Fire Risk: Hyundai and Kia Recall More Than Three Million Vehicles

Chris Teague
by Chris Teague

Though EV fires receive a tremendous amount of attention in the news, they are far less common proportionally than gas vehicle fires. Sure, we’ve seen a few massive recalls for EV fires in recent years, including a massive campaign involving every Chevy Bolt and Bolt EUV made between 2017 and 2023, but gas vehicles are still more likely to catch fire. Hyundai and Kia are the latest manufacturers to issue a fire-related recall, this time for millions of gas vehicles with faulty hydraulic electronic control units (HECU) and antilock brake modules. 


The affected Kia vehicles’ HECUs can experience an electrical short as they age, which causes excess electrical current, increasing the fire risk. The automaker said the exact cause of the short is unknown but noted that fires could occur when the vehicle is parked or in use. In total, the recall wrapped up more than three million vehicles from both automakers, with around 1.7 million Kias and 1.6 million Hyundais.  


Kia’s recalling several models, including:

·      2010-2019 Borrego

·      2014-2016 Cadenza 

·      2010-2013 Forte (includes Koup)

·      2010-2013 Sportage

·      2015-2018 K900

·      2011-2015 Optima (2011-2013 Optima Hybrid)

·      2011-2013 Soul

·      2012-2017 Rio

·      2010-2011 Rondo

·      2011-2014 Sorento


While fire-related, Hyundai’s recall is due to issues with the antilock brake system module. Similar to Kia’s HECU problems, the ABS in some Hyundai models can experience an electrical overcurrent, increasing the fire risk. Recall documentation states that the O-ring material in the ABS can be damaged over time, allowing brake fluid to leak onto electrical components.


 The list of Hyundai models involved in the recall includes:

·      2012-2015 Accent

·      2012-2015 Azera

·      2011-2015 Elantra

·      2011-2015 Genesis Coupe (prior to Genesis becoming a separate brand)

·      2011-2015 Sonata Hybrid

·      2012-2015 Veloster

·      2010-2012 Veracruz

·      2013 Santa Fe Sport

·      2014-2015 Equus

·      2013-2015 Santa Fe

·      2010-2013 Tucson

Hyundai said it is aware of 21 fires and 22 “thermal incidents” (sounds a lot like a fire) related to the problem. Both automakers noted that owners can continue driving their vehicles but advised that they must be parked outside and away from structures. Kia dealers will replace the HECU unit if required, and Hyundai stores will replace ABS fuses if there is a problem.


[Image: Hyundai]


Become a TTAC insider. Get the latest news, features, TTAC takes, and everything else that gets to the truth about cars first by  subscribing to our newsletter.

Chris Teague
Chris Teague

Chris grew up in, under, and around cars, but took the long way around to becoming an automotive writer. After a career in technology consulting and a trip through business school, Chris began writing about the automotive industry as a way to reconnect with his passion and get behind the wheel of a new car every week. He focuses on taking complex industry stories and making them digestible by any reader. Just don’t expect him to stay away from high-mileage Porsches.

More by Chris Teague

Comments
Join the conversation
3 of 27 comments
  • The Oracle The Oracle on Oct 01, 2023

    Good news is that based on the model years many of these have already been junked or experienced terminal engine failure.

  • Laura Laura on Oct 01, 2023

    I just buy a Hyndai Elantra SEL, and My car started to have issues with the AC dont work the air sometimes is really hot and later cold and also I heard a noice in the engine so I went to the dealer for the first service and explain what was hapenning to the AC they told me that the car was getting hot because the vent is not working I didnt know that the car was getting hot because it doesnt show nothing no sign no beep nothing I was surprise and also I notice that it needed engine oil, I think that something is wrong with this car because is a model 23 and I just got it on April only 5 months use. is this normal ? Also my daughter bought the same model and she went for a trip and the car also got hot and it didnt show up in the system she called them and they said to take the car to the dealer for a check up I think that if the cars are new they shouldnt be having this problems.

    • 28-Cars-Later 28-Cars-Later on Oct 01, 2023

      Something similar happened to the compressor of a friend's Toyota @ 110K, the diagnosis was the electronics or a sensor in the compressor itself. She had it replaced at my guy's shop and fortunately it took R134a so the whole process was only around $850.



  • Bd2 Lexus is just a higher trim package Toyota. ^^
  • Tassos ONLY consider CIvics or Corollas, in their segment. NO DAMNED Hyundais, Kias, Nissans or esp Mitsus. Not even a Pretend-BMW Mazda. They may look cute but they SUCK.I always recommend Corollas to friends of mine who are not auto enthusiasts, even tho I never owed one, and owned a Civic Hatch 5 speed 1992 for 25 years. MANY follow my advice and are VERY happy. ALmost all are women.friends who believe they are auto enthusiasts would not listen to me anyway, and would never buy a Toyota. They are damned fools, on both counts.
  • Tassos since Oct 2016 I drive a 2007 E320 Bluetec and since April 2017 also a 2008 E320 Bluetec.Now I am in my summer palace deep in the Eurozone until end October and drive the 2008.Changing the considerable oils (10 quarts synthetic) twice cost me 80 and 70 euros. Same changes in the US on the 2007 cost me $219 at the dealers and $120 at Firestone.Changing the air filter cost 30 Euros, with labor, and there are two such filters (engine and cabin), and changing the fuel filter only 50 euros, while in the US they asked for... $400. You can safely bet I declined and told them what to do with their gold-plated filter. And when I changed it in Europe, I looked at the old one and it was clean as a whistle.A set of Continentals tires, installed etc, 300 EurosI can't remember anything else for the 2008. For the 2007, a brand new set of manual rec'd tires at Discount Tire with free rotations for life used up the $500 allowance the dealer gave me when I bought it (tires only had 5000 miles left on them then)So, as you can see, I spent less than even if I owned a Lexus instead, and probably less than all these poor devils here that brag about their alleged low cost Datsun-Mitsus and Hyundai-Kias.And that's THETRUTHABOUTCARS. My Cars,
  • NJRide These are the Q1 Luxury division salesAudi 44,226Acura 30,373BMW 84,475Genesis 14,777Mercedes 66,000Lexus 78,471Infiniti 13,904Volvo 30,000*Tesla (maybe not luxury but relevant): 125,000?Lincoln 24,894Cadillac 35,451So Cadillac is now stuck as a second-tier player with names like Volvo. Even German 3rd wheel Audi is outselling them. Where to gain sales?Surprisingly a decline of Tesla could boost Cadillac EVs. Tesla sort of is now in the old Buick-Mercury upper middle of the market. If lets say the market stays the same, but another 15-20% leave Tesla I could see some going for a Caddy EV or hybrid, but is the division ready to meet them?In terms of the mainstream luxury brands, Lexus is probably a better benchmark than BMW. Lexus is basically doing a modern interpretation of what Cadillac/upscale Olds/Buick used to completely dominate. But Lexus' only downfall is the lack of emotion, something Cadillac at least used to be good at. The Escalade still has far more styling and brand ID than most of Lexus. So match Lexus' quality but out-do them on comfort and styling. Yes a lot of Lexus buyers may be Toyota or import loyal but there are a lot who are former GM buyers who would "come home" for a better product.In fact, that by and large is the Big 3's problem. In the 80s and 90s they would try to win back "import intenders" and this at least slowed the market share erosion. I feel like around 2000 they gave this up and resorted to a ton of gimmicks before the bankruptcies. So they have dropped from 66% to 37% of the market in a quarter century. Sure they have scaled down their presence and for the last 14 years preserved profit. But in the largest, most prosperous market in the world they are not leading. I mean who would think the Koreans could take almost 10% of the market? But they did because they built and structured products people wanted. (I also think the excess reliance on overseas assembly by the Big 3 hurts them vs more import brands building in US). But the domestics should really be at 60% of their home market and the fact that they are not speaks volumes. Cadillac should not be losing 2-1 to Lexus and BMW.
  • Tassos Not my favorite Eldorados. Too much cowbell (fins), the gauges look poor for such an expensive car, the interior has too many shiny bits but does not scream "flagship luxury", and the white on red leather or whatever is rather loud for this car, while it might work in a Corvette. But do not despair, a couple more years and the exterior designs (at least) will sober up, the cowbells will be more discreet and the long, low and wide 60s designs are not far away. If only the interiors would be fit for the price point, and especially a few acres of real wood that also looked real.
Next