Green Car Congress

SEPTEMBER 13, 2011

Mercedes-Benz is presenting its first electric vehicle with Range Extender at the 2011 Frankfurt International Motor Show: the Concept B-Class E-CELL PLUS. Equipped with a Li-ion battery pack from Deutsche Accumotive (a joint venture of Daimler and Evonik), the E-CELL PLUS has a battery-only range of up to 100 km (62 miles).

Extended Range 231

Extended Range Concept Mercedes Electric Vehicles 231

Green Car Congress

NOVEMBER 23, 2010

Elements of Raser’s current series plug-in hybrid (extended range electric vehicle) drive system. Berg helped found Li-ion battery company Valence and has served on the board of directors since September 1991. Click to enlarge. Raser Technologies, Inc. Earlier post.). million, of which Raser will receive $2.5

Extended Range 239

Extended Range Companies Range Hummer 239

Green Car Congress

AUGUST 17, 2009

is developing a 21 kWh Li-ion battery pack utilizing cells from Korea-based Energy Innovation Group (EIG Ltd.) for a Range-Extended Electric Vehicle (ReEV) project. The complementary cooperation combines the engineering and test core competencies of FEV with the lithium-ion battery core competencies of EIG.

Li-ion 199

Li-ion Lithium Ion Electric Vehicles Range 199

Green Car Congress

DECEMBER 8, 2009

The demonstrator is equipped with a 17 kW GENEPAC fuel cell stack, developed by PSA Peugeot Citroën and the French Atomic Energy Commission (CEA) ( earlier post ); a 13 kWh Li-ion battery pack (with energy densities of 100 Wh/L and 88 Wh/kg); and storage tanks holding 4.2 kg of hydrogen at 700 bar. Source: CEA. Click to enlarge.

Extended Range 207

Extended Range Fuel Electric Vehicles Range 207

Green Car Congress

FEBRUARY 19, 2009

CPI) shortly after GM selected CPI and its parent LG Chem as the provider for the Li-ion batteries for the Extended Range Electric Vehicle (E-REV) Chevy Volt. (GM billion, and spends $60 million annually on Li-ion battery research and development. Company Overview. LG Chem has annual sales of $14.3

Li-ion 170

Li-ion Power Powered Market 170

Green Car Congress

OCTOBER 26, 2015

Jens-Peter Suchsland, SolviCore GmbH, delve into the technological barriers for all-electric vehicles—battery-electric or PEM fuel cell vehicles. In addition, in the case of BEVs, recent studies clearly showed that BEV driving range (closely followed by cost) are the predominant variables determining consumer acceptance.

Lithium Sulfur 150

Lithium Sulfur Electric Vehicles Li-ion Batteries 150

Green Car Congress

JUNE 16, 2009

In 2011, the largest dollar volume for Li-ion automotive applications could come from the mini EV and EREV segment. the Prius) will represent the top Li-ion business opportunity from a dollar value perspective, followed by moderate hybrids and light electric vehicles (bikes and scooters), particularly in Asia.

Li-ion 150

Li-ion 2011 Market Hybrid 150

Green Car Congress

AUGUST 6, 2009

The 8 kWh battery pack for the new 2011 Buick PHEV crossover vehicle is prepared for testing at the General Motors Tech Center in Warren, Michigan. General Motors will debut its two-mode plug-in hybrid technology—originally intended to appear first in a Saturn VUE, prior to that brand’s sale—in a new Buick crossover vehicle in 2011.

Buick 210

Buick Li-ion Plug-in GM 210

Green Car Congress

SEPTEMBER 28, 2012

Building on its previously seen XIV and KEV design concepts, SsangYong Motor Company is showcasing the e-XIV (electric - eXciting user Interface Vehicle) ‘range extended EV concept at the 2012 Paris Motor Show. e-XIV concept extended range electric vehicle. Click to enlarge.

Range 262

Range Plug-in Li-ion Gasoline-Electric 262

Green Car Congress

FEBRUARY 18, 2011

Ltd will stage the European premiere of two electric vehicles at the upcoming 2011 Geneva International Motor Show in March: the updated pure-electric vehicle 2012 e6-Eco and the independent 4WD dual-mode electric SUV S6DM. China-based BYD Co., It takes 40 minutes to fully charge the e6 using a 100 kW quick charger. gasoline engine.

E6 199

E6 BYD Li-ion Extended Range 199

Green Car Congress

FEBRUARY 4, 2009

Student engineers participating in EcoCAR: The NeXt Challenge unveiled their vehicle architectures at the Washington Auto Show. The 17 designs range from systems using on-board hydrogen fuel cells to full battery-electric vehicles. All of the designs use lithium-ion battery technology.

Li-ion 170

Li-ion Plug-in Plug Renewable 170

Green Car Congress

DECEMBER 14, 2011

Ford’s Michigan Assembly Plant is starting production of the 2012 Focus Electric ( earlier post )—a five-passenger, battery-electric car Ford expects will achieve more than a 100 miles per gallon equivalent (MPGe) fuel economy rating. 1 gallon of gasoline=33.7 Phoenix and Tucson, Ariz.; Portland, Ore.; Raleigh-Durham, N.C.;

Michigan 363

Michigan 2012 Ford Lithium Ion 363

Green Car Congress

JANUARY 14, 2010

A123 Systems has entered a battery supply agreement with Fisker Automotive to supply battery systems for the Fisker Karma Plug-in Hybrid Electric Vehicle (PHEV). The Karma—an extended-range electric vehicle—is scheduled to be launched in late 2010. facility with production slated to commence later this year.

Fisker 218

Fisker Karma Li-ion Supplies 218

Green Car Congress

SEPTEMBER 4, 2009

Opel has begun testing two development cars (mules) of the Ampera extended-range electric vehicle (E-REV) ( earlier post ) at its Dudenhofen proving ground, keeping the four-seater on schedule for a late 2011 production date. A 16 kWh Li-ion battery pack provides all-electric range of up to 60 km/37 miles (MVEG).

Li-ion 186

Li-ion Lithium Ion Spain Extended Range 186

Green Car Congress

OCTOBER 5, 2015

Battery-electric bus manufacturer Proterra has introduced a new 35-foot vehicle based on the same technology platform as its current 40-foot Catalyst vehicle. Proterra has demonstrated that this option can travel more 700 miles in 24 hours. Earlier post.).

Washington 150

Washington Energy Storage Federal Grant Li-ion 150

Green Car Congress

NOVEMBER 18, 2009

The Volt and its Li-ion battery pack have proceeded in parallel through GM’s development and manufacturing process. Both the vehicle and the pack have undergone some expected tweaking on the run-up to PPV based on the testing to date. There have been more than 300,000 miles of customer use lab testing to date.

2010 218

2010 Volt Li-ion Production 218

Green Car Congress

FEBRUARY 17, 2013

The Robust Affordable Next Generation EV-Storage (RANGE) program’s goal is to enable a 3X increase in electric vehicle range (from ~80 to ~240 miles per charge) with a simultaneous price reduction of > 1/3 (to ~ $30,000). The second objective of RANGE is to fund the development of multifunctional energy storage systems.

Energy Storage 239

Energy Storage Range Energy Nickel Metal Hydride 239

Green Car Congress

MARCH 3, 2009

The Ampera is an extended range electric vehicle based on the Voltec technology used in the Chevrolet Volt. Equipped with a 16 kWh Li-ion battery pack, the five-door, four-seat hatchback has a battery-powered range of up to 60 km (37 miles) (MVEG cycle). Earlier post.) Click to enlarge.

Chevrolet 150

Chevrolet GM Europe Li-ion 150

Green Car Congress

OCTOBER 20, 2010

During the serial media launch events for the Chevrolet Volt, GM provided more detail (subsequent to the completion of related patent work) on the novel drive architecture applied in their first extended range electric vehicle to enhance the efficiency of both the battery electric and extended-range driving modes.

Extended Range 344

Extended Range Volt Motor Motors 344

Green Car Congress

MARCH 19, 2009

billion in federal funding from the American Recovery and Reinvestment Act of 2009 (ARRA) in support of the development of advanced electric drive vehicles (EDVs) including plug-in hybrid electric (PHEV), electric vehicles (EV), and fuel cell vehicles (FCV). Electric Drive Vehicle Battery and Components.

PHEV 170

PHEV Batteries Battery Vehicles 170

Green Car Congress

SEPTEMBER 3, 2015

A Proterra 40-foot Catalyst XR (extended range) electric bus drove 258 miles (415 miles) on a single charge under test conditions at Michelin’s Laurens Proving Grounds (LPG). The Catalyst XR configuration for the max mileage test used 8 NMC Li-ion battery packs, with a total energy capacity of 257 kWh.

Extended Range 150

Extended Range Miles Lithium Titanate Range 150

Green Car Congress

MARCH 20, 2009

Key challenges to commercialization revealed by the demonstrations were: Vehicle Range. The most significant challenge was range. Diesel buses typically operate for 18 to 20 hours per day, over a range of about 186-217 miles (300-350 km), using one tank of fuel. Fuel Cell Durability. This was higher than expected.

Nickel Metal Hydride 170

Nickel Metal Hydride Hydrogen 2002 Fuel 170

Green Car Congress

NOVEMBER 16, 2012

GM will focus its vehicle electrification strategy on eAssist-type systems and the plug. GM is tracking to sell more than 50,000 vehicles this year with some form of electrification, Barra said—the majority of which will be eAssist systems. We have every intention of maintaining our leadership position in plug-in vehicles.

Extended Range 286

Extended Range GM Light Plug 286

Green Car Congress

SEPTEMBER 22, 2018

At IAA Commercial Vehicles, Allison Transmission announced that it will offer its medium-duty, fully automatic 9-speed transmission globally, and that it has developed an electric hybrid system with purely electric extended range. The two-mode split parallel architecture improves fuel economy up to 25%.

Global 239

Global Available 2000 Extended Range 239

Green Car Congress

AUGUST 22, 2017

that covers the supply of SUMO MD powertrain systems for the E-GEN battery-electric extended range and E-100 all-electric delivery truck platforms. MPGe fuel efficiency, with an average range of 100 miles on a single charge depending on duty cycle. Last mile delivery vehicles are perfect candidates for electrification.

Extended Range 150

Extended Range Li-ion Miles Supplies 150

Tony Karrer Delicious EVdriven

APRIL 16, 2009

iMiEV Mitsubishi Innovative Electric Vehicle by Noel Adams Mitsubishi has been showing a number of electric cars at auto shows starting in Tokyo back in 2005, they didnt show the most recent iteration, the one that will be the production version, until the 2007 Frankfurt Auto show. The steering is light but precise.

Mitsubishi 28

Mitsubishi i-MiEV Electric Vehicles Vehicles 28

Green Car Congress

FEBRUARY 3, 2010

Axeon , Europe’s largest independent lithium-ion battery systems supplier, will develop a new high-capacity battery system for the electric Citroën C1 ev’ie, manufactured by the UK-based Electric Car Corporation ( earlier post ), with a view to supplying between 300 and 500 units in the 12 months following a successful trial.

C1 186

C1 Li-ion Lithium Ion Extended Range 186

Green Car Congress

AUGUST 14, 2009

to manufacture lithium-ion battery packs for the Chevrolet Volt and other extended-range electric vehicles. The previously announced plant is the first lithium-ion battery manufacturing plant in the US operated by a major automaker. General Motors Company will invest $43 million in Brownstown Township, Mich.

Li-ion 225

Li-ion GM Lithium Ion Batteries 225

Green Car Congress

DECEMBER 23, 2010

Ltd (BYD) will reveal plans for the launch of US-ready electric drive vehicles and clean energy products at the upcoming 2011 North America International Auto Show (NAIAS) in Detroit. Equipped with a BYD Iron-phosphate FE battery pack, the e6 Premier has an expected range of 300 km (186.4 liter gasoline engine.

BYD 170

BYD E6 PHEV Extended Range 170

Green Car Congress

JANUARY 8, 2010

Although lithium-ion cell and pack costs are expected to fall sharply by 2020, they are unlikely to drop enough to support widespread adoption of fully electric vehicles without a major breakthrough in battery technology, according to a new study by The Boston Consulting Group (BCG). Tradeoffs among five principle Li-ion chemistries.

Fully Electric 199

Fully Electric 2020 Market Lithium Ion 199

Green Car Congress

OCTOBER 1, 2009

Balqon Corporation, an emerging developer and manufacturer of zero emissions heavy-duty electric vehicles for Class 7 and Class 8 applications ( earlier post ), introduced a lithium-ion battery powered heavy-duty electric truck designed for use in on-highway short-haul applications at the Governors’ Global Climate Summit in Los Angeles, California.

Lithium Ion 231

Lithium Ion Li-ion Los Angeles Lead Acid 231

Tony Karrer Delicious EVdriven

APRIL 21, 2009

At these prices, people are buying the "environmental feature" -- they want to be among the first owners of the worlds cleanest extended-range vehicles. Today youd do it to be one of the first to drive the worlds cleanest extended range vehicle; in the future, youll do it because its an obvious and affordable win!

Plug-in 41

Plug-in Plug Hybrid Nickel Metal Hydride 41

Green Car Congress

AUGUST 11, 2009

Based on the same draft EPA methodology, the Volt would also deliver “ triple-digit ” combined cycle fuel economy along with combined cycle electricity consumption of 25 kWh/100 miles, according to GM. for electricity to travel 100 miles, or less than three cents per mile.

Volt 230

Volt MPG EPA GM 230

Green Car Congress

AUGUST 25, 2009

Opel will debut the new Astra at the 2009 Frankfurt Motor Show; the company will also showcase the Ampera, Opel’s implementation of the Voltec extended range electric vehicle architecture. An on-board gasoline/E85-fueled engine-generator extends the Ampera’s range to more than 500 km (311 miles).

Fuel 186

Fuel MPG Gasoline-Electric Gasoline 186

Green Car Congress

NOVEMBER 28, 2012

A 24 kWh liquid-cooled/heated Li-ion battery powers an 83 kW permanent-magnet, three-phase synchronous drive motor with 147 lb-ft (200 N·m) of torque. With its e-Drive, the 500e offers more than 80 miles of estimated range, with city driving range typically greater than 100 miles. Battery pack.

2013 261

2013 Auto Volt Chrysler 261

Tony Karrer Delicious EVdriven

APRIL 21, 2009

Despite this, a 2003 EPRI study , assuming only $2/gallon gas , zero buying incentives, and a PHEV premium of $3-$5,000 more than standard hybrids, shows that the total lifetime cost of ownership for a PHEV will be lower than that of any other vehicle type -- so the payback will be there. Whats Vehicle-to-Grid and why would I like it?

PHEV 37

PHEV Nickel Metal Hydride Prius EPRI 37