Green Car Congress

FEBRUARY 5, 2010

Schematic of the conceptual ideal piston engine used for the TCR study. When reforming is not used, the fuel and exhaust pass through CV2 unchanged. When reforming is not used, the fuel and exhaust pass through CV2 unchanged. The syngas is then burned in the engine in place of some or all of the original fuel.

Exhaust 249

Exhaust International Engine Concept 249

Green Car Congress

MAY 18, 2021

Startup ClearFlame Engine Technologies announced a partnership with Alto Ingredients, a leading producer of specialty alcohols and essential ingredients, to conduct pilot demonstrations of ClearFlame’s solution for diesel engines using low-cost ethanol in Class 8 trucks.

Diesel 397

Diesel Emissions Engine Fuel 397

Green Car Congress

OCTOBER 15, 2010

Professor Stan Golunski, Deputy Director of the newly established Cardiff Catalysis Institute , in collaboration with engineers at Brunel and Birmingham Universities, is investigating the feasibility of an on-board exhaust gas reforming system to improve combustion and recover waste heat. Earlier post.).

Exhaust 186

Exhaust Waste Gas 2006 186

Green Car Congress

SEPTEMBER 12, 2012

At the 17 th Supercharging conference this week in Dresden, Controlled Power Technologies (CPT) will launch what it says is the first water-cooled electric supercharger developed for “quasi-continuous” boosting of commercial diesel engines, including those developed for off highway applications. tonnes gross vehicle weight.

Water 370

Water Engine Commercial Diesel 370

Green Car Congress

APRIL 14, 2010

for a project developing a waste heat recovery system using VanDyne’s SuperTurbocharger technology. Effectively, says VanDyne, the SuperTurbocharger can create a “hybrid engine”—the combination of a piston engine working together with a turbine engine. The VanDyne SuperTurbo. Click to enlarge. Downsizing from a 3.2L

Waste 218

Waste Engine Downsizing Hybrid 218

Green Car Congress

APRIL 23, 2014

A consortium led by the Dearman Engine Company has been awarded £1.86 The Dearman project is to deliver a production-feasible waste-heat recovery system for urban commercial vehicles, which offers life-cycle CO 2 savings of up to 40%; fuel savings of 25%, with the potential of up to almost 50%; and potential payback in less than three years.

Waste 246

Waste Engine Land Rover Transportation 246

Green Car Congress

APRIL 9, 2010

(MHI) has completed its first unit of the STG (Super Turbo Generating) System, a marine-use, high-efficiency, combined power generation system that utilizes waste heat and the exhaust gas from diesel engines. Tags: Engines Ports and Marine Waste Heat Recovery. The STG System (Super Turbo Generating System).

Mariner 199

Mariner Waste Mitsubishi Engine 199

Green Car Congress

AUGUST 26, 2012

Opcon, in collaboration with Wallenius Marine, recently completed the first reference installation of its Waste Heat Recovery technology for ocean-going vessels in a project supported by the Swedish Energy Agency. The Opcon systems generate electricity from low-value waste heat in the vessel’s steam and cooling system. Earlier post.)

Waste 300

Waste Installation Mariner Fuel 300

Green Car Congress

SEPTEMBER 4, 2013

developer of the all-fuel, Cyclone external combustion engine, announced that its subsidiary Cyclone-WHE LLC and production partner Precision CNC LLC have signed a lease for a new manufacturing facility located in Lancaster, Ohio. The WHE is a self-starting Rankine cycle engine capable of using low to medium-temperature waste heat sources.

Waste 220

Waste Engine Production Ohio 220

Green Car Congress

AUGUST 22, 2013

The European Union-funded PowerDriver project—a two-year, €3-million (US$4-million) research project initiated in February 2012 to turn exhaust gas waste heat into electricity using thermoelectric generator (TGEN) technology—has completed simulation work on on a potential automotive application.

Exhaust 210

Exhaust Waste Land Rover Fuel 210

Green Car Congress

MAY 2, 2016

the criteria pollutants and CO 2 that emerge with the exhaust from the tailpipe. However, there is more than 15 years of research showing that the contribution of non-exhaust primary particles to the total traffic generated primary particles is significant in urban areas. Further, a 2013 review by Denier van der Gon et al. Background.

Exhaust 278

Exhaust Emissions Belgium Gasoline-Electric 278

Green Car Congress

MARCH 27, 2015

Testing was also conducted at the DTNA Detroit engineering facility to demonstrate engine efficiency by achieving 50.2% engine brake thermal efficiency. liter engine, a hybrid system, a Waste Heat Recovery (WHR) system, along with a number of other upgrades. mpg (19.26

2009 366

2009 Engine Detroit Oregon 366

Green Car Congress

AUGUST 26, 2010

MHI) has developed a generator-integrated hybrid turbocharger for marine propulsion diesel engines which utilizes engine exhaust gas not only to drive the turbocharger but also to generate electricity. Mitsubishi Heavy Industries, Ltd. Cutaway view of MET83MAG hybrid turbocharger. Click to enlarge.

Exhaust 199

Exhaust Mariner Gas-Electric Gas 199

Green Car Congress

OCTOBER 29, 2014

Before they can be used, however, it is essential to understand their physical properties, combustion chemistry, and characterization of the exhaust due to a number of issues associated with fuel properties—for example, a lower heating value and higher cloud point than regular diesel. Kumar et al.

Exhaust 312

Exhaust Oil Emissions Carbon 312

Green Car Congress

FEBRUARY 21, 2011

Mærsk Line has signed a contract with Korea’s Daewoo Shipbuilding & Marine Engineering Co., Two ‘ultra-long stroke’ engines turn two propellers, and specially optimized hull and bow forms guide the vessel through the water at the speeds typical in the industry today. Waste heat recovery. Rendering of the Triple-E.

Waste 239

Waste Engine Asia CO2 239

Green Car Congress

JUNE 24, 2015

The company also announced it will partner with Borla jointly to develop and to commercialize a next-generation-exhaust system incorporating PowerModules, with the goal of delivering significant fuel savings for commercial fleet truck fleets. —saving 52,500 liters of diesel fuel per year, per engine. 2014.11.002.

Waste 246

Waste Energy Exhaust 2014 246

Green Car Congress

MAY 4, 2011

Cyclone Power Technologies, developer of the external combustion Cyclone Engine, announced that the US Patent and Trademark Office has allowed the company a patent on its scalable waste energy recycling engine known as the WHE (Waste Heat Engine). Earlier post.)

Waste 199

Waste Phoenix Engine Powered 199

Green Car Congress

APRIL 3, 2014

The aim is to recover waste heat from the exhaust gases of internal combustion engines in both stationary installations (generators, cogeneration installations) and transport, particularly rail and maritime. Created in 2009, Enogia specializes in ORC (Organic Rankine Cycle) systems converting waste heat into electricity.

Waste 239

Waste Transportation Exhaust Gasoline-Electric 239

Green Car Congress

AUGUST 20, 2013

A team at Monsanto and colleagues at AVL Powertrain have successfully designed and demonstrated an onboard low-temperature ethanol reformer that can be driven by exhaust heat. Many papers have described high-temperature steam reforming of ethanol at around 600 °C but.this temperature is too high to be driven by engine exhaust.

Fuel Economy 230

Fuel Economy Exhaust Economy Fuel 230

Green Car Congress

DECEMBER 24, 2020

Since forming in 2013, Argent Materials, a San Francisco Bay Area recycler of concrete and asphalt, and supplier of aggregate such as crushed rock, entry, cutback, sand, backfill and base rock for construction projects, has diverted more than a billion pounds of waste from local landfills. There’s no change in engine performance.

Renewable 448

Renewable Diesel Fleet Building 448

Green Car Congress

JUNE 2, 2022

The Abfallentsorgungs-Gesellschaft Ruhrgebiet mbH ( AGR ), a waste management company in Herten, North Rhine-Westphalia, Germany, has put a converted DAF CF 340 hydrogen fuel cell truck into operation as part of the EU-funded HECTOR (Hydrogen Waste Collection Vehicles in North West Europe) project.

Convert 444

Convert Hydrogen Parts Fuel 444

Green Car Congress

OCTOBER 9, 2011

However, in city driving, the ORC system would supply about half of the accessory load requirement for a conventional engine, and only about one-third of the load requirement for a hybrid powertrain, due to the frequent engine off condition, according to the results presented by Quazi Hussain.

Waste 220

Waste Light Ford Vehicles 220

Green Car Congress

SEPTEMBER 11, 2013

Tenneco and Gentherm (formerly BSST/Amerigon) are part of a US Department of Energy (DOE) consortium actively developing a thermoelectric generator (TEG) for capturing waste exhaust heat in vehicles and converting it to electrical energy to be used to power electrical systems within the vehicle. Source: Crane (2013).Click

Fuel Economy 218

Fuel Economy Waste Economy Fuel 218

Green Car Congress

JANUARY 10, 2018

ElectraTherm, a leader in distributed, waste heat to power generation, is working with the Office of Naval Research (ONR), Creare, and the US Naval Academy (USNA) to demonstrate gas turbine waste heat recovery as part of a Small Business Innovation Research project. —Roger Hill, Lead Project Engineer at Creare.

Waste 186

Waste Exhaust Maryland Gas-Electric 186

Green Car Congress

JUNE 3, 2022

a Sumitomo Corporation Group company, jointly demonstrated a new waste heat recovery system based on a thermoelectric generator (TEG), which generates electrical power via exhaust gas heat. The TEG unit was installed in the exhaust pipe at the downstream of the catalyst. With the TEG, 1.9% of CO 2 emissions (i.e.

CO2 329

CO2 Exhaust Waste Gas-Electric 329

Green Car Congress

NOVEMBER 6, 2017

Stena Line is seeking novel, cost-effective approaches to recover energy from exhaust gases from ship engines and to transform it into a more useful energy form (e.g., The company is also interested in efficient turbine systems that generate electricity from the kinetic energy from the massflow and velocity of the exhaust gases.

Exhaust 150

Exhaust Engine Energy Mariner 150

Green Car Congress

JUNE 23, 2016

Ricardo is exploring the value proposition for applications of its novel split-cycle combustion engine ( earlier post ). Ricardo, in collaboration with the University of Brighton, has been developing the split-cycle engine with an eye toward improving the thermal efficiency of heavy-duty engines. Gurr (2016). Click to enlarge.

Engine 199

Engine Market Exhaust Waste 199

Green Car Congress

OCTOBER 22, 2020

liter four-cylinder engine with 96 kW / 130 PS and three natural gas fuel tanks. The engine of the quasi-monovalent drive system is powered primarily with CNG (Compressed Natural Gas), but can also run on gasoline. This allows the Golf TGI to accelerate powerfully from low engine speeds at any time. WLTP fuel consumption is 4.3–4.1

Gas 415

Gas Available Gasoline-Electric Gas-Electric 415

Green Car Congress

DECEMBER 3, 2014

GMZ Energy, a market leader in the development of high-temperature thermoelectric generation (TEG) solutions, has successfully demonstrated a 1,000W TEG designed for diesel engine exhaust heat recapture in a Bradley Fighting Vehicle. GMZ’s TEG also enables silent generation, muffles engine noise, and reduces thermal structure.

Energy 316

Energy Vehicles Waste Fuel Economy 316

Green Car Congress

OCTOBER 28, 2009

Concept diagram of an SMA heat engine for power generation from waste engine heat. million (subject to final negotiation with DOE) to support building a prototype thermomechanical waste heat recovery system using a Shape Memory Alloy (SMA) heat engine to generate electricity from the heat in automotive exhaust.

Waste 186

Waste GM Engine Michigan 186

Green Car Congress

SEPTEMBER 4, 2013

The concept of the Ricardo Split-Cycle engine. The recuperated engine uses isothermal compression via cryogenic injection to enable significant exhaust to compressed gas heat transfer. Recuperator to transfer heat from exhaust gas to compressed air. Source: Neville Jackson. Click to enlarge.

Engine 249

Engine Fuel Vehicles Waste 249

Green Car Congress

SEPTEMBER 28, 2012

The TEG technology, which converts waste heat from gas exhaust into electric energy and has the potential to improve passenger car fuel efficiency by as much as 5%. TEG & Exhaust System in Lincoln MKT. The TEG developed in that project provided a proof-of-concept for stack-arranged TE engines in a cylindrical form factor.

Fuel Economy 341

Fuel Economy Energy Waste Vehicles 341

Green Car Congress

MAY 26, 2023

According to MAN Engines, all MAN off-road engines from the current product portfolio can be operated with regenerative diesel—also known as HVO (hydrogenated vegetable oil)—in accordance with the EN15940 standard in Europe or the US specification ASTM D975. Marine engines for regenerative diesel have already been approved.

Engine 221

Engine Diesel Exhaust Fuel 221

Green Car Congress

JULY 3, 2009

Cyclone Power Technologies has achieved positive results from performance tests recently conducted on its Waste Heat Engine (WHE) ( earlier post ), and expects the final stage of testing prior to on-site beta installation to begin in July. The WHE is derivative of Cyclone’s external combustion Green Revolution Engine.

Waste 150

Waste Engine Powered Power 150

Green Car Congress

MAY 4, 2009

Comparisons of NO x , CO, soot, and engine brake power using different PS blends with the factory-set injection timings. Researchers at Iowa State University are proposing dissolving waste polystyrene (PS) in biodiesel for use as a diesel engine fuel as a mechanism for energy recovery from the waste plastic. Credit: ACS.

Waste 207

Waste Energy Iowa Diesel 207

Green Car Congress

FEBRUARY 20, 2010

Research on utilizing low-grade heat from sources such as industrial waste streams, geothermal activity, and solar heating has focused on using solid-state thermoelectrics and Stirling engines to harvest low-grade waste heat as electrical energy. Tags: Thermoelectrics Waste Heat Recovery. dela Cruz, John P.

Waste 230

Waste Conversion Carbon Ferrari 230

Green Car Congress

MAY 2, 2011

Organic Rankine Cycle (ORC) can be used to recover low-grade waste heat. When a vehicle is running, the engine exhaust gas states have a wide range of variance. Defining the operational conditions of the ORC that achieve the maximum utilization of waste heat is important. Zhang, B.Y. Zhao and Q.H. 2011.03.041.

Waste 186

Waste Exhaust Universal 2011 186