Green Car Congress

APRIL 8, 2022

Nissan unveiled its prototype production facility for laminated all-solid-state battery (ASSB) cells, which the company aims to bring to market in 2028. This prototype facility, within the Nissan Research Center in Kanagawa Prefecture, is aimed to further promote the development of all-solid-state-batteries.

Nissan 516

Nissan Batteries Battery Production 516

Green Car Congress

JUNE 17, 2023

After three years of intensive studies covering the entire lifecycle of an all-electric aircraft, Tecnam is halting development of the all-electric P-Volt aircraft, mainly due to concerns about current battery technology. The company will continue to explore new emerging technologies.

Volt 539

Volt All-Electric Batteries Battery 539

Green Car Congress

JULY 21, 2021

The results show there is no realistic pathway to full decarbonization of internal combustion engine vehicles, and that only battery and hydrogen fuel-cell EVs have potential to be very low-GHG passenger vehicle pathways. This study uses recent data on industrial-scale battery production and considers regional battery supply chains.

Hydrogen 418

Hydrogen Fuel Batteries Battery 418

Green Car Congress

JULY 14, 2023

The deal includes an order for three of Wabtec’s FLXdrive battery locomotives and a collaboration to test ammonia as a potential clean, alternative fuel to replace diesel. —Vale’s Director of Energy, Ludmila Nascimento Vale and Wabtec will work together on a study to use ammonia as a clean alternative fuel, which does not emit CO 2.

Fuel 195

Fuel Batteries Battery Clean Alternative 195

Green Car Congress

JANUARY 12, 2022

A University of Michigan team has shown that a network of aramid nanofibers, recycled from Kevlar, can enable lithium-sulfur batteries to overcome their Achilles heel of cycle life, delivering an estimated 1,000 real-world cycles. Biomimetic engineering of these batteries integrated two scales—molecular and nanoscale.

Lithium Sulfur 448

Lithium Sulfur Lithium Ion Batteries Battery 448

Green Car Congress

MARCH 2, 2023

Researchers led by the Department of Energy’s Pacific Northwest National Laboratory (PNNL) have extended the capacity and duration of sodium-aluminum batteries. The new sodium-based molten salt battery uses two distinct reactions. The team previously reported a neutral molten salt reaction. of peak charge capacity. —Weller et al.

Molten Salt 396

Molten Salt Grid Design Sodium 396

Green Car Congress

AUGUST 22, 2023

Shortly before the updated EU Battery Regulation comes into force, the chair “Production Engineering of E-Mobility Components” (PEM) of RWTH Aachen University has published a study on the European battery recycling market. billion for the annual processing of around 570,000 tons of battery material.

Batteries 150

Batteries Battery Economy Europe 150

Green Car Congress

OCTOBER 8, 2020

Ipsos’ new 2020 Global Mobility Navigator Study, focusing on Electrification, found global interest remained on par with the numbers from 2019. However, the study reveals there has been an increase in interest in the US and Chinese markets. Source: Ipsos. A growing consumer awareness led to an increased desire to have them in vehicles.

Global 429

Global Electric Vehicles Auto Vehicles 429

Electrek

SEPTEMBER 18, 2023

While colder weather negatively affects the range of Tesla electric vehicles and electric vehicles in general, it may actually be good for the long-term longevity health of EV battery packs, according to a new study. more… The post Tesla battery longevity is better in colder climates, new study shows appeared first on Electrek.

Climate 144

Climate Batteries Battery Tesla 144

Green Car Reports

JANUARY 30, 2023

Reducing the size of EV batteries and generally lowering levels of car ownership and use could have a significant environmental impact, according to a new study. The study, commissioned by the Climate and Community Project, a climate policy think tank, used UC Davis research (first spotted by Green Car Congress).

Davis 159

Davis Batteries Battery Congress 159

Green Car Congress

JANUARY 11, 2022

All-solid-state lithium batteries could address a number of the shortcomings of conventional lithium-ion batteries in advanced applications such as in electric vehicles, which demand high energy densities, fast charging, and long cycle lives. cm 2 ) by annealing the sample in a battery form. —Kobayashi et al.

Batteries 497

Batteries Battery Li-ion F-150 497

Green Car Congress

OCTOBER 6, 2022

Tackling the extremely complex technical questions that battery scientists face requires huge amounts of data to generate AI and machine learning algorithms. —Argonne battery scientist Sue Babinec. For batteries, there are many common types of data, but there’s no uniform way of approaching them. —Noah Paulson.

Batteries 284

Batteries Battery Energy Storage Idaho 284

Green Car Congress

NOVEMBER 9, 2022

Since its commissioning earlier this year, the Demo Plant has verified a 163% increase in actual leach processing capacity over the 500 kg/day planned capacity and 99% leach extraction efficiency of lithium-ion battery cathode waste material using RecycLiCo’s patented closed-loop process.

Lithium Ion 345

Lithium Ion Batteries Battery Waste 345

Green Car Congress

JUNE 17, 2023

Minah Lee of the Energy Storage Research Center at the Korea Advanced Institute of Science and Technology (KIST) has developed a chemical activation strategy of magnesium metal that enables efficient operation of magnesium batteries in common electrolytes that are free of corrosive additives and can be mass-produced. 2c08672

Batteries 493

Batteries Battery Energy Storage Re-Charge 493

Green Car Congress

FEBRUARY 21, 2021

A research team from Japan has recently developed a novel electrode material for all-solid-state batteries (ASSBs) by combining lithium sulfate and lithium ruthenate, which results in improved performance. However, they have never been applied to all-solid-state batteries. —Nagao et al.

Li-ion 536

Li-ion Batteries Battery Lithium Ion 536

Green Car Congress

AUGUST 2, 2022

A new study from Juniper Research forecasts that the volume of electric vehicle battery pack shipments will reach 30 million in 2027 up from 10 million in 2022. Global number of electrified vehicle battery packs shipped in 2027: 30 Million. This includes solid-state batteries and new chemical mixes.

Commercial 412

Commercial Batteries Battery Vehicles 412

Green Car Congress

APRIL 8, 2021

If fast charging is available, the competitiveness of battery electric trucks compared with diesel trucks can actually improve with larger trucks, according to a new study by Björn Nykvist and Olle Olsson from the Stockholm Environment Institute (SEI). In other words, the truck segment is very sensitive to battery specifications.

Li-ion 468

Li-ion Batteries Battery Electric 468

Green Car Congress

JANUARY 25, 2023

A crucial aspect of electrified transportation is new demand for metals, and specifically the most non-replaceable metal for EV batteries—lithium. Even if the car-centricity of the US transportation system continues, limiting the size of EV batteries alone can cut lithium demand by as much as 42%.

Batteries 397

Batteries Battery Vehicles Cars 397

Green Car Congress

AUGUST 29, 2022

A new University of Michigan study finds that making the switch to all-electric mail-delivery vehicles would lead to far greater reductions in greenhouse gas emissions than previously estimated by the US Postal Service (USPS). The Postal Service has not commented on the U-M study. Earlier post.). Woody et al. The USPS estimate was 10.3

District of Columbia 435

District of Columbia Fleet Gas-Electric Gasoline-Electric 435

Green Car Congress

NOVEMBER 1, 2021

Researchers from DGIST (Gyeongbuk Institute of Science and Technology, Republic of Korea) have demonstrated lithium metal battery cycling over a wide range of temperatures (2-60°C) by adopting a new dilution technique for high concentration electrolytes. —Prof Hongkyung Lee. 2021.131889.

Li-ion 221

Li-ion Range Batteries Battery 221

Green Car Congress

DECEMBER 6, 2021

Using a microscopic method for measuring electrical potential, a team of scientists at Sandia National Laboratories may have discovered how to identify rate-limiting processes in solid-state batteries. Solid-state batteries employ solid electrolytes instead of electrochemical gels and liquids and generally power small electronics.

Li-ion 481

Li-ion Batteries Battery Lithium Ion 481

Green Car Congress

AUGUST 20, 2023

Researchers in China are investigating the effect of low-velocity impact loads on structurally embedded Li-ion batteries in vehicles. A paper on their study is published in the Journal of Power Sources. —Li et al. 2023.233509

Li-ion 195

Li-ion Lithium Ion Batteries Battery 195

Green Car Congress

DECEMBER 5, 2021

With capacity for 22 passengers, Cit-e has 90 kWh of batteries and can run up to 50 km/h. Cit-e is equipped with LMP (Lithium Metal Polymer) batteries from Blue Solutions, the Bolloré Group's subsidiary specialized in batteries. The cost per passenger per km is particularly low. Cit-e Autonomous.

Batteries 501

Batteries Battery France Electric 501

Green Car Congress

DECEMBER 12, 2022

The study is published in the Journal of the American Chemical Society. In an earlier study, the researchers reported ∼3.5 In an earlier study, the researchers reported ∼3.5 This work could open up widely available, low-cost graphitic materials for high-capacity alkali metal/Cl 2 batteries. 2c07826.

Recharge 243

Recharge Batteries Battery Taiwan 243

Green Car Congress

DECEMBER 23, 2021

Researchers at the Department of Energy’s SLAC National Accelerator Laboratory and Stanford University may have found a way to revitalize rechargeable lithium batteries, potentially boosting the range of electric vehicles and battery life in next-gen electronic devices. A study on the work is published in Nature.

Lithium Ion 385

Lithium Ion Batteries Battery Li-ion 385

Green Car Congress

JULY 7, 2023

Under the framework of the MOU, the two companies will work together to explore opportunities to jointly develop EV battery recycling businesses in the UK. This will include the joint development of a UK supply chain of end-of-life lithium-ion batteries for recycling. Earlier post.)

Batteries 195

Batteries Battery Lithium Ion Green 195

Green Car Congress

JUNE 7, 2020

Scientists from the Daegu Gyeongbuk Institute of Science and Technology, Korea, have developed a novel silica-based cathode for lithium–sulfur batteries, thereby enabling the realization of batteries that can last for more than 2,000 charge/discharge cycles. However, using sulfur in batteries is tricky for two reasons.

Lithium Sulfur 400

Lithium Sulfur Batteries Battery Low Cost 400

Green Car Congress

OCTOBER 31, 2022

The Responsible Battery Coalition, in partnership with the University of Michigan Center for Sustainable Systems, launched a comprehensive research project to compare the total cost of ownership of gas and electric vehicles (EVs). Gregory Keoleian, Director of the Center for Sustainable Systems at the University of Michigan.

Michigan 199

Michigan Gas-Electric Gas Batteries 199

Green Car Congress

JANUARY 31, 2022

Penn State researchers have proposed cold sintering as an improved method of solid-state battery production that enables multi-material integration for better batteries. This prevents fire-causing short circuits, but also in theory it enables solid-state batteries to have higher energy density. —Zane Grady, lead author.

Batteries 370

Batteries Battery Production Sodium 370

Green Car Congress

APRIL 9, 2023

With the current global projection of over 130 million electric vehicles (EVs), there soon will be a need for battery waste management. With the current global projection of over 130 million electric vehicles (EVs), there soon will be a need for battery waste management. La 3 Zr 1.5 La 3 Zr 1.5 202202361

Li-ion 277

Li-ion Batteries Battery Lithium Ion 277

Green Car Congress

JULY 14, 2022

Cheap and abundant, sodium is a promising candidate for new battery technology. However, the limited performance of sodium-ion batteries has hindered large-scale application. Sodium-ion batteries (NIBs) have attracted worldwide attention for next-generation energy storage systems. A paper on the work appears in Nature Energy.

Sodium 334

Sodium Li-ion Batteries Battery 334

Green Car Congress

AUGUST 2, 2023

Each main line has the capacity to process up to 10,000 tonnes of lithium-ion battery material per year. Germany represents the largest market for both battery manufacturing scrap and the expected supply of end-of-life lithium-ion batteries in Europe. A definitive feasibility study for the project is currently underway.

Li-ion 280

Li-ion Lithium Ion Batteries Battery 280

Green Car Congress

AUGUST 22, 2019

The discovery, published in Nature , challenges the conventional belief that lithium metal batteries fail because of the growth of the solid electrolyte interphase (SEI) between the lithium anode and the electrolyte. The findings could pave the way for bringing rechargeable lithium metal batteries from the lab to the market.

San Diego 320

San Diego Batteries Battery Lithium Ion 320

Green Car Congress

FEBRUARY 14, 2023

billion to build the country’s first automaker-backed LFP battery plant, offering customers a second battery technology within Ford’s EV lineup. Ford is now commited to build both nickel cobalt manganese (NCM) and lithium iron phosphate (LFP) batteries in the US. Limited (CATL), the world’s leading battery manufacturer.

Michigan 259

Michigan Ford Building Batteries 259

Green Car Congress

NOVEMBER 6, 2022

Solid-state sodium-ion battery company LiNa Energy has closed out a £3-million (US$3.4-million) LiNA will also build a presence in India where LiNa has signed an MoU with Social Alpha to optimise product development for the India market and oversee battery cell testing and future pilot projects. Earlier post.)

Sodium 300

Sodium Companies Energy Batteries 300

Green Car Congress

FEBRUARY 8, 2022

In a recent analysis, Fraunhofer ISI concludes that battery-electric drives will become established in heavy-duty applications in the commercial vehicle sector and that fuel cells will remain a niche application. The decisive factor for the switch to battery-electric vehicles is the energy cost advantage compared to hydrogen and diesel.

Hydrogen 448

Hydrogen Energy Batteries Battery 448

Green Car Congress

MAY 10, 2023

Glencore International AG, a wholly owned subsidiary of Glencore plc, a leading producer, recycler, and marketer of nickel and cobalt for the production of electric vehicle batteries, and Li-Cycle Holdings Corp., A Li-Cycle Hub is a hydrometallurgical facility that processes black mass from lithium-ion batteries.

Li-ion 186

Li-ion Europe Lithium Ion Batteries 186