Brake Recall Impacts 124,000 Honda and Acura Vehicles

by Matt Posky

Published: July 11th, 2023

brake recall impacts 124 000 honda and acura vehicles

A handful of Honda models, and one from Acura, are under recall over a defect that could limit braking functionality. Impacted vehicles include the 2020-2021 Honda Civic, 2021-2023 Honda Passport, 2021-2022 Honda Pilot, 2020-2023 Honda Ridgeline, and 2020 Acura MDX.

A recall report filed with the National Highway Traffic Safety Administration (NHTSA) specifies improper assembly of the tie rod fastener that’s connected to the brake master cylinder and booster. Altogether, the recall encompasses 124,077 individual vehicles.

From the report:

The brake master cylinder may have been improperly fastened to the brake booster assembly during production, resulting in loose or missing tie rod nuts. During application of the brake pedal, a bending load may occur upon the brake booster assembly tie rod studs. As a result, the tie rod studs may break, leading to the brake master cylinder separating from the brake booster assembly and a failure to comply with Federal Motor Vehicle Safety Standards (FMVSS) 135 – Light vehicle brake systems.

Obviously, having the master cylinder separate from the brake booster isn’t going to improve anybody’s stopping power. Diminished braking performance is a given, with there being a possibility of a total loss of braking function. The report also states that there probably won’t be any warnings issued to drivers via instrumentation if something goes wrong.

It also blames the supplier, VBS, after Honda found a missing nut in 2020. VBS “implemented countermeasures” to ensure there were no additional defects. However, Honda received a quality report on brake failure in 2022 that encouraged the company to launch a full investigation.

VBS submitted part defect reports to the NHTSA earlier this year, followed by the serial numbers of the suspected parts involved in their recall as Honda continued its investigation. By June, Honda determined that a defect related to motor vehicle safety and FMVSS noncompliance existed and decided to conduct a safety and noncompliance recall.

At the time, Honda had received two warranty claims related to the issue between September 2022 to June 2023. There were no reports of crashes, injuries, or deaths related to this issue.

The manufacturer intends on issuing formal recall notices in August. But concerned owners can head over to the NHTSA recall website to determine whether their car is included in the recall campaign. Just be sure to have your VIN handy.

[Image: Honda]

Become a TTAC insider. Get the latest news, features, TTAC takes, and everything else that gets to the truth about cars first by subscribing to our newsletter.

#NewsBlog #Recalls #Safety #Honda #Acura #NHTSA #Ridgeline #Civic #Passport #Pilot #MDX

Matt Posky

A staunch consumer advocate tracking industry trends and regulation. Before joining TTAC, Matt spent a decade working for marketing and research firms based in NYC. Clients included several of the world’s largest automakers, global tire brands, and aftermarket part suppliers. Dissatisfied with the corporate world and resentful of having to wear suits everyday, he pivoted to writing about cars. Since then, that man has become an ardent supporter of the right-to-repair movement, been interviewed on the auto industry by national radio broadcasts, driven more rental cars than anyone ever should, participated in amateur rallying events, and received the requisite minimum training as sanctioned by the SCCA. Handy with a wrench, Matt grew up surrounded by Detroit auto workers and managed to get a pizza delivery job before he was legally eligible. He later found himself driving box trucks through Manhattan, guaranteeing future sympathy for actual truckers. He continues to conduct research pertaining to the automotive sector as an independent contractor and has since moved back to his native Michigan, closer to where the cars are born. A contrarian, Matt claims to prefer understeer — stating that front and all-wheel drive vehicles cater best to his driving style.

More by Matt Posky

Comments

Join the conversation

3 of 5 comments

ToolGuy on Jul 11, 2023

"December 2020 Honda manufacturing found a missing nut missing from the brake booster assembly tie rods and notified the component part supplier, VBS. VBS implemented countermeasures to prevent a reoccurrence. No outflow from the occurrence was found."
• What does that last sentence mean exactly? (Your individual spin is welcome)

1 Reply
- SPPPP on Jul 12, 2023
  
  My guess is that Honda determined that none of the batch of parts had yet been installed in a car.
  
  1
Sgeffe on Jul 11, 2023

I'll give Honda props for getting after the problem, unlike a certain company headquartered in downtown Detroit in a certain cylindrical skyscraper with ignition switches!

Like Reply

Recent Comments

Bd2 Lexus is just a higher trim package Toyota. ^^
Tassos ONLY consider CIvics or Corollas, in their segment. NO DAMNED Hyundais, Kias, Nissans or esp Mitsus. Not even a Pretend-BMW Mazda. They may look cute but they SUCK.I always recommend Corollas to friends of mine who are not auto enthusiasts, even tho I never owed one, and owned a Civic Hatch 5 speed 1992 for 25 years. MANY follow my advice and are VERY happy. ALmost all are women.friends who believe they are auto enthusiasts would not listen to me anyway, and would never buy a Toyota. They are damned fools, on both counts.
Tassos since Oct 2016 I drive a 2007 E320 Bluetec and since April 2017 also a 2008 E320 Bluetec.Now I am in my summer palace deep in the Eurozone until end October and drive the 2008.Changing the considerable oils (10 quarts synthetic) twice cost me 80 and 70 euros. Same changes in the US on the 2007 cost me $219 at the dealers and $120 at Firestone.Changing the air filter cost 30 Euros, with labor, and there are two such filters (engine and cabin), and changing the fuel filter only 50 euros, while in the US they asked for... $400. You can safely bet I declined and told them what to do with their gold-plated filter. And when I changed it in Europe, I looked at the old one and it was clean as a whistle.A set of Continentals tires, installed etc, 300 EurosI can't remember anything else for the 2008. For the 2007, a brand new set of manual rec'd tires at Discount Tire with free rotations for life used up the $500 allowance the dealer gave me when I bought it (tires only had 5000 miles left on them then)So, as you can see, I spent less than even if I owned a Lexus instead, and probably less than all these poor devils here that brag about their alleged low cost Datsun-Mitsus and Hyundai-Kias.And that's THETRUTHABOUTCARS. My Cars,
NJRide These are the Q1 Luxury division salesAudi 44,226Acura 30,373BMW 84,475Genesis 14,777Mercedes 66,000Lexus 78,471Infiniti 13,904Volvo 30,000*Tesla (maybe not luxury but relevant): 125,000?Lincoln 24,894Cadillac 35,451So Cadillac is now stuck as a second-tier player with names like Volvo. Even German 3rd wheel Audi is outselling them. Where to gain sales?Surprisingly a decline of Tesla could boost Cadillac EVs. Tesla sort of is now in the old Buick-Mercury upper middle of the market. If lets say the market stays the same, but another 15-20% leave Tesla I could see some going for a Caddy EV or hybrid, but is the division ready to meet them?In terms of the mainstream luxury brands, Lexus is probably a better benchmark than BMW. Lexus is basically doing a modern interpretation of what Cadillac/upscale Olds/Buick used to completely dominate. But Lexus' only downfall is the lack of emotion, something Cadillac at least used to be good at. The Escalade still has far more styling and brand ID than most of Lexus. So match Lexus' quality but out-do them on comfort and styling. Yes a lot of Lexus buyers may be Toyota or import loyal but there are a lot who are former GM buyers who would "come home" for a better product.In fact, that by and large is the Big 3's problem. In the 80s and 90s they would try to win back "import intenders" and this at least slowed the market share erosion. I feel like around 2000 they gave this up and resorted to a ton of gimmicks before the bankruptcies. So they have dropped from 66% to 37% of the market in a quarter century. Sure they have scaled down their presence and for the last 14 years preserved profit. But in the largest, most prosperous market in the world they are not leading. I mean who would think the Koreans could take almost 10% of the market? But they did because they built and structured products people wanted. (I also think the excess reliance on overseas assembly by the Big 3 hurts them vs more import brands building in US). But the domestics should really be at 60% of their home market and the fact that they are not speaks volumes. Cadillac should not be losing 2-1 to Lexus and BMW.
Tassos Not my favorite Eldorados. Too much cowbell (fins), the gauges look poor for such an expensive car, the interior has too many shiny bits but does not scream "flagship luxury", and the white on red leather or whatever is rather loud for this car, while it might work in a Corvette. But do not despair, a couple more years and the exterior designs (at least) will sober up, the cowbells will be more discreet and the long, low and wide 60s designs are not far away. If only the interiors would be fit for the price point, and especially a few acres of real wood that also looked real.