Green Car Congress

NOVEMBER 1, 2011

variant but with fuel economy of a strong hybrid. HyBoost achieves this by combining aggressive 50% downsizing of the engine with an electric supercharger for transient low-speed performance, and a micro-hybrid stop-start and energy recuperation systems, Boggs said. Downsizing the 2.0-liter Click to enlarge.

Downsizing 230

Downsizing Prius Hybrid Emissions 230

Green Car Congress

APRIL 22, 2013

Use of a variable compression ratio (VCR) could be one technology approach to reducing fuel consumption in highly boosted (e.g., downsized, turbocharged) gasoline engine, as operating an engine with higher compression ratios at low load can increase fuel economy compared to operating an engine with fixed compression ratio.

Fuel Economy 218

Fuel Economy Economy Fuel Downsizing 218

Green Car Congress

JANUARY 14, 2014

In part-load operation, the indirect injection supplements direct gasoline injection to improve fuel economy and to reduce the output of particulates from the engine. GDI technology provides fuel efficiency benefits from charge air cooling, more facile turbocharging, and the downsizing that these permit.

Gasoline 304

Gasoline Audi Fuel Engine 304

Green Car Congress

JUNE 14, 2011

Based on the results of the study, CAR believes the economic risk to the auto industry connected to mandating permanent fuel economy standards in the long run is “ very serious ” The group recommends periodic review to assess the rate of technology development and cost reduction of advanced technologies leading up to 2025.

Fuel Economy 199

Fuel Economy Economy Auto Industry Standards 199

Green Car Congress

JULY 11, 2017

The ICCT team—John German and Aaron Isenstadt—concluded that diesels have and will retain two significant advantages over gasoline engines: significantly better fuel economy and cargo hauling and towing ability. Meeting the 2025 standard will require an average improvement in fuel economy of about 4.1%

Diesel 186

Diesel Light Fuel Economy 2017 186

Green Car Congress

OCTOBER 11, 2013

The Automobile Division of the Institution of Mechanical Engineers has awarded its Prize for the Environment to Ricardo, Ford Motor Company, Controlled Power Technologies and Valeo engineers for their paper HyBoost—An Intelligently Electrified Optimized Downsized Gasoline Engine Concept. Earlier post.).

Engine 210

Engine Downsizing Lead Acid Automobile 210

Green Car Congress

SEPTEMBER 9, 2014

The ADEPT project was launched in 2013 to demonstrate the potential for 48V-based intelligent electrification to deliver full hybrid-scale fuel efficiency from a highly cost-effective package. An effective limitation on downsizing, however, is the delivery of acceptable driveability characteristics and launch performance.

Diesel 231

Diesel Downsizing Lead Acid Gasoline-Electric 231

Green Car Congress

SEPTEMBER 13, 2010

Reductions in fuel consumption and CO 2 from base 2.0-liter liter ELC-Hybrid to downsized 1.4L VTES + SpeedStart. Based on a VW Passat family-sized saloon, the demonstrator currently incorporates a advanced, AVL-developed 2-liter gasoline engine already delivering a fuel consumption of 6.6 Click to enlarge.

VRLA 210

VRLA Hybrid Downsizing Fuel 210

Green Car Congress

MAY 14, 2009

Continuing to emphasize a downsizing approach, Volkswagen presented two new engines at the at the 30 th Vienna Engine Symposium (7-8 May): the 1.2-liter liter TSI gasoline engine and the 1.6-liter Both engines impressively show how Volkswagen reduces the CO 2 emissions and the fuel consumption and that to fungible costs.

Downsizing 150

Downsizing Engine MPG Exhaust 150

Green Car Congress

AUGUST 4, 2011

However, while Mazda plans to offer hybrid vehicles in the medium-term, its engineers are pushing hard to increase the efficiencies of both the gasoline and diesel platforms, moving toward what they call “the ideal Internal Combustion Engine.” Extreme compression ratio rather than downsizing. Although downsizing—i.e.,

Mazda 322

Mazda Engine Gasoline Diesel 322

Green Car Congress

JANUARY 11, 2010

The funding includes more than $100 million from the American Recovery and Reinvestment Act, and with a private cost share of 50%, will support nearly $375 million in total research, development and demonstration projects. 38,831,115. Daimler Trucks North America, LLC. 39,559,868. Navistar, Inc. 37,328,933. 14,458,572. Cummins Inc.

Fuel Economy 199

Fuel Economy Downsizing Vehicles Waste 199

Green Car Congress

AUGUST 10, 2009

Cackette was in effect suggesting that the future tailpipe emissions baseline (LEV III) for light duty passenger vehicles—both diesel and gasoline—was likely to be or to approximate CA SULEV/US Tier 2 Bin 2. These are likely to drive further increases in cost, and potentially further reductions in fuel efficiency. Tim Johnson.

Gasoline 150

Gasoline Diesel Engine Emissions 150

Green Car Congress

SEPTEMBER 23, 2014

The new approach to natural gas combustion technology is designed to provide vehicle and engine original manufacturers (OEMs) with a “downsized” natural gas solution that is cost competitive while providing similar levels of power, torque, and fuel economy to a larger diesel engine.

Diesel 259

Diesel Gas Fuel Economy Power 259

Green Car Congress

NOVEMBER 8, 2011

Current fuel economy policy clearly demonstrates this fact. The federal government is pushing their fleet-procurement decisions almost completely to EVs and hybrids irrespective of costs. —“The Case for Technology Neutral Public Policy in Fuel Economy Debate”.

Standards 247

Standards Transportation Fuel Economy MPG 247

Green Car Congress

FEBRUARY 4, 2009

Comparison of Fuel Consumption, Fun to Drive and System Cost of the different powertrain concepts. liter AVL Turbohybrid prototype delivered a 24% reduction in fuel consumption on the NEDC compared to the 2.0L liter AVL Turbohybrid prototype delivered a 24% reduction in fuel consumption on the NEDC compared to the 2.0L

Hybrid 150

Hybrid Concept Downsizing Fuel 150

Green Car Congress

FEBRUARY 20, 2013

There are four elements when in place that Nissan thinks will encourage wider market adoption of hybrids, Thunes said: affordable cost; meaningful fuel economy gains; a rational evolution from conventional powertrains to hybrid powertrains; and preserving cabin space and cargo area. —Owen Thunes. Torque exceeds the 3.5L

Engine 220

Engine Hybrid Fuel Economy Li-ion 220

Green Car Congress

APRIL 18, 2013

Without CCS, the world will have to abandon its reliance on fossil fuels much sooner—and that will come at a cost. Emerging economies are stepping up their efforts to promote and develop clean energy. The costs of most clean energy technologies fell more rapidly than anticipated. billion to US$4.2

Carbon 265

Carbon Supplies Global Transportation 265

Green Car Congress

SEPTEMBER 29, 2011

The higher-voltage variant will support moves by European vehicle manufacturers announced earlier this year to introduce 48 volt passenger vehicle power networks to help meet the requirement for lower fuel consumption and CO 2 emissions. TDI models, but even lower CO 2 emissions and fuel consumption than the current production 1.4l

Volt 207

Volt Hybrid Downsizing Lead Acid 207

Green Car Congress

JUNE 18, 2013

Bosch does not believe there is just one powertrain solution for the future; most of the cars on the world’s roads are still running on diesel and gasoline, and things will stay that way for the rest of the decade, Bohr noted. Only the diesel engine will achieve this in the compact class, but the gasoline engine will come close.

Future 291

Future Gasoline-Electric Vehicles Gasoline 291

Green Car Congress

OCTOBER 10, 2012

The analysis used the Ohio State University EcoCAR, a student prototype PHEV, as the basis for the preliminary fuel economy evaluation. This evolution has led to the point where achieving significant fuel savings through the introduction of new technologies has become difficult. The OSU EcoCAR PHEV powertrain. Power from ORC.

Waste 312

Waste PHEV Fuel Exhaust 312

Green Car Congress

JUNE 22, 2013

The new engine will achieve high efficiency using the Atkinson Cycle with an 18:1 compression ratio, combined with aggressive engine downsizing. Envera specializes in the development of advanced technologies for improving automotive fuel economy. Engine downsizing is a key tool in improving fuel economy.

Engine 207

Engine Eaton Fuel Economy Downsizing 207

Green Car Congress

JANUARY 26, 2010

Based on test work already carried out, Ricardo estimates that a fuel economy improvement of up to 30% is possible with no loss of power or performance, using a downsized EBDI engine in place of currently available gasoline powertrain technology. fuel economy improvement. Ricardo is replacing a 6.6-liter

Engine 218

Engine Fuel Economy Energy Gasoline 218

Green Car Congress

JULY 12, 2013

GM’s fuel-economy plan through the 2016 model year focuses on a reduction in vehicle mass and aggressive investment in advanced materials, such as high-strength steel, carbon fiber and aluminum, enabled in part by our industry-first aluminum welding technology. Earlier post.). Manufacturing energy use and emissions. MWh/vehicle.

GM 275

GM MPG Manufacturer 2017 275

Green Car Congress

JUNE 4, 2010

However, the technologies would also increase vehicle purchase costs for consumers, sometimes by as much as several thousand dollars. Replacing spark-ignition engines with diesel engines and components would yield fuel savings of about 37% at an added cost of approximately $5,900 per vehicle. Engines and Technologies.

Purchase 210

Purchase Lithium Ion Fuel Available 210

Green Car Congress

DECEMBER 9, 2016

By rightsizing engines with available technologies, automakers are able to continue applying the benefits of smaller turbocharged engines while fine-tuning powertrain systems to further optimize fuel economy, emissions and performance. Regional highlights include: In North America, more engine downsizing is expected.

Global 150

Global Sale Transportation Vehicles 150

Green Car Congress

MARCH 4, 2009

Fiat expects that Multiair, with direct control of the air through the intake engine valves without using the throttle, can help reduce fuel consumption by up to 10% for turbocharged or naturally aspirated gasoline engines. A specific turbocharged engine version will be bi-fuel (gasoline-CNG).

Downsizing 210

Downsizing Gasoline Fuel Economy Engine 210

Green Car Congress

MAY 17, 2013

Relative changes in vehicle energy efficiency (VEE) (km/MJ) on ethanol/gasoline blends over those on gasoline for different blending levels. Several recent highly cited LCAs that have incorporated vehicle efficiency differences between gasoline and ethanol/gasoline blends could potentially be misleading. Click to enlarge.

Fuel 210

Fuel Energy Gasoline-Electric Gasoline 210

Green Car Congress

MAY 13, 2010

The new venture, which will be called “Rotrak”, will add Torotrak’s variable speed traction drive to Rotrex’ supercharging technology to address the automotive industry’s need for affordable, effective engine downsizing technologies. As part of the agreement, Torotrak will acquire a 15% stake in Rotrex and a seat on the company’s board.

Downsizing 268

Downsizing Engine Denmark Fuel Economy 268

Green Car Congress

APRIL 26, 2009

The resulting higher BMEP levels allow downsizing of the engine at equivalent vehicle performance. The vehicle owner will realize high fuel economy because gasoline, with its greater eating value per volume, is the fuel that is primarily used for most driving modes. E85 DI + gasoline PFI engine in a pickup truck.

Diesel 170

Diesel Ford F-150 Gasoline 170

Green Car Congress

APRIL 23, 2012

An increase in pumping requirements for any reason carries a fuel economy penalty. Scuderi explained that “Millerizing” the Scuderi split cycle means downsizing the compression cylinder to get the over-expansion technique that is the core of the Miller approach—achieved in a convention engine by using early or late valve closing.

Engine 294

Engine Design Congress Downsizing 294

Green Car Congress

DECEMBER 1, 2014

This means that in addition the power demand is more difficult to achieve with engine downsizing and transmission down-speeding alone. Thermal management of the electrical machine is another critical factor, because the duration of the boosting and energy recovery operating modes directly impacts fuel economy and emissions.

Standards 257

Standards International Vehicles Hybrid 257

Green Car Congress

DECEMBER 17, 2015

Achates Power will work with Delphi Automotive and Argonne National Laboratory on its ARPA-E-funded project to develop an innovative opposed-piston, gasoline compression ignition (OPGCI) engine. liter opposed-piston, gasoline compression ignition engine applicable to large passenger vehicles, pick-up trucks, SUVs and minivans.

Downsizing 150

Downsizing Engine Fuel Gasoline 150

Green Car Congress

OCTOBER 31, 2016

A new white paper published by the International Council on Clean Transportation (ICCT), in collaboration with Eaton, Ricardo, JCI, BorgWarner, Honeywell, and the ITB Group, analyzes current turbocharged, downsized gasoline engine technology developments and trends.

Downsizing 150

Downsizing EPA Engine Eaton 150

Green Car Congress

OCTOBER 8, 2015

The additional control of compressed air for transient performance provided by Cobra means that we can purge diesel particulate filters and other forms of exhaust after-treatment for NO x reduction and, most importantly, without compromising fuel economy. Phil Bush, technology manager at Eminox. —Andy Dickinson. Earlier post.)

Vehicles 150

Vehicles Exhaust Emissions Diesel 150

Green Car Congress

AUGUST 16, 2016

One initiative, SuperTruck II ( earlier post ), will award $80 million to four projects to develop and to demonstrate cost-effective technologies that more than double the freight efficiency of Class 8 trucks. Accelerated Development and Deployment of Low‐Cost Automotive Mg Sheet Components (Area of Interest 3). Description.

Vehicles 150

Vehicles Plug-in Lithium Ion Universal 150

Green Car Congress

NOVEMBER 16, 2011

The US Environmental Protection Agency (EPA) and the US Department of Transportation (DOT) formally unveiled their joint proposal to set stronger fuel economy and greenhouse gas pollution standards for Model Year 2017-2025 passenger cars and light trucks. L/100km), if the vehicles were to meet this CO 2 level all through fuel economy.

Fuel Economy 338

Fuel Economy EPA Economy MPG 338

Green Car Congress

JUNE 23, 2014

The project is scheduled to end 31 December of this year; Ford is likely to request a no-cost extension to 30 September 2015. Ford’s approach to the project was to engineer a comprehensive suite of gasoline engine systems technologies, including: Aggressive engine downsizing in a mid-sized sedan from a large V-6 to a small I-4.

Fuel Economy 247

Fuel Economy Economy Ford Engine 247