Green Car Congress

AUGUST 2, 2009

Based on detailed model-level data for US light-duty vehicles from 1980 to 2006, a recent analysis by a UC Davis researcher found that if weight, horsepower and torque had been held at their 1980 levels, fuel economy for both passenger cars and light trucks could have increased by nearly 50% from 1980 to 2006. Knittel, 2009.

Fuel Economy 210

Fuel Economy Downsizing Obama Economy 210

Green Car Congress

OCTOBER 16, 2013

As reported in a paper in ACS journal Environmental Science & Technology , the results showed that GDI technology has the potential to meet the upcoming California LEV III and US EPA Tier 3 PM mass standard of 3 mg/mi (phasing in over MY2017?2021) Credit: ACS, Maricq et al. Click to enlarge. Earlier post.) and fuel properties.

Standards 246

Standards Emissions Miles Engine 246

Green Car Congress

NOVEMBER 15, 2009

The dark grey areas are silicon particles; the light grey areas aluminium. Federal-Mogul Corporation has developed an innovative aluminum piston design that can reliably withstand the mechanical and thermal loads produced by heavily boosted engines, thereby enhancing diesel engine performance and supporting diesel downsizing.

Downsizing 210

Downsizing Diesel Engine Design 210

Green Car Congress

MAY 16, 2019

In a paper presented at the 2019 Vienna Motor Symposium this week, Delphi Technologies will unveil a new 500+ bar GDi system that can reduce particulate emissions by up to 50% compared to state-of-the-art 350 bar system without expensive engine design modifications. —Walter Piock, chief engineer, Gasoline Systems, Delphi Technologies.

Emissions 257

Emissions Gasoline Fuel Exhaust 257

Green Car Congress

DECEMBER 1, 2014

At the 2 nd International Conference Automotive 48 V Power Supply Systems , held last week in Düsseldorf, Germany, Controlled Power Technologies (CPT), a major sponsor of the event, together with leading car makers and Tier 1 suppliers, argued the need for an internationally agreed 48V electrical standard.

Standards 257

Standards International Vehicles Hybrid 257

Green Car Congress

APRIL 2, 2010

The footprint-based standard CO 2 curves for cars (left) and trucks (right). Each manufacturer will have its own fleet-wide standard which reflects the vehicles it chooses it produce. Light trucks. system leakage) and indirect CO 2 emissions related to the increased load on the engine. Source: EPA. Click to enlarge.

EPA 236

EPA Standards Light PHEV 236

Green Car Congress

FEBRUARY 22, 2018

Although GDI vehicles offer the potential of improved fuel economy, less fuel pumping, and charge air cooling, they tend to produce higher particulate matter (PM) emissions when compared with the traditional port fuel injection engines. liter all-guided direct injection SI Atkinson cycle engine; the second was equipped with a 1.5-liter

Gasoline 253

Gasoline Emissions Engine Fuel Economy 253

Green Car Congress

APRIL 8, 2015

In a new report, Navigant Research forecasts that total annual global light-duty start-stop vehicle (SSVs) sales will reach 59 million, accounting for 55% of all light duty vehicle sales. This also offers opportunities for other engine efficiencies such as electric boost. —“ Start-Stop Vehicles ”.

Light 150

Light North America Global Sale 150

Green Car Congress

JULY 25, 2013

New generation XL3 injector for GDI engines goes into production. liter GDI engine. of 8 holes) enables optimal adaptation to all engine-specific requirements. of 8 holes) enables optimal adaptation to all engine-specific requirements. Click to enlarge.

Engine 294

Engine Production Downsizing Emissions 294

Green Car Congress

OCTOBER 25, 2012

Fuel mass flow comparison shows Pinnacle engine ahead at just about all points in the map. FEV performed engine mappings in a dynamometer test cell to evaluate the fuel economy of Pinnacle’s TP90 scooter engine compared to a benchmark engine (N15) from Pinnacle’s Asian OEM partner. Test engine specs. Stroke [mm].

Engine 262

Engine Fuel Fuel Economy Production 262

Green Car Congress

APRIL 19, 2016

Continental will present an innovative close-coupled annular catalytic converter that supports near-complete NO x conversion in downsized turbocharged gasoline engines at the 37 th Vienna Motor Symposium next week. For downsized turbocharged gasoline engines, this presents two challenges. Click to enlarge.

Convert 150

Convert Standards Exhaust Conversion 150

Green Car Congress

MAY 1, 2012

Delphi Automotive has developed a common rail fuel system technology for heavy-duty diesel engines that combines proven hardware with an innovative architecture, allowing vehicle manufacturers to meet Euro VI emissions standards without significant modification to their base engines.

Engine 199

Engine Light Diesel 2000 199

Green Car Congress

SEPTEMBER 12, 2012

At the 17 th Supercharging conference this week in Dresden, Controlled Power Technologies (CPT) will launch what it says is the first water-cooled electric supercharger developed for “quasi-continuous” boosting of commercial diesel engines, including those developed for off highway applications. tonnes gross vehicle weight. Earlier post.)

Water 370

Water Commercial Engine Diesel 370

Green Car Congress

FEBRUARY 5, 2020

CO 2 and NO x certification test data for heavy-duty diesel engines certified from 2002 through 2019. which are regulated under the National Ambient Air Quality Standards (NAAQS) because of their adverse effects on human health and the environment. Source of data: US EPA (2019). Chart: MECA.

Emissions 291

Emissions Diesel Engine 2010 291

Green Car Congress

FEBRUARY 4, 2013

During its recent Innovation Day presentations ( earlier post ), PSA Peugeot Citroën announced that it will commercialize high-efficiency gasoline engines featuring dedicated exhaust gas recirculation (D-EGR), derived from a collaborative program with SwRI in the US. PSA concept D-EGR engine. PSA has filed for two patents on its work.

Gasoline 268

Gasoline 2018 Engine Commercial 268

Green Car Congress

DECEMBER 17, 2015

The US Department of Energy, Office of Energy Efficiency and Renewable Energy’s (EERE) Bioenergy Technologies Office (BETO) and Vehicle Technologies Office (VTO) have released a request for information (RFI) ( DE-FOA-0001460 ) titled “Co-Optimization of Fuels and Engines” (Optima). Earlier post.) Source: DOE. Click to enlarge.

Engine 150

Engine Fuel Fuel Economy Light 150

Green Car Congress

SEPTEMBER 30, 2014

Automakers are turning to downsized turbocharged engines to satisfy more stringent global fuel economy and emission regulations and customer demand for better-performing vehicles. In addition to improving fuel efficiency, downsized turbocharged engines also reduce harmful exhaust emissions. Regional growth projections.

2019 261

2019 Global Sale Downsizing 261

Green Car Congress

MAY 6, 2013

The new MY2014 Mercedes-Benz Sprinter van for the US now features a 2.1L, 4-cylinder diesel with a t-speed automatic transmission as standard. liter four-cylinder diesel engine produces 161 hp (120 kW) and 265 lb-ft (359 N·m) of torque at 1,400-2,400 rpm. The engines attain both a high specific power output and high torque.

2014 306

2014 Diesel Standards Exhaust 306

Green Car Congress

AUGUST 4, 2011

Mazda’s roadmap to the ideal internal combustion engine. the step-by-step introduction of electrification to SKYACTIV internal combustion engines: stop-start, followed by regenerative braking, followed by electric motor drive technologies. Energy balance in an internal combustion engine. Click to enlarge. Click to enlarge.

Mazda 322

Mazda Engine Gasoline Diesel 322

Green Car Congress

APRIL 28, 2012

Test results from that supplier have demonstrated potential fuel-saving, engine down-sizing and/or down-speeding opportunities without adversely affecting performance and drivability. band, particularly at low engine speeds. manufacturers can utilize smaller, more efficient engines with no loss in. V6 engine.

Downsizing 304

Downsizing Engine 2008 Design 304

The Truth About Cars

JUNE 8, 2023

Other dimensions of the Mark VIII were larger in all directions, a stark contrast to the extreme downsizing implemented on Mark VI, a measure pushed further by the tidy proportions of the Mark VII.& Worth a quick comparison, the equivalent Thunderbird weighed 3,536 pounds with a V6 engine or 3,725 with the V8. a subsidiary of Fiat.

Parts 90

Parts Mercury 2003 2004 90

Green Car Congress

OCTOBER 11, 2011

Compared to the engine in the previous model, the normally aspirated 5.2-liter The engine delivers 650 N·m (479 lb-ft) of torque between 1,700 and 5,500 rpm; and peak power (382 kW/520 hp) is developed at 5,800 rpm. As the youngest member of the large Audi family of V engines, the 4.0 The newly developed 4.0

Audi 199

Audi Downsizing Fuel Engine 199

Green Car Congress

AUGUST 1, 2016

The US Department of Energy (DOE) will award up to $7 million in project funding to accelerate the introduction of affordable, scalable, and sustainable high-performance fuels for use in high-efficiency, low-emission engines as part of the Co-Optimization of Fuels and Engines (Co-Optima) initiative. Earlier post.).

Engine 150

Engine Fuel Emissions Pollution 150

Green Car Congress

AUGUST 10, 2009

Additionally, suggested one of the speakers, advanced SIDI (spark-ignited, direct-injection) engines can take light-duty market share back from diesels in Europe based on the same trends. The SULEV standard, established under the current LEV II regulation, is equivalent to the Federal Tier 2 Bin 2 standard.

Gasoline 150

Gasoline Diesel Engine Emissions 150

Green Car Congress

SEPTEMBER 15, 2016

Major automotive suppliers see national fuel economy standards as important for long-term planning and investment and don’t want to see them altered by US policymakers, according to a first-of-its-kind industry survey commissioned by CALSTART and conducted by Ricardo Energy & Environment.

Fuel Economy 150

Fuel Economy Auto Economy Standards 150

Green Car Congress

DECEMBER 19, 2013

Annual stop-start light duty vehicle sales by region, world markets: 2013-2022. By 2022, total global annual sales for light duty stop-start vehicles (SSVs) will exceed 55 million, accounting for 54.3% A longer period with the engine off also changes the nature of ancillary systems that must be electrified. Source: Navigant.

North America 273

North America Sale Global Vehicles 273

Green Car Congress

DECEMBER 9, 2016

This year’s forecast recognizes an industry trend for slightly bigger engine sizes in Europe and China as automakers adapt powertrain strategies to tackle updated emissions regulations developed for real-world driving conditions. In these regions, a typical powertrain is a three- or four-cylinder engine with a displacement size between 1.2

Global 150

Global Sale Transportation Vehicles 150

Green Car Congress

OCTOBER 23, 2014

of total worldwide light-duty vehicle sales by 2023, or about 2.5 Of note are fuel efficiency advances made to conventional internal combustion engines (ICEs) through stop-start technologies, the use of lightweight materials for body panels and chassis, engine downsizing, and growing interest in diesel. million units.

Plug-in 276

Plug-in Plug Global Sale 276

Green Car Congress

JUNE 29, 2012

For the 2013 XF and XJ lineup, Jaguar is adding two new downsized forced induction gasoline powerplants: 3.0-liter Eight-speed ZF automatic transmissions are now fitted to all gasoline and diesel XJ and XF variants as standard for greater efficiency and performance. —Ron Lee, Group Chief Engineer, Powertrains, Jaguar Cars.

Gasoline 225

Gasoline Engine 2013 MPH 225

Green Car Congress

JUNE 14, 2011

Plug-in hybrids dominate market penetration in 2025 under CAR scenario IV (62 mpg CAFE standard). Each of these nine pathways produced a specific fuel economy standard and cost estimate measured at retail price equivalence. The results for each fuel economy scenario are: Scenario I: (47 mpg CAFE standard, 37.6 Source: CAR.

Fuel Economy 199

Fuel Economy Economy Auto Industry Standards 199

Green Car Congress

MAY 27, 2014

Due to strong federal and state emissions standards, the average new car has gotten 43% cleaner since 1998. The company also showed strong improvements in GHG emissions due to its increased use of hybrids and its focus on smaller, turbocharged engines in vehicles ranging from the Ford Focus sedan to the F-150. Source: UCS. Source: UCS.

2013 299

2013 Kia Hyundai Sale 299

Green Car Congress

JANUARY 29, 2021

In addition to GM’s carbon goals, the company worked with the Environmental Defense Fund to develop a shared vision of an all-electric future and an aspiration to eliminate tailpipe emissions from new light-duty vehicles by 2035. Renewable Energy.

General Motors 199

General Motors Carbon Emissions GM 199

Green Car Congress

JANUARY 26, 2010

EBDI engine. Based on test work already carried out, Ricardo estimates that a fuel economy improvement of up to 30% is possible with no loss of power or performance, using a downsized EBDI engine in place of currently available gasoline powertrain technology. liter EBDI engine—resulting in up to a 16.8%

Engine 218

Engine Energy Fuel Economy Gasoline 218

Green Car Congress

APRIL 5, 2011

will exhibit its High Efficiency Combustion System (HECS) diesel engine at the 2011 SAE World Congress, 12-14 April at Cobo Center in Detroit. Flexible multiple injection and two-stage turbocharging improve low-end torque, in spite of the reduction in engine capacity. The second-generation HECS has been adapted to a downsized 1.6L

Congress 218

Congress 2011 Diesel Exhaust 218

Green Car Congress

NOVEMBER 14, 2014

It features 8 MPEs (Media Processing Engines) that perform double precision floating point arithmetic, and integrates 14 types of image processing accelerators for the first time. With TMPV7608XBG, Toshiba is supporting the realization of next-generation Advanced Driver Assistance Systems (ADAS).

DC 259

DC Downsizing 2015 Power 259

Green Car Congress

AUGUST 3, 2016

MaryAnn Wright, group vice president of Technology and Industry Relations, Johnson Controls Power Solutions, noted that automakers have made significant advances in fuel efficiency and reduced emissions through implementation of several new technologies, such as turbo charging, engine downsizing and light weighting across their fleets.

Fuel 150

Fuel Vehicles Downsizing Purchase 150

Green Car Congress

JUNE 4, 2010

Various combinations of commercially available technologies could greatly reduce fuel consumption in passenger cars, sport-utility vehicles, minivans, and other light-duty vehicles over the next 15 years without compromising vehicle performance or safety, according to a new report by the National Research Council. Engines and Technologies.

Purchase 210

Purchase Lithium Ion Fuel Available 210