system, Kessen said, although the customer is not talking about the program yet.

Li-ion 359

Li-ion Lead Acid Lithium Ion Hybrid 359

Green Car Congress

DECEMBER 2, 2009

Hyundai Motor America President and CEO John Krafcik introduces the all-new 2011 Sonata along with Hyundai’s Fluidic Sculpture design language. Hyundai introduced its all-new 2011 Sonata at the Los Angeles Auto Show, marking the North American debut of the latest version of the midsize sedan. 2011 Sonata. Click to enlarge.

2011 186

2011 Hyundai Engine Auto 186

Green Car Congress

MARCH 2, 2012

At a standstill, system automatically detects the position of each piston and injects fuel into the most favorably-placed cylinder. Energy recovered by the deceleration/braking energy recovery system is used to recharge the battery and restart the vehicle. Average fuel consumption (NEDC combined cycle) is down 25% compared with the 1.6

Fuel Economy 278

Fuel Economy MPG 2012 Engine 278

Green Car Congress

AUGUST 29, 2011

Through the end of July 2011, about 215,000 had been sold nationwide. (By By comparison, GM delivered 35,298 units of the LaCrosse in the US from January through the end of July 2011.). At the heart of the LaCrosse eAssist is a 115V lithium-ion battery and 15kW motor-generator unit, which help increase fuel economy.

General Motors 186

General Motors Buick Motor Motors 186

Green Car Congress

OCTOBER 25, 2011

ICA) have developed a new battery pack design for hybrid electric vehicles that promises to reduce battery size, weight, and cost while improving fuel economy. The 500 Wh lithium-ion battery pack can deliver 22 kW of peak power. AllCell Technologies, LLC and the International Copper Association, Ltd., (ICA)

Li-ion 210

Li-ion International Lithium Ion Hybrid 210

Green Car Congress

FEBRUARY 21, 2012

The military is interested in replacing lead-acid batteries with higher performing Li-ion systems. From a 2011 TARDEC presentation. A123 Systems has introduced the Military 6T Battery, a robust Li-ion battery system engineered specifically to meet the demanding requirements of military vehicles. Click to enlarge.

Li-ion 247

Li-ion Lead Acid Lithium Ion Design 247

Green Car Congress

DECEMBER 16, 2020

The result is that the engine dynamically fires the optimal number of cylinders to maximize fuel economy while maintaining a smooth ride with commercial levels of noise and vibration. Because each combustion event is selected to allow optimal efficiency, DSF reduces fuel and CO 2 , and for diesel applications, NO x emissions.

Yukon 186

Yukon Vehicles Escalade Sierra 186

Green Car Congress

AUGUST 16, 2009

The new Kizashi will have a hybrid option, reportedly in 2011. The Nikkei reports that Suzuki will introduce the Kizashi sedan into the North American market in 2011, using a next-generation system co-developed with GM. Suzuki and GM are developing a next-generation hybrid system that uses small but high-capacity lithium-ion batteries.

Suzuki 218

Suzuki 2011 GM Hybrid 218

Green Car Congress

DECEMBER 17, 2010

The Annual Energy Outlook 2011 (AEO2011) Reference case released yesterday by the US Energy Information Administration (EIA) more than doubles the technically recoverable US shale gas resources assumed in AEO2010 and added new shale oil resources. Shale gas offsets declines in other US supply to meet. Source: EIA. Click to enlarge.

Gas 199

Gas 2011 Price Energy 199

Green Car Congress

MAY 5, 2009

Saturn currently sells two hybrid vehicles (VUE and Aura with GM Hybrid System) and was scheduled to begin initially offering a two-mode hybrid Vue ( earlier post ), with a Vue plug-in two-mode hybrid version ( earlier post ) due in 2011 for use in a cooperative demonstration test fleet with the US Dept. Earlier post.). Earlier post.).

VUE 150

VUE Plug-in GM Saturn 150

Green Car Congress

DECEMBER 14, 2011

Ford’s Michigan Assembly Plant is starting production of the 2012 Focus Electric ( earlier post )—a five-passenger, battery-electric car Ford expects will achieve more than a 100 miles per gallon equivalent (MPGe) fuel economy rating. 1 gallon of gasoline=33.7 Earlier post.).

Michigan 363

Michigan 2012 Ford Lithium Ion 363

Green Car Congress

FEBRUARY 4, 2011

Infiniti announced official EPA (Environmental Protection Agency) fuel economy figures of 32 mpg highway, 27 mpg city for its first production hybrid performance luxury sedan, the all-new 2012 Infiniti M35h. It goes on sale at Infiniti retailers nationwide in spring 2011. Combined cycle fuel economy is 29 mpg. .

Infinity 210

Infinity MPG 2012 Hybrid 210

Green Car Congress

NOVEMBER 1, 2011

variant but with fuel economy of a strong hybrid. Engine downsizing is central to Ricardo’s gasoline engine roadmap for future CO 2 and fuel economy improvements. More than two dozen SSV models were available in Western Europe as of early 2011, while in the United States, only three SSV models are for sale.

Downsizing 230

Downsizing Prius Hybrid Emissions 230

Green Car Congress

AUGUST 6, 2009

The 8 kWh battery pack for the new 2011 Buick PHEV crossover vehicle is prepared for testing at the General Motors Tech Center in Warren, Michigan. General Motors will debut its two-mode plug-in hybrid technology—originally intended to appear first in a Saturn VUE, prior to that brand’s sale—in a new Buick crossover vehicle in 2011.

Buick 210

Buick Li-ion Plug-in GM 210

Green Car Congress

JULY 6, 2013

Battery replacement along with EVSE will also greatly affect the relative TCO of the electric truck. Battery replacement is another key factor; to maximize the benefits from electric trucks, the durability and reliability of the automotive Li-ion battery are crucial, which might be advanced with technological development.

Diesel 361

Diesel Georgia Energy Li-ion 361

Green Car Congress

AUGUST 4, 2010

Hyundai Motor America, currently the leading fuel economy auto manufacturer in the US according to EPA ratings, plans to achieve a corporate average fuel economy (CAFE) rating of at least 50 (mpg) by 2025 for its lineup of passenger cars and light duty trucks. The Sonata Hybrid incorporates a lithium polymer battery.

MPG 223

MPG Hyundai America Fuel Economy 223

Green Car Congress

DECEMBER 16, 2010

Additionally, Proterra is working with local support to break ground on its larger Phase 2 plant located on Clemson University’s International Center for Automotive Research campus in the spring of 2011. Proterra claims that the EcoRide BE35 is the first battery-electric bus that can charge in under ten minutes.

Manufacturer 186

Manufacturer Batteries Battery Grant 186

Green Car Congress

AUGUST 20, 2012

Pike Research forecasts that the global market for all electric-drive buses—including hybrid, battery electric, and fuel cell buses—grow steadily over the next. would purchase 500 battery electric buses. Annual sales of hybrid buses in China surpassed that of North America in 2011, reaching almost 1,700 units.

2018 276

2018 Li-ion Hybrid Fuel 276

Green Car Congress

MARCH 23, 2010

Lexus will bring the CT 200h premium compact hybrid to the US market in early 2011 as the first dedicated hybrid vehicle in the premium compact segment. The engine-driven generator can charge the battery pack or provide additional power to the drive motor as needed. CT 200h powertrain. Click to enlarge. Earlier post.).

Lexus 223

Lexus HS 250h 2011 Hybrid 223

Green Car Congress

AUGUST 1, 2012

The Nissan Serena minivan has taken the Nº1 position in minivan sales in Japan for calendar year 2011, fiscal year 2011 and for the first half of calendar year 2012. The hybrid system also adds a sub battery for increased storage capacity, which fits in the current engine compartment. Nissan Motor Co., Serena S-HYBRID.

Japan 218

Japan Nissan Hybrid Minivan 218