Conference, Downsizing, Economy and Gasoline

HyBoost concept achieving close to Prius-level CO2 emissions; aggressive downsizing with advanced boosting and micro-hybrid system

Green Car Congress

NOVEMBER 1, 2011

variant but with fuel economy of a strong hybrid. HyBoost achieves this by combining aggressive 50% downsizing of the engine with an electric supercharger for transient low-speed performance, and a micro-hybrid stop-start and energy recuperation systems, Boggs said. Downsizing the 2.0-liter Click to enlarge. Click to enlarge.

Downsizing

Downsizing Prius Hybrid Emissions

ACCESS project targeting 30% improvement in fuel economy and SULEV emissions in light-duty gasoline engine; multi-mode SI/HCCI combustion

Green Car Congress

NOVEMBER 4, 2011

Hakan Yilmaz, Global Technology Management, Gasoline Systems, for Bosch presented an overview of and update on the project at the 2011 DEER conference in Detroit in October. Two-stage boost—a small supercharger for HCCI, and a regular turbocharger for downsizing. HCCI range extension with boosting. Source: Bosch.

Fuel Economy

Fuel Economy Gasoline Light Engine

FEV’s two-stage VCR system; 5-7% increase in fuel economy using variable length conrods

Green Car Congress

APRIL 22, 2013

downsized, turbocharged) gasoline engine, as operating an engine with higher compression ratios at low load can increase fuel economy compared to operating an engine with fixed compression ratio. Haake (2012) Two-Stage Variable Compression Ratio (VCR) System to Increase Efficiency in Gasoline Powertrains. Kleeberg, H.,

Fuel Economy

Fuel Economy Economy Fuel Downsizing

Ricardo HyBoost “Intelligent Electrification” project awarded automotive environmental prize by Institution of Mechanical Engineers

Green Car Congress

OCTOBER 11, 2013

The Automobile Division of the Institution of Mechanical Engineers has awarded its Prize for the Environment to Ricardo, Ford Motor Company, Controlled Power Technologies and Valeo engineers for their paper HyBoost—An Intelligently Electrified Optimized Downsized Gasoline Engine Concept. Earlier post.). Earlier post.)

Engine

Engine Downsizing Lead Acid Automobile

Ford / AVL study concludes mid-level ethanol blend attractive as a long-term future fuel for use in optimized engines in US

Green Car Congress

APRIL 19, 2013

Ford engineers also presented two other papers evaluating the effects of low to mid-level ethanol blends in spark-ignited engines at the conference. The study by the Ford / AVL team provides an overview of the effects of such a future ethanol-gasoline blend in such an engine. (As and of gasoline, about 14.6 Earlier post.)

Engine

Engine Fuel Ford Future

Hyundai outlines future powertrain strategy

Green Car Congress

OCTOBER 25, 2012

Hyundai Motor Group this week outlined its latest powertrain technologies and future plans at the 12 th Hyundai-Kia International Powertrain Conference, held near the Hyundai Motor Group R&D Center in Korea. In keeping with the trend to downsizing, Hyundai has been expanding the application of Turbo Gasoline Direct Injection (T-GDI) engines.

Hyundai

Hyundai Future Exhaust Gasoline

Advanced Turbocharged, Direct Injected Gasoline Engines Poised to Take on Diesels in US and in Europe for Reduced Fuel Consumption and Emissions

Green Car Congress

AUGUST 10, 2009

Cackette was in effect suggesting that the future tailpipe emissions baseline (LEV III) for light duty passenger vehicles—both diesel and gasoline—was likely to be or to approximate CA SULEV/US Tier 2 Bin 2. We see dramatic downsizing and boosting [as] something that’s going to for gasoline engines especially.

Gasoline

Gasoline Diesel Engine Emissions

CPT/AVL Study: New Generation of Micro-Hybrid Technologies Can Enable More than 25% Reduction in Fuel Consumption at Lower Cost Than Full Hybrid Drive Systems

Green Car Congress

SEPTEMBER 13, 2010

liter ELC-Hybrid to downsized 1.4L VTES + SpeedStart. The intent is to enable aggressive yet near term downsizing and downspeeding of existing engine families, delivering proven CO reduction and fuel economy improvement, without the usual dynamic compromises that typically limit market acceptance.

VRLA

VRLA Hybrid Downsizing Fuel

Ford Making Aggressive Push With EcoBoost and Technologies Such as Ti-VCT for Improved Fuel Economy; Roadmap for Future Generations of EcoBoost Highlights Role as Company Strategy as Well as Product

Green Car Congress

DECEMBER 20, 2009

As part of an aggressive deployment strategy for improving fuel efficiency across its product line-up in the near-to medium-term, Ford will offer its first-generation turbocharged, gasoline direct-injection EcoBoost engines ( earlier post ) in 90% of its product lineup by 2013. Planning background. ” First-generation EcoBoost.

Fuel Economy

Fuel Economy Economy Ford Downsizing

CPT developing 48-volt electric supercharger for micro-mild hybrids

Green Car Congress

SEPTEMBER 29, 2011

At 48 volts, a VTES electric supercharger will transform 7kW of battery power into a highly boosted charge of air for downsized gasoline and diesel engines. There will be no torque deficit or other tradeoffs from essential engine downsizing and higher gearing, which now dominates the development of internal combustion engines.

Volt

Volt Hybrid Downsizing Lead Acid

Eaton launches new, more efficient TVS2 supercharger; targeting super-turbo systems

Green Car Congress

SEPTEMBER 25, 2015

The announcement came at the 20 th Supercharging Conference in Dresden, Germany. Key elements of this new design include: Rotor profile changes to reduce the clearance between the rotors reducing internal leakage; Modifying the twist of the rotors to shift the peak efficiency to a location that improves overall fuel economy; and.

Eaton

Eaton Fuel Economy Downsizing Engine

Simulation study suggests ORC waste heat recovery system could deliver potential 7% improvement in fuel consumption in a PHEV on highway

Green Car Congress

OCTOBER 10, 2012

Their paper was presented at the ASME Internal Combustion Engine Division 2012 Fall Technical Conference by Marcello Canova, assistant professor at OSU; lead author was Philipp Skarke, from the University of Stuttgart Institute for Internal Combustion Engines and Automotive Engineering. The OSU EcoCAR PHEV powertrain.

Waste

Waste PHEV Fuel Exhaust

Calls for an international 48V electrical standard for vehicles; looming WLTP implementation

Green Car Congress

DECEMBER 1, 2014

At the 2 nd International Conference Automotive 48 V Power Supply Systems , held last week in Düsseldorf, Germany, Controlled Power Technologies (CPT), a major sponsor of the event, together with leading car makers and Tier 1 suppliers, argued the need for an internationally agreed 48V electrical standard. The conference.

Standards

Standards International Vehicles Hybrid

CPT VTES Electric Supercharger Selected for Two Projects

Green Car Congress

SEPTEMBER 22, 2009

When applied to a radically downsized 1.2-liter liter naturally aspirated engine, the downsized engine with electric supercharger reduces the 70-100 km/h (44-63 mph) top gear acceleration time from 18 to 11 seconds. CPT will showcase VTES at the international supercharging conference held in Dresden 24-25 September 2009.

Downsizing

Downsizing Electrical Electric Exhaust

AVL Concept Turbohybrid Mild Hybrid System Approaches Full Hybrid Fuel Savings at Lower Cost; Improved Driveability

Green Car Congress

FEBRUARY 4, 2009

Downsizing a gasoline engine (e.g., AVL reasoned that merging turbocharged GDI with a mild hybrid function can result in excellent driveability even with the combination of strong downsizing and downspeeding. Comparison of Fuel Consumption, Fun to Drive and System Cost of the different powertrain concepts. Click to enlarge.

Hybrid

Hybrid Concept Downsizing Fuel

Toyota Aims to Reduce Fuel Cell Vehicle Cost to 1/10 of Current By Commercialization in 2015; Reduction to Another 1/10 With Scale

Green Car Congress

OCTOBER 4, 2009

In a news conference at the Japan National Press Club on Friday, Toyota Motor President Akio Toyoda said that the company plans to begin mass production of electric vehicles in the US in 2012, followed by US production of fuel cell vehicles in 2015. Toyota’s targeted cost reductions in fuel cell vehicles. Source: Toyota.

2015

2015 Toyota Commercial Fuel

CPT and Eminox to collaborate on development of retrofit electric supercharging and aftertreatment solutions for heavy-duty vehicles

Green Car Congress

OCTOBER 8, 2015

The additional control of compressed air for transient performance provided by Cobra means that we can purge diesel particulate filters and other forms of exhaust after-treatment for NO x reduction and, most importantly, without compromising fuel economy. Phil Bush, technology manager at Eminox. —Andy Dickinson. Earlier post.)

Vehicles

Vehicles Exhaust Emissions Diesel

Using the PHEV (Plug-In Hybrid Electric Vehicle) to Transition Society Seamlessly and Profitably From Fossil Fuel to 100% Renewable Energy

Green Car Congress

JULY 17, 2015

Though the PHEV combines the two types of energy and power, it is not merely a temporary “transition” between gasoline and diesel cars to pure electric cars. Since it can refuel from a standard household outlet and from a gasoline station, it needs no new infrastructure. It is much more than that. Engineering Advantages of the PHEV.

PHEV

PHEV Plug-in Renewable Energy

How Carmakers Are Responding to the Plug-In Hybrid Opportunity

Tony Karrer Delicious EVdriven

APRIL 21, 2009

Company says its focusing on gasoline and hydrogen. USA Today ) 10/25/06 DaimlerChrysler is downright reluctant, even though it has built four test models, commercial-size vans that run on gasoline and electricity. Hybrid Sonata model year 2011, possible PHEV version in 2013. No announced plans. Red Herring ).

Plug-in

Plug-in Plug Hybrid PHEV

EV Driven

HyBoost concept achieving close to Prius-level CO2 emissions; aggressive downsizing with advanced boosting and micro-hybrid system

ACCESS project targeting 30% improvement in fuel economy and SULEV emissions in light-duty gasoline engine; multi-mode SI/HCCI combustion

FEV’s two-stage VCR system; 5-7% increase in fuel economy using variable length conrods

Ricardo HyBoost “Intelligent Electrification” project awarded automotive environmental prize by Institution of Mechanical Engineers

Ford / AVL study concludes mid-level ethanol blend attractive as a long-term future fuel for use in optimized engines in US

Hyundai outlines future powertrain strategy

Advanced Turbocharged, Direct Injected Gasoline Engines Poised to Take on Diesels in US and in Europe for Reduced Fuel Consumption and Emissions

CPT/AVL Study: New Generation of Micro-Hybrid Technologies Can Enable More than 25% Reduction in Fuel Consumption at Lower Cost Than Full Hybrid Drive Systems

Ford Making Aggressive Push With EcoBoost and Technologies Such as Ti-VCT for Improved Fuel Economy; Roadmap for Future Generations of EcoBoost Highlights Role as Company Strategy as Well as Product

CPT developing 48-volt electric supercharger for micro-mild hybrids

Eaton launches new, more efficient TVS2 supercharger; targeting super-turbo systems

Simulation study suggests ORC waste heat recovery system could deliver potential 7% improvement in fuel consumption in a PHEV on highway

Calls for an international 48V electrical standard for vehicles; looming WLTP implementation

CPT VTES Electric Supercharger Selected for Two Projects

AVL Concept Turbohybrid Mild Hybrid System Approaches Full Hybrid Fuel Savings at Lower Cost; Improved Driveability

Toyota Aims to Reduce Fuel Cell Vehicle Cost to 1/10 of Current By Commercialization in 2015; Reduction to Another 1/10 With Scale

CPT and Eminox to collaborate on development of retrofit electric supercharging and aftertreatment solutions for heavy-duty vehicles

Using the PHEV (Plug-In Hybrid Electric Vehicle) to Transition Society Seamlessly and Profitably From Fossil Fuel to 100% Renewable Energy

How Carmakers Are Responding to the Plug-In Hybrid Opportunity

Stay Connected